IllustrationDRIVING ON LOCAL CITY STREET, WHEN RIGHT FRONT TIRE BLOWS OUT. BLOW HAPPENED BECAUSE RIGHT FRONT COIL SPRING SHEERED INTO TWO PIECES AND CUT INTO RIGHT FRONT TIRE CAUSING BLOWOUT. RIGHT FRONT TIRE REPLACED AND NEW COIL SPRING INSTALLED ON RIGHT FRONT SUSPENSION. YES, I HAVE THE FAILED COIL SPRING IN MY POSSESSION. *TR
2003 Saab 9-3
Owner reports · Recalls · Investigations
More warning signs than most 9-3 years
Owner complaints for the 2003 Saab 9-3 are substantially higher than the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
3225–50K
4050–75K
2475–100K
12100–150K
6150K+
167 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports6 fire reports13 injury reports
What owners actually said
212 reportsWHILE BACKING UP OUT OF A DRIVEWAY ON A FLAT LEVEL SURFACE THE VEHICLES FRONT PASSENGER COIL SPRING BROKE IN TWO PIECES. THE CAR WAS RENDERED UN-DRIVABLE AND WAS TOWED TO A DEALERSHIP. THE PART WAS REPLACED. THE VEHICLE IS A 2003 SAAB 9-3 WITH ONLY 41,400 MILES. *TR
TL*THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW MADE A GRINDING SOUND AND WOULD NO LONGER GO UP OR DOWN. THE DEALER STATED THAT THE POWER WINDOW FAILED DUE TO FREEZING RAIN. THE WINDOW WAS REPAIRED. THE CURRENT MILEAGE WAS 34,895 AND FAILURE MILEAGE WAS 34,700. UPDATED 3/5/08 *CN THE …
Read full complaint
TL*THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW MADE A GRINDING SOUND AND WOULD NO LONGER GO UP OR DOWN. THE DEALER STATED THAT THE POWER WINDOW FAILED DUE TO FREEZING RAIN. THE WINDOW WAS REPAIRED. THE CURRENT MILEAGE WAS 34,895 AND FAILURE MILEAGE WAS 34,700. UPDATED 3/5/08 *CN THE CONSUMER STATED THE DEALERSHIP OFFERED A GMC SMART CURE WHICH IS A PACKAGE COIL CHANGE AND TIRE ROTATION AT NO COST. UPDATED 03/05/08 *TR
I AM THE OWNER OF A 2003 SAAB 9-3. MY MOONROOF SHATTERED WITHOUT ANY EXPLANATION. AS I WAS DRIVING MY CAR, IT SOUNDED LIKE AN EXPLOSION. GLASS RAINED DOWN ON ME. THERE WAS NO OBJECT THAT HIT THE MOONROOF. IT SIMPLY SHATTERED. IS THIS A PROBLEM FOR THIS MODEL? *TR
AFTER THE OUTSIDE TEMPERATURE DROPS BELOW 40F, THE VEHICLE DISPLAYS A MALFUNCTION LIGHT ON THE DASHBOARD. UPON INVESTIGATION, THE DIAGNOSIS IS A FAILURE ON THE SECONDARY AIR PUMP AND CHECK VALVE. THIS IS AN EMISSIONS SYSTEM. THE PUMP WAS ADDED TO IMPROVE PERFORMANCE UNDER EMISSIONS TESTING. THE VEHICLE WARRANTY HAS EXPIRED AND…
Read full complaint
AFTER THE OUTSIDE TEMPERATURE DROPS BELOW 40F, THE VEHICLE DISPLAYS A MALFUNCTION LIGHT ON THE DASHBOARD. UPON INVESTIGATION, THE DIAGNOSIS IS A FAILURE ON THE SECONDARY AIR PUMP AND CHECK VALVE. THIS IS AN EMISSIONS SYSTEM. THE PUMP WAS ADDED TO IMPROVE PERFORMANCE UNDER EMISSIONS TESTING. THE VEHICLE WARRANTY HAS EXPIRED AND SAAB IS NOT COVERING THIS ITEM UNDER EMISSIONS WARRANTY. THIS IS AN EXTREMELY COMMON ISSUE, MANY SAAB OWNERS ARE COMPLAINING ABOUT THE ISSUE. *TR
TL*THE CONTACT OWNS A 2003 SAAB 9-3. THE DRIVER'S SEAT BELT DOES NOT RETRACT AND REMAINS LOOSE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER, BUT HE DISCOVERED NHTSA CAMPAIGN ID NUMBER 04V226000 (SEAT BELTS:FRONT:RETRACTOR). THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT FELT THAT IT …
Read full complaint
TL*THE CONTACT OWNS A 2003 SAAB 9-3. THE DRIVER'S SEAT BELT DOES NOT RETRACT AND REMAINS LOOSE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER, BUT HE DISCOVERED NHTSA CAMPAIGN ID NUMBER 04V226000 (SEAT BELTS:FRONT:RETRACTOR). THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT FELT THAT IT WAS UNSAFE TO DRIVE A VEHICLE WITH A MALFUNCTIONING SEAT BELT. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 51,000.
IN, APPROXIMATELY, THE LAST FOUR MONTHS, MY ENGINE WARNING LIGHT MY ENGINE WARNING LIGHT HAS GONE ON. IN CONTACTING THE DEALER, THE FIRST TIME, THE GAS CAP HAD NOT BEEN PROPERLY PUT BACK ON. THE TWO SUBSEQUENT TIMES, I AM CERTAIN THAT IT HAD BEEN. AFTER THE THIRD TIME, I TOOK THE VEHICLE TO THE DEALER, THINKING IT WAS EITHER T…
Read full complaint
IN, APPROXIMATELY, THE LAST FOUR MONTHS, MY ENGINE WARNING LIGHT MY ENGINE WARNING LIGHT HAS GONE ON. IN CONTACTING THE DEALER, THE FIRST TIME, THE GAS CAP HAD NOT BEEN PROPERLY PUT BACK ON. THE TWO SUBSEQUENT TIMES, I AM CERTAIN THAT IT HAD BEEN. AFTER THE THIRD TIME, I TOOK THE VEHICLE TO THE DEALER, THINKING IT WAS EITHER THE O2 SENSOR, OR THE GAS CAP. I WAS TOLD, BY THE SERVICE ADVISOR, THAT THERE WAS (I BELIEVE HE SAID) A VAPOR LEAK. IT WOULD REQUIRE PUTTING ON A REDESIGNED GAS CAP. THE SERVICE WRITE-UP STATED IT WAS "REPLACED WITH AN UPDATED GAS CAP". *TR
WHEN CAR IS LOCKED AND TRUNK LID IS OPENED WITH THE KEY FOR THE CAR ALARM WILL SOUND OFF, THE REAR TRUNK HANDLE ALSO ONLY WORKS WHEN REAR TRUNK HATCH IS ACTUALLY OPENED. *TR
MOON ROOF THINKS IT IS PINCHING AND RETRACTS WHEN ATTEMPTING TO CLOSE. *TR
I HAVE OWNED 4 DIFFERENT SAAB MODELS AND I HAVE ALLAYS HAD HEATED SEATS. THIS LAST WINTER WHILE WEARING A SUIT AND WOOL OVERCOAT I FELT A BURNING SENSATION ON MY BACK. I IMMEDIATELY TURNED MY SEAT OFF, WHEN I GOT OUT OF THE CAR THERE WHERE COIL BURN MARKS IN MY LEATHER SEAT. THERE HAS TO BE A SAFETY ISSUE IF A HEATED SEAT COI…
Read full complaint
I HAVE OWNED 4 DIFFERENT SAAB MODELS AND I HAVE ALLAYS HAD HEATED SEATS. THIS LAST WINTER WHILE WEARING A SUIT AND WOOL OVERCOAT I FELT A BURNING SENSATION ON MY BACK. I IMMEDIATELY TURNED MY SEAT OFF, WHEN I GOT OUT OF THE CAR THERE WHERE COIL BURN MARKS IN MY LEATHER SEAT. THERE HAS TO BE A SAFETY ISSUE IF A HEATED SEAT COIL CAN BURN THROUGH LEATHER, AND CAN BE FELT THROUGH AN INCH OF WOOL... *TR
Official recalls
407V087000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
05V236000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
04V540000 · Engine And Engine Cooling
Oct 20, 2004
ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.
Consequence & remedy
Consequence: IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.
Remedy: DEALERS WILL UPDATE THE ENGINE MANAGEMENT SYSTEM. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
04V226000 · Seat Belts:front:retractor
May 11, 2004
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04008 · Engine Stall
Opened Mar 19, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Electrical System:ignition:module
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
Engine And Engine Cooling
ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A GLOBAL CUSTOMER SATISFACTION CAMPAIGN TO CORRECT TWO DISTINCT ENGINE MANAGEMENT SOFTWARE CONDITIONS THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 12 THOUSAND SAAB 9-3 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS.THE REMEDIES FOR BOTH CONDITIONS INVOLVED REPROGRAMMING THE ENGINE MANAGEMENT SOFTWARE. GM HAS STATED THAT NEITHER CONDITION CAN OCCUR DURING VEHICLE ACCELERATION AND IN BOTH CASES THE VEHICLE CAN BE SAFELY CONTROLLED AND IMMEDIATELY RESTARTED AFTER ENGINE STALL. FOR THESE REASONS, AMONG OTHERS, GM BELIEVES THAT THE SUBJECT VEHICLES DO NOT CONTAIN A SAFETY-RELATED DEFECT. TO DATE, ODI HAS NOT RECEIVED ANY REPORTS OF CRASHES ALLEGEDLY DUE TO STALLING OF THE SUBJECT VEHICLES.NEVERTHELESS, ODI BELIEVES THAT THE CIRCUMSTANCES ASSOCIATED WITH THESE STALLING CONDITIONS CAN HAVE A SIGNIFICANT ADVERSE EFFECT ON SAFETY.ODI BELIEVES THAT THE CONDITIONS ADDRESSED BY GM?S CUSTOMER SATISFACTION CAMPAIGN WOULD HAVE BEEN MORE APPROPRIATELY TREATED AS A SAFETY RECALL.HOWEVER, BASED ON THE VERY HIGH COMPLETION RATES FOR THAT CAMPAIGN (83.3 PERCENT OVERALL) AND GM?S LETTER DESCRIBING ITS FUTURE APPROACH TO THE CONSIDERATION OF STALLING ISSUES, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED.THEREFORE, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SEE THE ATTACHED REPORT.
PE03059 · Engine Stall
Opened Dec 30, 2003 · Closed Mar 19, 2004
Status: closed (inferred from source dates) · Electrical System:ignition:module; Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Additional source detail variants (2)
Electrical System:ignition:module
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.
Engine And Engine Cooling
THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN JANUARY 2003, SAAB DISABLED THE DUAL MASS FLYWHEEL (DMF) PROTECTION (INTENDED ONLY FOR MANUAL TRANSMISSION VEHICLES) IN SUBJECT VEHICLES WITH 175 HP ENGINES.ACCORDING TO SAAB, DMF PROTECTION IN A VEHICLE WITH AUTOMATIC TRANMSSION MAY CAUSE THE ENGINE TO STALL WHEN RELEASING THE ACCELERATOR PEDAL WHEN COMING TO A STOP OR WHEN THE VEHICLE IS COASTING. IN AUGUST 2003, SAAB REVISED THE ECM SOFTWARE IN THE 210 HP ENGINES TO ADDRESS A CONCERN WITH ENGINE STALL DURING ABORTED TAKE-OFF MANUEVERS.ACCORDING TO SAAB, ABORTED TAKE-OFF STALLS OCCUR WHEN THE VEHICLE IS STATIONARY AND IN DRIVE GEAR, THE ENGINE IS IDLING, AND THE ACCELERATOR PEDAL IS PULSED (PRESSED QUICKLY AND RELEASED IN LESS THAN 1 SECOND). THERE HAVE BEEN 553 NON-DUPLICATIVE COMPLAINTS TO ODI AND SAAB ALLEGING ENGINE STALL IN THE SUBJECT VEHICLES.THERE IS ONE REPORTED CRASH AND NO INJURIES.SAAB INITIATED A CUSTOMER SATISFACTION PROGRAM IN EARLY FEBRUARY TO REPROGRAM THE ECM'S.SAAB REPORTED THAT 36% OF THE VEHICLES HAD BEEN SERVICED IN THE PROGRAM AS OF MARCH 9, 2004.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND SAAB'S ACTIONS TO ADDRESS THE PROBLEMS.