NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
13 reportsClear category filter94,000 miles · May 26, 2009
Electrical SystemEngine And Engine Cooling
SAAB 2000 9-3 TURBO CONTINUED TO BE PLAGUED WITH NO START PROBLEMS (RECALLED ITEM REPAIRED BY SAAB DEALERSHIP. OIL SLUDGE AS A RESULT OF PROBLEMS RELATED TO RECALL CAUSED ENGINE/TURBO TO FAIL AT 94,000 ON INTERSTATE HIGHWAY. CAR HAS BEEN TOWED TO MECHANIC. SERVICE AT DEALERSHIP IS DOCUMENTED AND SHOULD HAVE PREVENTED THIS T…
Read full complaint
SAAB 2000 9-3 TURBO CONTINUED TO BE PLAGUED WITH NO START PROBLEMS (RECALLED ITEM REPAIRED BY SAAB DEALERSHIP. OIL SLUDGE AS A RESULT OF PROBLEMS RELATED TO RECALL CAUSED ENGINE/TURBO TO FAIL AT 94,000 ON INTERSTATE HIGHWAY. CAR HAS BEEN TOWED TO MECHANIC. SERVICE AT DEALERSHIP IS DOCUMENTED AND SHOULD HAVE PREVENTED THIS TYPE OF ENGINE. TURBO FAILURE. *TR
NHTSA ODI #10269966
77,715 miles · Oct 22, 2008
Electrical SystemEngine And Engine Cooling
2000 9-3 HAD THE IGNITION MODULE RECALL DONE A FEW YEARS AGO. WHILE DRIVING AT 45 MPH THE MOTOR STOPPED. LOST ALL ELECTRICAL POWER. CAR WOULD NOT RESTART. THE REPAIR SHOP REPLACED THE CATALYTIC BECAUSE IT WAS PLUGGED. THEY SAID IT COULD BE CAUSED BY THE IGNITION MODULE. *TR
NHTSA ODI #10246362
100,000 miles · Jul 29, 2008
Engine And Engine Cooling
I BOUGHT A USED 2.0L 2000 SAAB 9-3 A YEAR AGO. SINCE THEN, THE CAR HAS HAD PROBLEMS THAT MANY OTHER OWNERS OF THIS SIMILAR MAKE/MODEL/YEAR HAVE HAD. I'VE REPLACED THE THROTTLE HOUSING, SERPENTINE BELT, BELT TENSIONER, CRANKSHAFT SENSOR, AND MOST RECENTLY THE WATER PUMP. NOW, I'M GETTING A CHECK ENGINE LIGHT FAULT CODE P1312 AND…
Read full complaint
I BOUGHT A USED 2.0L 2000 SAAB 9-3 A YEAR AGO. SINCE THEN, THE CAR HAS HAD PROBLEMS THAT MANY OTHER OWNERS OF THIS SIMILAR MAKE/MODEL/YEAR HAVE HAD. I'VE REPLACED THE THROTTLE HOUSING, SERPENTINE BELT, BELT TENSIONER, CRANKSHAFT SENSOR, AND MOST RECENTLY THE WATER PUMP. NOW, I'M GETTING A CHECK ENGINE LIGHT FAULT CODE P1312 AND P1334, WHICH POINTS TO THE DIRECTION IGNITION MODULE. I KNOW THAT THERE WAS A RECALL OF THE DIRECT IGNITION MODULE IN CERTAIN SAABS FOR THIS MAKE/MODEL/YEAR, BUT IT'S ODD THAT MY CAR COINCIDENTALLY HAPPENS TO HAVE THE SAME PROBLEM. I'M THINKING THAT THE PROBLEM IS LARGER THAN INITIALLY ANTICIPATED WITH THE ORIGINAL RECALL. *TR
NHTSA ODI #10236271
106,178 miles · May 7, 2008
Engine And Engine CoolingEquipment
2000 SAAB 9-3 WITH SEVERAL PROBLEMS AFTER REPAIRS WERE MADE. CONSUMER STATES THAT AFTER THE SERPENTINE BELT WAS REPLACED. THE NEW BELT SHRED. DEALER SAID TO PAY FOR THE SECOND REPAIR AND THEN GET REIMBURSED. *KB THE CONSUMER ALSO STATED FOLLOWING THE REPLACEMENT OF THE WATER PUMP WHICH FAILED TWICE, THE VEHICLE DEVELOPED A RAT…
Read full complaint
2000 SAAB 9-3 WITH SEVERAL PROBLEMS AFTER REPAIRS WERE MADE. CONSUMER STATES THAT AFTER THE SERPENTINE BELT WAS REPLACED. THE NEW BELT SHRED. DEALER SAID TO PAY FOR THE SECOND REPAIR AND THEN GET REIMBURSED. *KB THE CONSUMER ALSO STATED FOLLOWING THE REPLACEMENT OF THE WATER PUMP WHICH FAILED TWICE, THE VEHICLE DEVELOPED A RATTLING SOUND. THE DEALER STATED THE PROBLEM WAS THE CLUTCH, HOWEVER THE CONSUMER DISAGREED WITH THEIR FINDINGS. THE DEALER THEN INSTALLED AN AC COMPRESSOR BRACKET INCORRECTLY WHICH RESULTED IN ANOTHER FAILURE OF THE SERPENTINE BELT. THE DEALER STATED THE FAILURE OF THE SERPENTINE BELT WAS NOT A RESULT OF IT BEING FAULTY, IT WAS DUE TO THE BELT BEING DAMAGED OR CRACKED. THE DEALER STATED THE AIR CONDITIONING BRACKET HAD BROKEN AND IN DOING SO, IT THREW THE BELT OFF OF THE PULLEYS. THE AC BRACKET WAS THE CASUAL PART FAILURE NOT THE BELT. THE BELT WAS DAMAGED WHEN IT CAME OFF. THE OIL PUMP RING AND CRANKSHAFT SEAL WERE REPLACED DUE TO AN OIL LEAK AT THE PUMP. *JB
NHTSA ODI #10227335
104,000 miles · May 6, 2008
Engine And Engine Cooling
MY CAR STOPPED ON MASS TURNPIKE AROUND MIDNIGHT. I HAD VEHICLE TOWED TO THE NEAREST SAAB DEALER. THEIR DIAGNOSIS WAS THE OIL SLUDGE. EVEN AT THAT TIME THE DEALER DID NOT MENTION ANYTHING ABOUT SPECIAL WARRANTY THE SAAB ANNOUNCED IN 2005. I HAVE NEVER RECEIVED ANY INFORMATION FROM THE SAAB AS WELL. AFTER I SEARCH THE INTERNET I F…
Read full complaint
MY CAR STOPPED ON MASS TURNPIKE AROUND MIDNIGHT. I HAD VEHICLE TOWED TO THE NEAREST SAAB DEALER. THEIR DIAGNOSIS WAS THE OIL SLUDGE. EVEN AT THAT TIME THE DEALER DID NOT MENTION ANYTHING ABOUT SPECIAL WARRANTY THE SAAB ANNOUNCED IN 2005. I HAVE NEVER RECEIVED ANY INFORMATION FROM THE SAAB AS WELL. AFTER I SEARCH THE INTERNET I FOUND OUT ABOUT THE SPECIAL WARRANTY. I FILED A CLAIM AND SUBMITTED ALL OIL CHANGE RECEIPTS I HAD ( IT IS THEIR REQUIREMENT TO QUALIFY FOR THE SPECIAL WARRANTY). THE CAR IS ALMOST 8YEARS OLD. THE ONLY THREE RECEIPTS I DID NOT SUBMIT WERE WHEN THE CAR HAD 10,000, 20,000, AND 30,000 MILES. MY CLAIM WAS REJECTED BASED ON THESE 3 MISSING OILCHANGE RECEIPTS. I AM A SECOND OWNER THEREFORE I DO NOT HAVE THESE RECORDS AND SAAB REFUSED TO PROVIDE ME WITH THE PREVIOUS OWNER'S NAME ( PRIVACY ACT) AND THEY ALSO REFUSED TO CONTACT THE PREVIOUS OWNER ON MY BEHALF. THE MILEAGE ON THE CAR AT THE TIME OF THE ENGINE FAILURE WAS 104,000 MILES. IT IS OBVIOUS THAT THE OIL CHANGE IN THE FIRST YEAR OF THE CAR HAD NOTHING TO DO WITH THE PROBLEM I HAVE EXPERIENCED. THE CAR WOULD NOT DRIVE FOR THE NEXT 7 YEARS. THE PEOPLE IN THE SAAB'S SPECIAL WARRANTY DEPT. WERE ARROGANT AND TOTALLY UNPROFESSIONAL. THEIR RESPONSE TO ME WAS " BUY A NEW CAR". AS OF NOW MY CAR IS UNDRIVABLE AND HAS NO VALUE. I STRONGLY FEEL THAT SAAB CORP. SHOULD TAKE CARE OF THAT PROBLEM UNDER THE SPECIAL WARRANTY. IF YOU ARE UNABLE TO HELP ME PLEASE DIRECT ME TO THE RIGHT PLACE. THAT CAR COST ME SO MUCH MONEY AND I REFUSE TO ACCEPT THEIR DECISION. *TR
NHTSA ODI #10226768
111,180 miles · Apr 24, 2008
Engine And Engine CoolingEquipment
THE SERPENTINE BELT ON MY SAAB 9-3, MODEL YEAR 2000 HAS FAILED 3 TIMES ON ME. THE LAST TIME THE SERPENTINE BELT DISINTEGRATED INTO TINY PIECES WHILE THE CAR WAS DRIVEN AND ALMOST LED TO AN ACCIDENT. THIS HAPPENED LESS THAN 6 MONTHS AND 5,000 MILES AFTER THE BELT WAS REPLACED. ACCORDING TO THE REPAIR FACILITY THE DISINTEGRATION …
Read full complaint
THE SERPENTINE BELT ON MY SAAB 9-3, MODEL YEAR 2000 HAS FAILED 3 TIMES ON ME. THE LAST TIME THE SERPENTINE BELT DISINTEGRATED INTO TINY PIECES WHILE THE CAR WAS DRIVEN AND ALMOST LED TO AN ACCIDENT. THIS HAPPENED LESS THAN 6 MONTHS AND 5,000 MILES AFTER THE BELT WAS REPLACED. ACCORDING TO THE REPAIR FACILITY THE DISINTEGRATION WAS DUE TO THE IDLER PULLEY SEIZURE AND THEY CLAIM IT HAPPENS FREQUENTLY ON SUCH CARS. *TR
NHTSA ODI #10225625
97,780 miles · Aug 28, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 SAAB 9-3. AT 68,359 MILES, THE ENGINE WAS REBUILT DUE TO A BLOWN PISTON. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. FIFTEEN MONTHS LATER, THE ENTIRE ENGINE HAD TO BE REBUILT FOR THE SAME FAILURE. WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND THE ENGINE SUDDENLY FAILED. TH…
Read full complaint
TL*THE CONTACT OWNS A 2000 SAAB 9-3. AT 68,359 MILES, THE ENGINE WAS REBUILT DUE TO A BLOWN PISTON. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. FIFTEEN MONTHS LATER, THE ENTIRE ENGINE HAD TO BE REBUILT FOR THE SAME FAILURE. WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND THE ENGINE SUDDENLY FAILED. THE VEHICLE WAS REPAIRED, BUT THE CONTACT BELIEVES THAT THE MANUFACTURER SHOULD CONSIDER THIS A RECALL BECAUSE OF THE FREQUENCY OF THE FAILURES. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 97,780.
NHTSA ODI #10200985
54,000 miles · Sep 20, 2006
Engine And Engine CoolingFire
CONSUMER'S 2002 SAAB 9-3'S ENGINE CAUGHT ON FIRE WHILE IT WAS BEING DRIVEN. *KB THE MANUFACTURER WAS CONTACTED BUT THEY REFUSED TO PROVIDE ANY ASSISTANCE BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. *NM
NHTSA ODI #10169111
93,118 miles · Apr 21, 2006
Electrical SystemEngine And Engine Cooling
SINCE PURCHASING MY 2000 SAAB 9-3 [XXX] IN 2003, I HAVE SPENT $9,000 IN VEHICLE REPAIRS WHICH HAVE SUBSEQUENTLY BECOME "RECALL NOTICES" ISSUED FROM SAAB CARS USA. THE VEHICLE'S ENGINE FAILED FALL 2004 - WITH SUBSEQUENT REPAIR COVERAGE UNDER A RECALL NOTICE ISSUED 5/17/05. THE IGNITION DISCHARGE MODULE FAILED IN 7/05, WITH REPAIR…
Read full complaint
SINCE PURCHASING MY 2000 SAAB 9-3 [XXX] IN 2003, I HAVE SPENT $9,000 IN VEHICLE REPAIRS WHICH HAVE SUBSEQUENTLY BECOME "RECALL NOTICES" ISSUED FROM SAAB CARS USA. THE VEHICLE'S ENGINE FAILED FALL 2004 - WITH SUBSEQUENT REPAIR COVERAGE UNDER A RECALL NOTICE ISSUED 5/17/05. THE IGNITION DISCHARGE MODULE FAILED IN 7/05, WITH REPAIRS SUBSEQUENTLY COVERED THROUGH AN IDM RECALL NOTICE ISSUED 3/31/06. AT THE TIME OF THE IDM FAILURE IN 7/05, THE SAAB DEALERSHIP ALSO DIAGNOSED CATALYTIC CONVERTER FAILURE IN THE VEHICLE. DO THE MAJOR MECHANICAL ISSUES THAT EXIST WITH THIS VEHICLE CAUSE A CASCADE OF EVENTS WHICH HAVE DAMAGED THE CATALYTIC CONVERTER, NOW REQUIRING REPLACEMENT? *NM *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10155805
72,000 miles · Jun 6, 2005
Engine And Engine Cooling
EXPERIENCED ENGINE FAILURE DUE TO SLUDGE IN ENGINE. TOLD BY WARRANTY COMPANY WARRANTY VOIDED DUE TO SLUDGE IN ENGINE. MONTHS LATER SAAB SEND OUT NOTICE STATING ENGINE FAILURE DUE TO SLUDGE, EXTENDS WARRANTY AND STILL DENIES CLAIM.
NHTSA ODI #10124371
NHTSA investigations
1PE05017 · Engine Stall/ Engine Compartment Fires
Opened Apr 7, 2005 · Closed Sep 23, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (6)
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Illustration