Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 53 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Forward Collision Avoidance. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports2 injury reports
What owners actually said
53 reports
Mileage unknown · Dec 26, 2024
Unknown Or Other
The heat pump compressor had a loud noise for days, similar to a jet engine. On December 13, 2024, while the vehicle was being driven in freezing temperatures, the heat pump compressor made different noise that sounded that internal pieces were being broken. After that, the dashboard showed the following error "Thermal system fa…
Read full complaint
The heat pump compressor had a loud noise for days, similar to a jet engine. On December 13, 2024, while the vehicle was being driven in freezing temperatures, the heat pump compressor made different noise that sounded that internal pieces were being broken. After that, the dashboard showed the following error "Thermal system fault detected. Service it if the problem persists". After this, there was no heat available for the cabin. Service center replaced the compressor under warranty.
NHTSA ODI #11632559
Mileage unknown · Oct 9, 2024
Steering
Steering wheel vibrates back and forth when driving at highway speeds and following the flow of traffic. The shaking makes my hands and wrists numb after a few minutes of driving at speed. The car becomes uncomfortable to steer and keep straight at speed. Rivian Service Center attempted 1 repair (alignment and wheel rebalance…
Read full complaint
Steering wheel vibrates back and forth when driving at highway speeds and following the flow of traffic. The shaking makes my hands and wrists numb after a few minutes of driving at speed. The car becomes uncomfortable to steer and keep straight at speed. Rivian Service Center attempted 1 repair (alignment and wheel rebalance) but the problem persists. At the second service visit, the Service Center mentions that an engineering investigation is ongoing, and that there is nothing the service center can do at this time.
NHTSA ODI #11619023
Mileage unknown · Aug 19, 2024
Exterior Lighting
Driver side high beam lights are out or malfunction. No warning on dashboard except for "Adaptive High Beam not working." When the high beam assistance is set to Off, and I turn on the high beam manually, there are no warnings about the high beam malfunction whatsoever.
Rivian Automotive, LLC (Rivian) is recalling certain 2025-2026 R1S and R1T vehicles. One or both front turn signals may fail to illuminate and flash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Turn signals that do not function properly increase the risk of a crash.
Remedy: Rivian will inspect and replace the front turn signals as necessary, free of charge. Owner notification letters are expected to be mailed September 29, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1833. This is an expansion of Recall 25V387. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 31, 2026.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Seat Belts:critical Fasteners
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.
Consequence & remedy
Consequence: The toe link joint may separate, increasing the risk of a crash.
Remedy: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles operating a software version prior to 2025.18.30. The Hands-Free Highway Assist (HWA) software may fail to correctly identify a lead vehicle.
Consequence & remedy
Consequence: Failure to detect another vehicle increases the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1744.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. An improperly grounded connection inside the High Voltage Distribution Box (HVDB) may cause a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Rivian will inspect and repair the HVDB ground strap joint or replace the high voltage battery pack as necessary, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1723.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. One or both front turn signals may fail to illuminate and flash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Turn signals that do not function properly, failing to indicate the driver's intention to change direction, increase the risk of a crash.
Remedy: Rivian will inspect and replace the front turn signals as necessary, free of charge. Owner notification letters were mailed September 22, 2025. Owners will receive a second notice once the remedy becomes available. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1693.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.
Consequence & remedy
Consequence: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. The headlight low beams may fail to illuminate when starting the vehicle in cold weather. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Headlight failure can reduce visibility, increasing the risk of a crash.
Remedy: Rivian will replace the headlight control modules, free of charge. Owner notification letters were mailed September 22, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1612.
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence & remedy
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Additional source detail variants (2)
Electrical System:software
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Exterior Lighting
Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1T and R1S vehicles. Software version 2024.39.30 may prevent certain exterior lights from turning on when the Car Costume feature is activated.
Consequence: Deactivated exterior lighting reduces the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 18, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1552.
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Additional source detail variants (2)
Steering:steering Control Module
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Vehicle Speed Control:cruise Control
Rivian Automotive, LLC. (Rivian) is recalling certain 2025 R1S vehicles. The steering column control module (SCCM) may be missing cruise control markings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence: The driver may not know how to activate or deactivate the cruise control without the proper markings, increasing the risk of a crash.
Remedy: Rivian will inspect and replace the SCCMs as necessary, free of charge. Owner notification letters were mailed October 18, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1532.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE26004 · Rear Toe Link May Separate
Opened May 26, 2026 · No close date supplied
Status: open (inferred from source dates) · Suspension:rear
The Office of Defects Investigation (ODI) has received two Vehicle Owner Questionnaires (VOQs) reporting left rear toe link separation in certain Model Year (MY) 2023-2024 Rivian R1S vehicles. Both VOQs report component separation while driving, causing the vehicles to swerve across multiple lanes of traffic. One incident resulted in a collision with an adjacent vehicle and roadside barrier. In both separations, the bolt that maintains the integrity of the toe link fractured. Evidence collected from the complaint vehicles included repair histories, onboard video, imagery of the damaged components, and a police accident report. The two vehicles with reported separation have different vehicle histories. One vehicle received prior service and the other was involved in a previous collision. In both instances, the vehicles operated for multiple months and thousands of miles of usage with no apparent problems between the previous service or the previous collision and the failures that prompted this investigation. Rivian recognized the subject toe link joint’s sensitivity to service procedures in March of 2025 in its updated service procedures. In January 2026 through recall 26V-003, Rivian extended the improved repair procedure to vehicles that received toe link service prior to the March 2025 improvement. ODI is opening a Preliminary Evaluation (PE) to (1) assess the sensitivity of the rear toe link joint to foreseeable road and service conditions, (2) compare the physical failure evidence from the two VOQs to identify apparent similarities and potential differences, (3) evaluate Rivian’s current toe link repair procedure, and (4) assess the in-field subject population’s toe links conditions. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov
2025 Rivian R1S Problems, Complaints & Recalls | Skip That Year
Illustration