NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
114 reportsClear category filterMileage unknown · Feb 17, 2023
Power Train
I lost the transmission in my truck. Lost 1st thru 4th gears . I was in reverse and my truck made a loud clunk/bang the dash stated 4wheel drive unavailable. The engine light came on and it went into limp mode. 40mph top speed. I got it to the dealer on 12\23\22 and the truck has been there since. Ram is now claiming no eta of a…
Read full complaint
I lost the transmission in my truck. Lost 1st thru 4th gears . I was in reverse and my truck made a loud clunk/bang the dash stated 4wheel drive unavailable. The engine light came on and it went into limp mode. 40mph top speed. I got it to the dealer on 12\23\22 and the truck has been there since. Ram is now claiming no eta of any sort and there is an engineering problem with the transmission. I worry that someone could get injured if the transmission fails at speed of in traffic. Please look into this before someone gets hurt.
NHTSA ODI #11507790
800 miles · Feb 17, 2023
Power Train
The contact owns a 2022 Ram 3500. The contact stated while driving 40 MPH and towing a 40-ft trailer ascending a mountain, a loud clunking noise was coming from the vehicle. The contact stated that the vehicle decelerated. The contact stated that the vehicle failed to accelerate while depressing the accelerator pedal. The vehicl…
Read full complaint
The contact owns a 2022 Ram 3500. The contact stated while driving 40 MPH and towing a 40-ft trailer ascending a mountain, a loud clunking noise was coming from the vehicle. The contact stated that the vehicle decelerated. The contact stated that the vehicle failed to accelerate while depressing the accelerator pedal. The vehicle was driven very slowly to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The VIN was not available. The failure mileage 800.
NHTSA ODI #11507774
Mileage unknown · Feb 6, 2023
Power Train
I was driving on the interstate and new truck with 170 miles on it just made 2 loud noises and then would not go over 10 miles an hour, Which I think is very dangerous. Now its been at the service station for Ram for a month and the mechanic said this was his 6th truck with under 600 miles with the same problem. And Ram is not d…
Read full complaint
I was driving on the interstate and new truck with 170 miles on it just made 2 loud noises and then would not go over 10 miles an hour, Which I think is very dangerous. Now its been at the service station for Ram for a month and the mechanic said this was his 6th truck with under 600 miles with the same problem. And Ram is not doig much to assist me.
NHTSA ODI #11505853
Mileage unknown · Feb 2, 2023
Power Train
While traveling approximately 15 miles per hour transmission locked-up in the middle of the road and would not move. Dash lit-up with check engine lights. Truck was towed to dealership where it was determined that a new transmission was needed and ordered. As of today, the truck has been at the dealership for repair for just …
Read full complaint
While traveling approximately 15 miles per hour transmission locked-up in the middle of the road and would not move. Dash lit-up with check engine lights. Truck was towed to dealership where it was determined that a new transmission was needed and ordered. As of today, the truck has been at the dealership for repair for just under 40 days.
NHTSA ODI #11505097
Mileage unknown · Feb 1, 2023
Power Train
On 4 different occasions when accelerating from a stop when we proceed forward slowly vehicle will rev up to 4500 RPM without any forward movement. After coasting to side of road we put vehicle in park and after a few minutes we put it in drive and it will run fine. We have not had any code lights appear or warning signs appear…
Read full complaint
On 4 different occasions when accelerating from a stop when we proceed forward slowly vehicle will rev up to 4500 RPM without any forward movement. After coasting to side of road we put vehicle in park and after a few minutes we put it in drive and it will run fine. We have not had any code lights appear or warning signs appear.
NHTSA ODI #11505032
Mileage unknown · Feb 1, 2023
Power Train
Backed out of a parking spot onto a busy road, put the truck in drive and nothing. Transmission failure. ME and my daughter were stuck in the middle of the road and truck would only go in reverse. Had to reverse a u-turn in middle of road and back into parking spot. Dealer confirmed a failure in the transmission and is repairing…
Read full complaint
Backed out of a parking spot onto a busy road, put the truck in drive and nothing. Transmission failure. ME and my daughter were stuck in the middle of the road and truck would only go in reverse. Had to reverse a u-turn in middle of road and back into parking spot. Dealer confirmed a failure in the transmission and is repairing/ replacing. Upon fruther investigation into this issue online there is a list of truck that this is happening to. Check engine light also came on when vehical would not move.
NHTSA ODI #11504875
Mileage unknown · Jan 31, 2023
Power Train
We were traveling westbound on the interstate I-10 towards Los Angeles California on Nov 13/22 near Cabazon CA in my 2022 Ram 3500, SRW, 6.7 HO with the Aisin transmission. It was rush hour stop-and-go traffic. I was traveling at a speed of approximately 35mph when a large bang came from under the vehicle. There was an immediate…
Read full complaint
We were traveling westbound on the interstate I-10 towards Los Angeles California on Nov 13/22 near Cabazon CA in my 2022 Ram 3500, SRW, 6.7 HO with the Aisin transmission. It was rush hour stop-and-go traffic. I was traveling at a speed of approximately 35mph when a large bang came from under the vehicle. There was an immediate and complete power loss and we had to coast to the shoulder of the road and try to avoid being struck by traffic. Once on the shoulder, I had got out and checked under the vehicle. There was nothing that I could see that was wrong. There was a check engine light that went on. Using a jobber OB2 scanner, codes P0731 (Gear 1 incorrect ratio) and P0732 (Gear 2 incorrect ratio) were present. The truck was towed to the Redlands CDJR dealer for service with only 6700 miles on the odometer. It turned out to require a complete new Aisin transmission. The repair took a month to complete and looks to have been caused by a defective snap ring as per service bulletin 21-002-23 (K1 clutch drum snap ring and K1 input shaft drum sub assembly) although the Redlands CDJR dealer or FCA will not confirm. The bulletin states the affected vehicles are the 2022-23 Ram 3500 pickup, 3500 cab and chassis, and 4500/5500 Cab Chassis trucks. Due to the immediate power loss, with zero warning, we were just able to get to the shoulder of the road and could have easily caused a massive pile up and possible deaths due to the failure. FCA refuses to inspect or confirm that the new transmission (68498560AB) installed in my truck addresses the 21-002-23 service bulletin and said I would need to pay out of pocket for the inspection to occur at a dealer. There are numerous documented cases of newly installed transmissions failing shortly after being "repaired". I believe it would be in the publics best interest that FCA/RAM issue a recall on the effected vehicles as these vehicles are typically used for emergency, commercial and towing application's.
NHTSA ODI #11504661
Mileage unknown · Jan 21, 2023
Power Train
While driving the transmission went out, not being able to engage or use any forward moving gears.
NHTSA ODI #11502992
26,000 miles · Jan 10, 2023
Power Train
The contact owns a 2022 Ram 3500. The contact stated while depressing the accelerator pedal, the vehicle made an abnormal sound. Additionally, the vehicle occasionally would not start as needed. The fault code: P0731 (Gear 1 Incorrect Ratio) was retrieved. The vehicle was towed to a dealer, where it was diagnosed with transmissi…
Read full complaint
The contact owns a 2022 Ram 3500. The contact stated while depressing the accelerator pedal, the vehicle made an abnormal sound. Additionally, the vehicle occasionally would not start as needed. The fault code: P0731 (Gear 1 Incorrect Ratio) was retrieved. The vehicle was towed to a dealer, where it was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 26,000.
NHTSA ODI #11501120
Mileage unknown · Jan 9, 2023
Power Train
The transmission suddenly lost all forward gears while towing 3 utv on a trailer.
NHTSA ODI #11500840
Official recalls
12Nov 6, 2025
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Additional source detail variants (2)
Steering:steering Control Module
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Air Bags:frontal
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Jun 13, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.
Jun 6, 2024
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Additional source detail variants (2)
Service Brakes, Air:antilock:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Electronic Stability Control (esc):control Module
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Sep 28, 2023
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram 1500, Ram 3500 Cab Chassis with GVWR less than 10,000 lbs., and 2022-2024 Ram 2500 vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the radio software, free of charge. Owner notification letters were mailed October 24, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 97A.
Feb 9, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.
Consequence & remedy
Consequence: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.
Dec 8, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
Consequence & remedy
Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
Nov 10, 2022
FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.
Consequence & remedy
Consequence: Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.
Remedy: Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.
Aug 26, 2022
Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.
Consequence & remedy
Consequence: An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.
Jun 9, 2022
Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will reprogram the radio software, free of charge. Owner notification letters were mailed July 5, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z47.
Mar 10, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Additional source detail variants (2)
Electronic Stability Control (esc)
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Nov 24, 2021
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 2500, Ram 3500, and 2021 Ram 1500 Classic pickup trucks. The side air bag inflatable curtain (SABIC) assemblies may have been manufactured with the incorrect amount of compressed gas, which can result in an improper air bag deployment.
Consequence & remedy
Consequence: An air bag that deploys improperly can increase the risk of injury in a crash.
Remedy: Dealers will replace the SABIC assemblies, free of charge. Owner notification letters were mailed January 17, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y99.
Oct 14, 2021
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE26002 · Loss Of Power Steering Assist
Opened Mar 2, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring:connectors/plugs/receptacles; Steering; Steering:electric Power Assist System; Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Electrical System:wiring:connectors/plugs/receptacles
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24009 · 2022 RAM Transmission Snap Ring Failure
Opened Mar 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:internal:clutches/bands
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:automatic Transmission
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:internal:clutches/bands
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration