← New search

2019 RAM 1500

Owner reports · Recalls · Investigations

More warning signs than most 1500 years

Owner complaints for the 2019 RAM 1500 are substantially higher than the model-year median of 616.

About this comparison →

When problems were reported

Mileage at the reported incident

550 reports with mileage · 923 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 379 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 337 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

75 crash reports11 fire reports42 injury reports

Fuel/propulsion System complaints

79 reports
Clear category filter
Mileage unknown · Jan 5, 2022
EngineFuel/propulsion SystemPower TrainFireInjury

On 06-06-2021 my wife, daughter and Me and our three dogs, was heading to are first destination on are 2 week vacation pulling are camper. In about 150 miles into the trip started smelling diesel, pulled over on a narrow 2 lane road couldn’t see anything. So my wife found a road we could pull off on to check everything out a mi…

Read full complaint

On 06-06-2021 my wife, daughter and Me and our three dogs, was heading to are first destination on are 2 week vacation pulling are camper. In about 150 miles into the trip started smelling diesel, pulled over on a narrow 2 lane road couldn’t see anything. So my wife found a road we could pull off on to check everything out a mile away, right before we made it to the road a (service electronic throttle) message came on, so made it to the road to pull off stoped and instantly smoke started bellowing out from the back of the hood. I hopped out and started feeling something burning my legs looked down and saw liquid aluminum dripping and yelled from everyone to get out, by to time we got everyone out the whole front of the truck way fully on the so I got what I could get out and my wife was on the phone with 911. Knowing that the fire department is 20 minutes out I needed to save the camper. Fire is past the fire wall now, pull the panel for the emergency release to put the transmission in neutral one of the airbags blew up in my face and couldn’t get it out of park. So somehow I shook the truck and camper enough to get the pin out of the hitch and somehow someone drove by and asked them could they help me pull the camper away, and we hooked a chain and pulled it away. 24 minutes later the fire department arrived and everything I saved from the truck was in the grass and burned up to hot to get close to get. So 24 minutes of hell was just starting legs, hand burned and contacts burned can’t see well and back thumping. Calling everyone like Ram, insurance company no one will help. So the volunteer fire department pulled are camper to their fire station and stayed the night there until are family could pull us back home. Then the nightmare of dealing with the scummy progressive fight for almost 3 months that would not pay market value the time of the incident and somehow took over my claim I had. I have videos and pictures of the fire.

NHTSA ODI #11446344

Mileage unknown · Dec 19, 2021
Fuel/propulsion System

gasoline leaking from top of gas tank

NHTSA ODI #11444349

Mileage unknown · Nov 22, 2021
Electrical SystemFuel/propulsion System

I cannot properly refuel my tank. It takes me 25 minutes to fill 5 gallons of gas. The pump keeps shutting off like it thinks my car is full. All gas station pump are doing the same thing. Also my Navi goes off course. Sirius XM says my location is one place according to their system but I am 200 miles away. They say it shows …

Read full complaint

I cannot properly refuel my tank. It takes me 25 minutes to fill 5 gallons of gas. The pump keeps shutting off like it thinks my car is full. All gas station pump are doing the same thing. Also my Navi goes off course. Sirius XM says my location is one place according to their system but I am 200 miles away. They say it shows it is working on their end but there is clearly an electrical or navigation glitch with my car.

NHTSA ODI #11441361

Mileage unknown · Oct 13, 2021
Fuel/propulsion System

Recently I have been experiencing issues when I pump gas in my three year old truck. When I pump gas the nozzle won't fill it up automatically and continues to stop constantly that causes to take forever.

NHTSA ODI #11436702

Mileage unknown · Aug 13, 2021
EngineFuel/propulsion System

The exhaust system builds up soot and causes the vehicle to malfunction or require excessive EGR cleaning. My vehicle has been in 4 times for the same issue. The dealership admitted they have had many of the same vehicles in for the same issue. It will freeze up when driving and prevent going forward. I have called Ram and they …

Read full complaint

The exhaust system builds up soot and causes the vehicle to malfunction or require excessive EGR cleaning. My vehicle has been in 4 times for the same issue. The dealership admitted they have had many of the same vehicles in for the same issue. It will freeze up when driving and prevent going forward. I have called Ram and they refuse to consider anything because my issue is a maintenance issue the dealership already told me should not be necessary until 60,000-90,000 miles and I should know it will need to be done every 10,000 miles if I do not drive more than I do. I was never informed of the issue when purchasing the vehicle brand new.

NHTSA ODI #11428948

Mileage unknown · Apr 20, 2021
EngineFuel/propulsion SystemUnknown Or Other

WHILE DRIVING ON APRIL 15, 2021, STOPPED AT A RED LIGHT AND CAR COMPLETELY SHUT OFF AND WOULD NOT START BACK UP. TRIED JUMPING CAR NUMEROUS TIMES BUT STILL WOULD NOT START. HAD CAR TOWED TO DEALER AND CAR STILL WOULD NOT START. DEALER CAN NOT DIAGNOSE WHAT ISSUE IS AND CAN NOT DEFINE WHY CAR CUT OFF IN THE MIDDLE OF TRAFFIC

NHTSA ODI #11412966

22,000 miles · Apr 10, 2021
EngineFuel/propulsion SystemPower Train

VEHICLE WAS IN MOTION, GENTLY TURNING RIGHT AND DECELERATING, MOVING APPROX. 60 MPH EXITING INTERSTATE WHEN ENGINE SHUTOFF. DASH DISPLAY READ MESSAGE TO SHIFT CAR INTO PARK. DRIVE SHIFT KNOB FLASHED 'D'. ACCESSORY POWER REMAINED ON. VEHICLE WAS COASTED TO A STOP, SHIFTED TO PARK, POWERED OFF, AND RESTARTED. DRIVER ACCELERATED V…

Read full complaint

VEHICLE WAS IN MOTION, GENTLY TURNING RIGHT AND DECELERATING, MOVING APPROX. 60 MPH EXITING INTERSTATE WHEN ENGINE SHUTOFF. DASH DISPLAY READ MESSAGE TO SHIFT CAR INTO PARK. DRIVE SHIFT KNOB FLASHED 'D'. ACCESSORY POWER REMAINED ON. VEHICLE WAS COASTED TO A STOP, SHIFTED TO PARK, POWERED OFF, AND RESTARTED. DRIVER ACCELERATED VEHICLE TO MERGE BACK INTO TRAFFIC, TRIGGERING ANOTHER ENGINE SHUTOFF WITH THE SAME CONDITION. AFTER SECOND RESTART, WHEN VEHICLE WAS IN PARK THE ENGINE WAS REVVED TO VERIFY A POWER LIMIT REDLINE WAS NOT BEING SURPASSED CAUSING ENGINE SHUTOFF. AC/RADIO WAS POWERED DOWN AND VEHICLE REACHED DESTINATION 5 MINUTES AWAY WITHOUT FURTHER INCIDENT. CAUSE OF ENGINE FAILURE UNKNOWN, ALL FLUID LEVELS/TEMPERATURES NOMINAL, NO SMOKE OR VISUAL INDICATIONS OF FAILURE ON THE VEHICLE.

NHTSA ODI #11407397

39,350 miles · Mar 29, 2021
Electrical SystemEngineFuel/propulsion System

I WAS DRIVING ON I-65 IN INDIANAPOLIS, IN TRAFFIC, WHEN MY ENGINE ABRUPTLY SHUT OFF AND THE IGNITION MODE SWITCHED FROM RUN TO ACC. THIS CAUSED ME TO LOSE ALL PROPULSION POWER AND I WAS FORCED TO CROSS LANES TO GET OVER TO THE RIGHT SHOULDER. LUCKILY, I WAS STILL A MILE OR TWO FROM THE UPCOMING CONSTRUCTION ZONE, WHICH WOULD HAV…

Read full complaint

I WAS DRIVING ON I-65 IN INDIANAPOLIS, IN TRAFFIC, WHEN MY ENGINE ABRUPTLY SHUT OFF AND THE IGNITION MODE SWITCHED FROM RUN TO ACC. THIS CAUSED ME TO LOSE ALL PROPULSION POWER AND I WAS FORCED TO CROSS LANES TO GET OVER TO THE RIGHT SHOULDER. LUCKILY, I WAS STILL A MILE OR TWO FROM THE UPCOMING CONSTRUCTION ZONE, WHICH WOULD HAVE PREVENTED ME FROM BEING ABLE TO PULL OFF ONTO A SHOULDER. BECAUSE THE ENGINE HAD SHUT OFF WHILE THE TRUCK WAS MOVING, THE COMPUTER SYSTEM IS PROGRAMMED TO SHIFT THE TRANSMISSION INTO PARK, BUT BECAUSE I WAS GOING 70MPH ON THE HIGHWAY (>5MPH ACCORDING TO MY USER MANUAL), IT JUST ALERTED ME THAT MY ENGINE WAS OFF AND THAT I WAS IN ACC MODE. AFTER PARKING THE TRUCK ON THE SHOULDER WITH HAZARDS ON, I TURNED THE ENGINE OFF AND WAITED A FEW SECONDS BEFORE TRYING TO START IT AGAIN. WHEN I PRESSED THE BRAKE AND THE IGNITION BUTTON, THE TRUCK STARTED UP IMMEDIATELY, LIKE NORMAL, BUT THEN 2 SECONDS LATER IT CUT OUT AGAIN WITH THE SAME RUN-TO-ACC MODE SWITCH. THIS HAPPENED 6-7 MORE TIMES BEFORE THE TRUCK SOMEHOW STAYED ON RUN. I CHECKED THE ENGINE AND MY FLUIDS FOR ANYTHING ODD, BUT MECHANICALLY, THE TRUCK WAS FINE. NO CHECK ENGINE OR WARNING LIGHTS EVER CAME ON. THE COMPUTER SYSTEM DIDN'T RECOGNIZE THAT ANYTHING WAS WRONG OTHER THAN THE INITIAL INDICATION. I WAS ABLE TO GET HOME WITHOUT ISSUES AFTER THAT, BUT WHEN I WENT TO TURN THE ENGINE OFF, I COULDN'T. THE IGNITION BUTTON HAD STOPPED RESPONDING. I TRIED ALL OF THE USER MANUAL'S METHODS TO TURN IT OFF, BUT NOTHING WORKED. THIS VEHICLE DOESN'T HAVE A MANUAL KEY IGNITION OVERRIDE, JUST THE FOB AND KEYLESS BUTTON, NEITHER OF WHICH COULD TURN THE ENGINE OFF. THE FOB'S REMOTE START/SHUTOFF DIDN'T WORK EITHER. IN THE END, I HAD TO DISCONNECT THE BATTERY TO FORCE THE ENGINE AND COMPUTER SYSTEM TO TURN OFF. I'M TAKING IT INTO THE LOCAL DEALER, VIA TOW IF IT WON'T START AGAIN, TO FIGURE OUT WHAT HAPPENED.

NHTSA ODI #11405327

28,000 miles · Jan 21, 2021
Electrical SystemFuel/propulsion SystemUnknown Or Other

TOUCHSCREEN CONTROLS FOR RADIO, CLIMATE, AND ALL OTHER CONTROLS DO NOT WORK PROPERLY. ANY AND ALL ELEMENTS OF TOUCHSCREEN WILL POWER ON AND OFF FROM AC TO HEAT TO RADIO STATIONS TO RANDOM PHONE DIALING. ALSO THE VEHICLE WILL SHUT DOWN WHILE DRIVING AS IF THE GEAR SHIFTER HAS BEEN PLACED IN NEUTRAL. TRUCK WILL NOT ACCELERATE AND …

Read full complaint

TOUCHSCREEN CONTROLS FOR RADIO, CLIMATE, AND ALL OTHER CONTROLS DO NOT WORK PROPERLY. ANY AND ALL ELEMENTS OF TOUCHSCREEN WILL POWER ON AND OFF FROM AC TO HEAT TO RADIO STATIONS TO RANDOM PHONE DIALING. ALSO THE VEHICLE WILL SHUT DOWN WHILE DRIVING AS IF THE GEAR SHIFTER HAS BEEN PLACED IN NEUTRAL. TRUCK WILL NOT ACCELERATE AND REMOTE START DOESN'T WORK EITHER. LEFT REAR PASSENGER WINDOW SEAL NEAR BED OF TRUCK ALSO LEAKS WATER WHEN IT RAINS.

NHTSA ODI #11389260

15,000 miles · Jan 19, 2021
Fuel/propulsion System

MY 2019 RAM FUEL FILLER NECK CAUSES ANY GAS PUMP NOZZLE I USE TO BECOME STUCK AND MAKES REFUELING TAKE MUCH LONGER THAN IT SHOULD. THE GAS PUMP NOZZLE CONTINUOUSLY TURNS OFF NOT ALLOWING ME TO FILL MY GAS TANK. THE FILLER NECK?S DESIGN SEEMS TO TRIGGER THE GAS PUMPS? AUTOMATIC SHUTOFF WHEN THE TANK ISN?T FULL YET. SOMETIMES THE …

Read full complaint

MY 2019 RAM FUEL FILLER NECK CAUSES ANY GAS PUMP NOZZLE I USE TO BECOME STUCK AND MAKES REFUELING TAKE MUCH LONGER THAN IT SHOULD. THE GAS PUMP NOZZLE CONTINUOUSLY TURNS OFF NOT ALLOWING ME TO FILL MY GAS TANK. THE FILLER NECK?S DESIGN SEEMS TO TRIGGER THE GAS PUMPS? AUTOMATIC SHUTOFF WHEN THE TANK ISN?T FULL YET. SOMETIMES THE PUMP SHUTS OFF EVERY FEW SECONDS, FORCING ME TO FILL MY TRUCKS? TANK OUNCES AT A TIME.

NHTSA ODI #11388781

Official recalls

29

26V495000 · Seat Belts:rear/other:anchorage

Jul 30, 2026

Chrysler (FCA US, LLC) is recalling certain 2019-2026 Ram 1500 vehicles. The second-row center and left-side seat belt buckle anchors may have been improperly installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Consequence & remedy

Consequence: An improperly installed seat belt buckle anchor may fail to properly restrain occupants, increasing the risk of injury during a crash.

Remedy: Dealers will inspect and attach the seat belt buckle anchor to the body structure as necessary, free of charge. Owner notification letters are expected to be mailed August 18, 2026. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 67D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 6, 2026.

25V824000 · Air Bags:side/window:curtain:inflator

Dec 1, 2025

Chrysler (FCA US, LLC) is recalling certain 2019 Ram 1500 Classic, Ram 2500, and Ram 3500 vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are C2C, C7C, and C8C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 4, 2025.

25V298000 · Air Bags; Electrical System:wiring

May 8, 2025

Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

Additional source detail variants (2)

Air Bags

Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

Electrical System:wiring

Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

25V010000 · Air Bags:side/window:curtain:inflator

Jan 16, 2025

Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.

24V653000 · Electronic Stability Control (esc):control Module; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 5, 2024

Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

Additional source detail variants (2)

Electronic Stability Control (esc):control Module

Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

23V411000 · Engine And Engine Cooling

Jun 8, 2023

Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

Consequence & remedy

Consequence: An engine stall can increase the risk of a crash.

Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.

22V904000 · Structure:body:tailgate:hinge And Attachments

Dec 8, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Consequence & remedy

Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

22V406000 · Fuel System, Diesel:delivery:fuel Pump

Jun 9, 2022

Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.

Consequence & remedy

Consequence: Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.

Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.

21V632000 · Air Bags:side/window:curtain; Air Bags:side/window:curtain:inflator

Aug 12, 2021

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence & remedy

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

Additional source detail variants (2)

Air Bags:side/window:curtain:inflator

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

Air Bags:side/window:curtain

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

20V580000 · Seat Belts; Seat Belts:front:retractor

Sep 24, 2020

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.

Consequence & remedy

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.

Additional source detail variants (2)

Seat Belts:front:retractor

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.

Seat Belts

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.

20V191000 · Back Over Prevention: Sensing System: Camera

Sep 10, 2020

Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.

20V513000 · Vehicle Speed Control:accelerator Pedal

Aug 27, 2020

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles equipped with adjustable pedals. In certain accelerator pedal positions, the floormats may prevent the pedal from returning to the normal resting (idle) position.

Consequence & remedy

Consequence: A pedal that does not return as expected may affect the vehicle's deceleration, thereby increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will modify the driver's floormat to remove the potential for pedal interference, free of charge. The recall began September 10, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W63.

20V208000 · Visibility:windshield Wiper/washer:linkages

Apr 9, 2020

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500, 1500 Classic and Jeep Compass vehicles. The windshield wiper arm or arms may loosen, possibly causing the wipers to not operate properly and reduce the driver's visibility in certain weather conditions.

Consequence & remedy

Consequence: Reduced visibility increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will tighten the wiper nuts, free of charge. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W25.

20V080000 · Power Train:transfer Case (4-WHEEL Drive)

Feb 13, 2020

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 pickup trucks equipped with four-wheel drive. A gear within the transfer case may not have been installed correctly, possibly causing the vehicle to become stuck in neutral. If this occurs while driving, there could be a sudden loss of power. Additionally, a loss of 'PARK' function may occur.

Consequence & remedy

Consequence: A sudden loss of power or a loss of 'PARK' function may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transfer case, free of charge. The recall began March 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W06.

19V887000 · Tires:pressure Monitoring And Regulating Systems

Dec 12, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. An incorrect Tire Pressure Monitoring System (TPMS) sensor could have been installed during production causing the sensor to not display the low tire pressure warning indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: Without a warning indicator, the driver will be unaware if low tire pressure occurs, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the TPMS sensor, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE1.

19V812000 · Steering:electric Power Assist System

Nov 14, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. These vehicles may have been built with a contaminated electric power steering (EPS) gear that may short circuit, potentially resulting in an intermittent loss of power steering assist.

Consequence & remedy

Consequence: An intermittent loss of power steering assist may cause an inconsistent steering effort, especially during lower speed maneuvers, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the EPS gear assembly, free of charge. The recall began December 12, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA's number for this recall is VB8.

19V757000 · Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Oct 24, 2019

Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram 1500 and 1500 Classic Pickup trucks equipped with 3.0L Eco Diesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.

Consequence & remedy

Consequence: Combustion in the intake manifold can increase the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. The recall began April 16, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB1.

19V556000 · Electrical System: Instrument Cluster/panel

Jul 26, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The instrument cluster may not properly illuminate driver warnings. As such, these vehicles fails to conform with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."

Consequence & remedy

Consequence: Failure of the instrument cluster to properly illuminate may prevent the driver from receiving warnings about the vehicle's systems and increase the risk of crash.

Remedy: Chrysler will notify owners, and dealers will replace the instrument cluster, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V83.

19V448000 · Tires:temporary/emergency Spare Tire

Jun 13, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. The spare tire provided may differ in size and required inflation pressure from the information on the tire placard label. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: The driver, referencing the tire placard label, may incorrectly inflate the spare tire, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the incorrect size spare tire with the correct size spare tire, free of charge. The recall began June 27, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V67.

19V407000 · Air Bags; Air Bags: Air Bag/restraint Control Module; Seat Belts:pretensioner

May 31, 2019

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.

Consequence & remedy

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

Additional source detail variants (3)

Air Bags: Air Bag/restraint Control Module

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

Seat Belts:pretensioner

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

Air Bags

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

19V324000 · Power Train:driveline:driveshaft

Apr 25, 2019

Chrysler (FCA US LLC) is recalling certain 2018-2019 Ram 1500 pickup trucks. The rear driveshaft may have an incomplete weld fusion between the tube and tube yoke, which may lead to weld cracking or the driveshaft fracturing.

Consequence & remedy

Consequence: A fractured rear driveshaft could detach from the vehicle and become a road hazard, or it may result in a loss of drive power, both of which can increase the risk of a crash.

Remedy: FCA US will notify owners, and dealers will replace the rear driveshaft, free of charge. The recall began June 13, 2019. Owners may contact FCA US customer service at 1-800-853-1403. The FCA US recall number is V48.

19V201000 · Steering

Mar 14, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and 2019 Ram 1500 vehicles. These vehicles have improperly machined steering column stub shafts that may break, possibly causing the steering wheel to detach from the steering column.

Consequence & remedy

Consequence: If the steering wheel detaches from the steering column, the driver may lose control of the vehicle, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will inspect the steering column, replacing it, as necessary, free of charge. The recall began April 5, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V29.

19V142000 · Electrical SYSTEM:12V/24V/48V Battery

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with a 48v auxiliary battery system located behind the rear seat (sales code: XBZ). Due to an incorrect assembly repair process, the auxiliary battery wire terminal connection may overheat.

Consequence & remedy

Consequence: If the auxiliary battery system overheats, there is an increased risk of a fire within the cabin even if the ignition is off.

Remedy: FCA US has notified owners, and dealers will properly secure the auxiliary battery fasteners, free of charge. The recall began March 15, 2019. Owners may contact Chrysler's customer service at 1-800-853-1403. The Chrysler number for this recall is V17.

19V067000 · Service Brakes, Hydraulic:pedals And Linkages

Feb 5, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with adjustable pedals. The affected vehicles have a brake pedal that may move too far and separate from pedal assembly.

Consequence & remedy

Consequence: If the brake pedal separates from the pedal assembly, the driver may be unable to brake the vehicle, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will repair the adjustable pedal assembly, free of charge. The recall began on February 25, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V07.

19V020000 · Steering:electric Power Assist System

Jan 24, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The battery ground fastener on the driver-side front fender may have been improperly secured, possibly resulting in a loss of power steering assist.

Consequence & remedy

Consequence: A loss of power steering could vary the steering effort required, possibly causing vehicle oversteer or understeer, increasing the risk of crash.

Remedy: Chrysler has notified owners, and dealers will properly secure the ground fastener, free of charge. The recall began on February 11, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V04.

19V051000 · Visibility:defroster/defogger/hvac System

Jan 24, 2019

Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 vehicles equipped with a 12" touchscreen display and a base-level heating, ventilation and air conditioning ("HVAC") system. Vehicles with this combination do not have a functioning windshield defrosting and defogging system. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield defrosting and defogging systems."

Consequence & remedy

Consequence: The lack of a functioning windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will repurchase the affected vehicles. The recall began March 7, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V12.

18V822000 · Seats

Nov 20, 2018

Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 trucks. The seat track position sensor on the manually-adjusted passenger seats may come loose and out of position, preventing the sensor from detecting if the seat is in the full-forward position.

Consequence & remedy

Consequence: If the sensor cannot identify that the seat is in the full-forward position and adjust the frontal air bag deployment accordingly, there would be an increased the risk of a injury in the event of a crash.

Remedy: Chrysler will notify owners and dealers will inspect the passenger seat track position sensor bracket, replacing it as necessary, free of charge. The recall began December 20, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB7.

18V556000 · Power Train:axle Assembly

Aug 23, 2018

Chrysler (FCA US LLC) is recalling certain 2018-2019 RAM 1500 trucks. The rear differential may have been insufficiently filled, possibly resulting in its failure.

Consequence & remedy

Consequence: If the rear axle assembly fails, it can cause a loss of drive or the rear wheels may lock up. Either scenario increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the rear axle oil level. Rear axles with an insufficient amount of oil will be replaced, free of charge. The recall began September 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U88.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Electrical System:wiring

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA23001 · High Pressure Fuel Pump Failure

Opened Mar 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337