NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
79 reportsClear category filterMileage unknown · Jan 17, 2024
Electrical SystemEngineFuel/propulsion System
When driving the vehicle on the roadway, the vehicle will turn off the engine and will not allow you to accelerate and will flash a message to put the car in park. When you pull on the side of the road and place the vehicle in park you can then restart the engine. Once the engine is on and you try to put the vehicle in drive the…
Read full complaint
When driving the vehicle on the roadway, the vehicle will turn off the engine and will not allow you to accelerate and will flash a message to put the car in park. When you pull on the side of the road and place the vehicle in park you can then restart the engine. Once the engine is on and you try to put the vehicle in drive the engine will turn off again and request that you put the vehicle in park. It does this over and over for about 5-6 times until it does eventually allow the vehicle to stay in Drive and you can start moving down the road. Once you are driving in the road way it will repeat the process again. During this process there are no warning lights or messages being displayed other than "place the vehicle in park". This is extremely dangerous especially if I was on the interstate or Highway and I lost all capability to move the vehicle. I took the vehicle to a dealership and they were unable to recreate the issue and so no active codes that would point them in the direction of the problem. The dealership told me there was nothing they could do unless they had a code or could recreate the issue.
NHTSA ODI #11566016
Mileage unknown · Nov 29, 2023
Fuel/propulsion System
Hard to fuel the vehicle. Takes 15 minutes or more to fill the gas tank. Ram's fix is to replace the gas tank on a 4 year old truck with under 60,000 miles. Filling up using a funnel at a gas station is not safe for me or other drivers. The local dealer said the cost would about $2000. A service notice was issued over a year …
Read full complaint
Hard to fuel the vehicle. Takes 15 minutes or more to fill the gas tank. Ram's fix is to replace the gas tank on a 4 year old truck with under 60,000 miles. Filling up using a funnel at a gas station is not safe for me or other drivers. The local dealer said the cost would about $2000. A service notice was issued over a year ago.
NHTSA ODI #11557505
Mileage unknown · Oct 30, 2023
Fuel/propulsion System
There is an issue with putting gas into this truck. Seems there is a defect in the filler tube which Ram will not at this point recognize
NHTSA ODI #11552593
Mileage unknown · Oct 11, 2023
EngineFuel/propulsion SystemPower Train
I have an oil cooler leak, a radiator leaking coolant , transmission running high. I have 110k miles on my truck and do routine maintenance. I’m worried about an engine fire or cracked block soon.
NHTSA ODI #11549491
Mileage unknown · Sep 16, 2023
Fuel/propulsion System
Due to a known but unaddressed defect in the steep-angled fuel filler neck, it’s almost impossible to fill my tank with gas because the defect causes the gas pump to stop the flow of gasoline every few seconds. Also, the gas pump handle can sometimes become stuck while trying to refill the truck. This cause a very dangerous si…
Read full complaint
Due to a known but unaddressed defect in the steep-angled fuel filler neck, it’s almost impossible to fill my tank with gas because the defect causes the gas pump to stop the flow of gasoline every few seconds. Also, the gas pump handle can sometimes become stuck while trying to refill the truck. This cause a very dangerous situation in trying to remove the stuck handle due to the possibility of creating a spark which could ignite the gasoline vapors from trying to forcefully dislodge the pump handle. The NHTSA, to my knowledge, has not requested the manufacturer to initiate a recall to replace the defective part. This problem has been widely discussed online in different forums. My truck has been at the dealership all week and the service department just called me saying I need to order a new fuel tank at the cost of $1925.00!
NHTSA ODI #11544908
Mileage unknown · Jul 12, 2023
Fuel/propulsion System
When Filling the truck up with fuel, after 1-2 gallons the pump would shut off and I would have to repeat this process to fill up my 32-gallon tank. When I took it to the mechanic, it was found that the tank and filler neck was not properly preventing the pressure, causing the pump to think the tank was full and shut off. By the…
Read full complaint
When Filling the truck up with fuel, after 1-2 gallons the pump would shut off and I would have to repeat this process to fill up my 32-gallon tank. When I took it to the mechanic, it was found that the tank and filler neck was not properly preventing the pressure, causing the pump to think the tank was full and shut off. By the time we figured out the issue Stellantis had already developed an updated tank and filler neck and were putting it into their new trucks, but they never informed the public of the error nor issued any kind of recall to fix the existing issue.
NHTSA ODI #11531813
Mileage unknown · Jul 3, 2023
Fuel/propulsion System
Having trouble putting fuel into the tank. While attempting the refuel the vehicle the nozzle will constantly shut off and sometimes fuel will pour out of the filler neck onto the ground. I have to VERY slowly fill up the tank. Not sure if this is related but the fuel nozzle does not fit into the neck properly. Thank you
NHTSA ODI #11530101
Mileage unknown · Jun 27, 2023
Fuel/propulsion System
My 2019 Ram 1500 will not take more than a few ounces of fuel at a time. It takes well over a half hour to refuel my tank. The pump constantly shuts off and the tank constantly spits gasoline back at me when trying to refuel, it is not safe to have gasoline spilled on you. I have a toddler, and I do not want her exposed to th…
Read full complaint
My 2019 Ram 1500 will not take more than a few ounces of fuel at a time. It takes well over a half hour to refuel my tank. The pump constantly shuts off and the tank constantly spits gasoline back at me when trying to refuel, it is not safe to have gasoline spilled on you. I have a toddler, and I do not want her exposed to the fumes after I am doused with gasoline trying to refill my Ram 1500. No warning lights are illuminated on the dashboard. I have scheduled an appointment for a dealer to examine the issue.
NHTSA ODI #11529098
Mileage unknown · May 31, 2023
EngineFuel/propulsion System
Truck had check engine light and sever loss of power Intermittently. Brought to dealer to have it checked. Dealer said they cannot clear the code or fix the issue as the recall in effect does not have the parts out to fix. Recall z46 has been in effect since June of 22 and there is still no solution. I called manufacturer to ask…
Read full complaint
Truck had check engine light and sever loss of power Intermittently. Brought to dealer to have it checked. Dealer said they cannot clear the code or fix the issue as the recall in effect does not have the parts out to fix. Recall z46 has been in effect since June of 22 and there is still no solution. I called manufacturer to ask about it and they all they said was quote "I'm sorry there's nothing we can do about it".
NHTSA ODI #11524735
Mileage unknown · May 7, 2023
Fuel/propulsion System
Fuel pump failure resulted in the loss of propulsion on the Highway.
NHTSA ODI #11520859
Official recalls
29Jul 30, 2026
Chrysler (FCA US, LLC) is recalling certain 2019-2026 Ram 1500 vehicles. The second-row center and left-side seat belt buckle anchors may have been improperly installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: An improperly installed seat belt buckle anchor may fail to properly restrain occupants, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and attach the seat belt buckle anchor to the body structure as necessary, free of charge. Owner notification letters are expected to be mailed August 18, 2026. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 67D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 6, 2026.
Dec 1, 2025
Chrysler (FCA US, LLC) is recalling certain 2019 Ram 1500 Classic, Ram 2500, and Ram 3500 vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.
Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are C2C, C7C, and C8C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 4, 2025.
May 8, 2025
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Additional source detail variants (2)
Air Bags
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Electrical System:wiring
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Jan 16, 2025
Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.
Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Additional source detail variants (2)
Electronic Stability Control (esc):control Module
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Jun 8, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.
Dec 8, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
Consequence & remedy
Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
Jun 9, 2022
Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.
Consequence & remedy
Consequence: Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.
Aug 12, 2021
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Additional source detail variants (2)
Air Bags:side/window:curtain:inflator
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Air Bags:side/window:curtain
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Sep 24, 2020
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence & remedy
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Additional source detail variants (2)
Seat Belts:front:retractor
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Seat Belts
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Sep 10, 2020
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.
Aug 27, 2020
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles equipped with adjustable pedals. In certain accelerator pedal positions, the floormats may prevent the pedal from returning to the normal resting (idle) position.
Consequence & remedy
Consequence: A pedal that does not return as expected may affect the vehicle's deceleration, thereby increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will modify the driver's floormat to remove the potential for pedal interference, free of charge. The recall began September 10, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W63.
Apr 9, 2020
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500, 1500 Classic and Jeep Compass vehicles. The windshield wiper arm or arms may loosen, possibly causing the wipers to not operate properly and reduce the driver's visibility in certain weather conditions.
Consequence & remedy
Consequence: Reduced visibility increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will tighten the wiper nuts, free of charge. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W25.
Feb 13, 2020
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 pickup trucks equipped with four-wheel drive. A gear within the transfer case may not have been installed correctly, possibly causing the vehicle to become stuck in neutral. If this occurs while driving, there could be a sudden loss of power. Additionally, a loss of 'PARK' function may occur.
Consequence & remedy
Consequence: A sudden loss of power or a loss of 'PARK' function may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the transfer case, free of charge. The recall began March 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W06.
Dec 12, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. An incorrect Tire Pressure Monitoring System (TPMS) sensor could have been installed during production causing the sensor to not display the low tire pressure warning indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Without a warning indicator, the driver will be unaware if low tire pressure occurs, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the TPMS sensor, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE1.
Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. These vehicles may have been built with a contaminated electric power steering (EPS) gear that may short circuit, potentially resulting in an intermittent loss of power steering assist.
Consequence & remedy
Consequence: An intermittent loss of power steering assist may cause an inconsistent steering effort, especially during lower speed maneuvers, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the EPS gear assembly, free of charge. The recall began December 12, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA's number for this recall is VB8.
Oct 24, 2019
Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram 1500 and 1500 Classic Pickup trucks equipped with 3.0L Eco Diesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.
Consequence & remedy
Consequence: Combustion in the intake manifold can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. The recall began April 16, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB1.
Jul 26, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The instrument cluster may not properly illuminate driver warnings. As such, these vehicles fails to conform with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: Failure of the instrument cluster to properly illuminate may prevent the driver from receiving warnings about the vehicle's systems and increase the risk of crash.
Remedy: Chrysler will notify owners, and dealers will replace the instrument cluster, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V83.
Jun 13, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. The spare tire provided may differ in size and required inflation pressure from the information on the tire placard label. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: The driver, referencing the tire placard label, may incorrectly inflate the spare tire, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the incorrect size spare tire with the correct size spare tire, free of charge. The recall began June 27, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V67.
May 31, 2019
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence & remedy
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Additional source detail variants (3)
Air Bags: Air Bag/restraint Control Module
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Air Bags
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Apr 25, 2019
Chrysler (FCA US LLC) is recalling certain 2018-2019 Ram 1500 pickup trucks. The rear driveshaft may have an incomplete weld fusion between the tube and tube yoke, which may lead to weld cracking or the driveshaft fracturing.
Consequence & remedy
Consequence: A fractured rear driveshaft could detach from the vehicle and become a road hazard, or it may result in a loss of drive power, both of which can increase the risk of a crash.
Remedy: FCA US will notify owners, and dealers will replace the rear driveshaft, free of charge. The recall began June 13, 2019. Owners may contact FCA US customer service at 1-800-853-1403. The FCA US recall number is V48.
Mar 14, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and 2019 Ram 1500 vehicles. These vehicles have improperly machined steering column stub shafts that may break, possibly causing the steering wheel to detach from the steering column.
Consequence & remedy
Consequence: If the steering wheel detaches from the steering column, the driver may lose control of the vehicle, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will inspect the steering column, replacing it, as necessary, free of charge. The recall began April 5, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V29.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with a 48v auxiliary battery system located behind the rear seat (sales code: XBZ). Due to an incorrect assembly repair process, the auxiliary battery wire terminal connection may overheat.
Consequence & remedy
Consequence: If the auxiliary battery system overheats, there is an increased risk of a fire within the cabin even if the ignition is off.
Remedy: FCA US has notified owners, and dealers will properly secure the auxiliary battery fasteners, free of charge. The recall began March 15, 2019. Owners may contact Chrysler's customer service at 1-800-853-1403. The Chrysler number for this recall is V17.
Feb 5, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with adjustable pedals. The affected vehicles have a brake pedal that may move too far and separate from pedal assembly.
Consequence & remedy
Consequence: If the brake pedal separates from the pedal assembly, the driver may be unable to brake the vehicle, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will repair the adjustable pedal assembly, free of charge. The recall began on February 25, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V07.
Jan 24, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The battery ground fastener on the driver-side front fender may have been improperly secured, possibly resulting in a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering could vary the steering effort required, possibly causing vehicle oversteer or understeer, increasing the risk of crash.
Remedy: Chrysler has notified owners, and dealers will properly secure the ground fastener, free of charge. The recall began on February 11, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V04.
Jan 24, 2019
Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 vehicles equipped with a 12" touchscreen display and a base-level heating, ventilation and air conditioning ("HVAC") system. Vehicles with this combination do not have a functioning windshield defrosting and defogging system. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield defrosting and defogging systems."
Consequence & remedy
Consequence: The lack of a functioning windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will repurchase the affected vehicles. The recall began March 7, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V12.
Nov 20, 2018
Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 trucks. The seat track position sensor on the manually-adjusted passenger seats may come loose and out of position, preventing the sensor from detecting if the seat is in the full-forward position.
Consequence & remedy
Consequence: If the sensor cannot identify that the seat is in the full-forward position and adjust the frontal air bag deployment accordingly, there would be an increased the risk of a injury in the event of a crash.
Remedy: Chrysler will notify owners and dealers will inspect the passenger seat track position sensor bracket, replacing it as necessary, free of charge. The recall began December 20, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB7.
Aug 23, 2018
Chrysler (FCA US LLC) is recalling certain 2018-2019 RAM 1500 trucks. The rear differential may have been insufficiently filled, possibly resulting in its failure.
Consequence & remedy
Consequence: If the rear axle assembly fails, it can cause a loss of drive or the rear wheels may lock up. Either scenario increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the rear axle oil level. Rear axles with an insufficient amount of oil will be replaced, free of charge. The recall began September 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U88.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA23001 · High Pressure Fuel Pump Failure
Opened Mar 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337
Illustration