NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
227 reportsClear category filterMileage unknown · Sep 1, 2021
Electrical SystemEnginePower Train
I purchased my truck new in Nov 2019. Since then I have had four different occasions where my truck has stalled while driving at low speed or while shifting from drive to reverse. Two of the occasions I was pulling away from a stop and the truck stalled and I was stuck in the middle of the intersection until I put the truck in p…
Read full complaint
I purchased my truck new in Nov 2019. Since then I have had four different occasions where my truck has stalled while driving at low speed or while shifting from drive to reverse. Two of the occasions I was pulling away from a stop and the truck stalled and I was stuck in the middle of the intersection until I put the truck in park and restarted. Luckily there was no cross traffic so there was no danger in this situation but it could have been much worse. The last occasion happened a couple weeks ago when I was moving my truck in my driveway. I shifted to drive and pulled forward then put my truck in reverse. As I put my truck in reverse it immediately stalled. I put it in park and was able to immediately restart it. However, it did have a check engine light on. The next morning I was going to take the truck to the dealer to have the light checked but it had cleared itself and there are no codes stored so the dealer can't do anything.
NHTSA ODI #11431361
29,497 miles · Aug 30, 2021
Engine
2019 DODGE RAM. CONSUMER WRITES IN REGARDS TO ILLUMINATED SERVICE LIGHTS. THE CONSUMER STATED THE ENGINE LIGHT, BATTERY LIGHT AND ADAPTABLE CRUISE CONTROL WARNING LIGHTS ILLUMINATED ON MULTIPLE OCCASIONS. WHILE DRIVING, THE VEHICLE LOST POWER STEERING, LEAKED A LIQUID, SMOKE EMITTED FROM UNDER THE HOOD AND THE DASHBOARD WENT D…
Read full complaint
2019 DODGE RAM. CONSUMER WRITES IN REGARDS TO ILLUMINATED SERVICE LIGHTS. THE CONSUMER STATED THE ENGINE LIGHT, BATTERY LIGHT AND ADAPTABLE CRUISE CONTROL WARNING LIGHTS ILLUMINATED ON MULTIPLE OCCASIONS. WHILE DRIVING, THE VEHICLE LOST POWER STEERING, LEAKED A LIQUID, SMOKE EMITTED FROM UNDER THE HOOD AND THE DASHBOARD WENT DARK. ALSO THE TAILGATE OPENS INTERMITTENTLY, RADIO SHUTS OFF INDEPENDENTLY, VOLTS ARE READING LOW, AND BATTERY IS IN SAVER MODE.
NHTSA ODI #11431071
Mileage unknown · Aug 13, 2021
EngineFuel/propulsion System
The exhaust system builds up soot and causes the vehicle to malfunction or require excessive EGR cleaning. My vehicle has been in 4 times for the same issue. The dealership admitted they have had many of the same vehicles in for the same issue. It will freeze up when driving and prevent going forward. I have called Ram and they …
Read full complaint
The exhaust system builds up soot and causes the vehicle to malfunction or require excessive EGR cleaning. My vehicle has been in 4 times for the same issue. The dealership admitted they have had many of the same vehicles in for the same issue. It will freeze up when driving and prevent going forward. I have called Ram and they refuse to consider anything because my issue is a maintenance issue the dealership already told me should not be necessary until 60,000-90,000 miles and I should know it will need to be done every 10,000 miles if I do not drive more than I do. I was never informed of the issue when purchasing the vehicle brand new.
NHTSA ODI #11428948
Mileage unknown · Jun 26, 2021
EnginePower Train
The vehicle has a tendency to hesitate when accelerating from a stop. It is as if the engine is stalling and then recovers. It occurs primarily when the engine is cold but has also happened when warmed up This is a safety hazard because it could leave the vehicle subject to collision form approaching traffic.
NHTSA ODI #11422417
Mileage unknown · Jun 20, 2021
Engine
Driving on hwy 85 north kind in Atlanta going 65moh in rain truck stalls on 5 lane busy hwy in middle lane almost causes accidents . Engine bogged out and made it to side of road where engine failed to stay on , vehicle shakes when trying to start .....almost killed me
NHTSA ODI #11421519
Mileage unknown · Jun 2, 2021
Electrical SystemEngineService Brakes
While driving,usually slowing from highway speed,all safety lights turn on on the dash board (cross traffic,anti collision,rear parking,ignition,stabilitrak,check engine).Also vehicle loses power and you can not accelerate.Engine runs on (assuming) 4 cylinders as it starts shaking like it’s misfiring.After you pull over and rest…
Read full complaint
While driving,usually slowing from highway speed,all safety lights turn on on the dash board (cross traffic,anti collision,rear parking,ignition,stabilitrak,check engine).Also vehicle loses power and you can not accelerate.Engine runs on (assuming) 4 cylinders as it starts shaking like it’s misfiring.After you pull over and restart the engine all lights clear except check engine.Vehicle than runs normal.Check engine has cleared twice on me.Once after about 30 and second time after about 50 miles.In both instances I was away from home and had to drive back.The other few times was only a few miles away from dealer.Vehicle is currently at the dealer (7th time) with 35775 miles.Multiple tickets have been opened with FCA.In my own research I have found online forums with identical issues.The dealer is at the liss.Their techs can’t figure it out.They have replaced multiple parts but the issue remains. NOTE:Your system allows me to select three issues at the start of this form but I have three more under ADAS category that I was unable to select.
NHTSA ODI #11419320
45,000 miles · May 10, 2021
Electrical SystemEngineUnknown Or Other
VEHICLE WARNING DISPLAY ON THE SPEEDOMETER ISN'T WORKING. IT'S A 2019 RAM WITH 45K MILES. IT GOES BLANK OR WON'T COME ON. WITHOUT THIS DISPLAY WORKING PROPERLY, DRIVER CANNOT SEE ANY WARNING SUCH AS, DOOR OPEN, TIRE PRESSURE OR ANY IMPORTANT WARNINGS. THE VEHICLE IS DRIVABLE BUT THE WARNING DASH ON THE SPEEDOMETER DOESN'T WORK.
NHTSA ODI #11415767
Mileage unknown · Apr 20, 2021
EngineFuel/propulsion SystemUnknown Or Other
WHILE DRIVING ON APRIL 15, 2021, STOPPED AT A RED LIGHT AND CAR COMPLETELY SHUT OFF AND WOULD NOT START BACK UP. TRIED JUMPING CAR NUMEROUS TIMES BUT STILL WOULD NOT START. HAD CAR TOWED TO DEALER AND CAR STILL WOULD NOT START. DEALER CAN NOT DIAGNOSE WHAT ISSUE IS AND CAN NOT DEFINE WHY CAR CUT OFF IN THE MIDDLE OF TRAFFIC
NHTSA ODI #11412966
22,000 miles · Apr 10, 2021
EngineFuel/propulsion SystemPower Train
VEHICLE WAS IN MOTION, GENTLY TURNING RIGHT AND DECELERATING, MOVING APPROX. 60 MPH EXITING INTERSTATE WHEN ENGINE SHUTOFF. DASH DISPLAY READ MESSAGE TO SHIFT CAR INTO PARK. DRIVE SHIFT KNOB FLASHED 'D'. ACCESSORY POWER REMAINED ON. VEHICLE WAS COASTED TO A STOP, SHIFTED TO PARK, POWERED OFF, AND RESTARTED. DRIVER ACCELERATED V…
Read full complaint
VEHICLE WAS IN MOTION, GENTLY TURNING RIGHT AND DECELERATING, MOVING APPROX. 60 MPH EXITING INTERSTATE WHEN ENGINE SHUTOFF. DASH DISPLAY READ MESSAGE TO SHIFT CAR INTO PARK. DRIVE SHIFT KNOB FLASHED 'D'. ACCESSORY POWER REMAINED ON. VEHICLE WAS COASTED TO A STOP, SHIFTED TO PARK, POWERED OFF, AND RESTARTED. DRIVER ACCELERATED VEHICLE TO MERGE BACK INTO TRAFFIC, TRIGGERING ANOTHER ENGINE SHUTOFF WITH THE SAME CONDITION. AFTER SECOND RESTART, WHEN VEHICLE WAS IN PARK THE ENGINE WAS REVVED TO VERIFY A POWER LIMIT REDLINE WAS NOT BEING SURPASSED CAUSING ENGINE SHUTOFF. AC/RADIO WAS POWERED DOWN AND VEHICLE REACHED DESTINATION 5 MINUTES AWAY WITHOUT FURTHER INCIDENT. CAUSE OF ENGINE FAILURE UNKNOWN, ALL FLUID LEVELS/TEMPERATURES NOMINAL, NO SMOKE OR VISUAL INDICATIONS OF FAILURE ON THE VEHICLE.
NHTSA ODI #11407397
39,350 miles · Mar 29, 2021
Electrical SystemEngineFuel/propulsion System
I WAS DRIVING ON I-65 IN INDIANAPOLIS, IN TRAFFIC, WHEN MY ENGINE ABRUPTLY SHUT OFF AND THE IGNITION MODE SWITCHED FROM RUN TO ACC. THIS CAUSED ME TO LOSE ALL PROPULSION POWER AND I WAS FORCED TO CROSS LANES TO GET OVER TO THE RIGHT SHOULDER. LUCKILY, I WAS STILL A MILE OR TWO FROM THE UPCOMING CONSTRUCTION ZONE, WHICH WOULD HAV…
Read full complaint
I WAS DRIVING ON I-65 IN INDIANAPOLIS, IN TRAFFIC, WHEN MY ENGINE ABRUPTLY SHUT OFF AND THE IGNITION MODE SWITCHED FROM RUN TO ACC. THIS CAUSED ME TO LOSE ALL PROPULSION POWER AND I WAS FORCED TO CROSS LANES TO GET OVER TO THE RIGHT SHOULDER. LUCKILY, I WAS STILL A MILE OR TWO FROM THE UPCOMING CONSTRUCTION ZONE, WHICH WOULD HAVE PREVENTED ME FROM BEING ABLE TO PULL OFF ONTO A SHOULDER. BECAUSE THE ENGINE HAD SHUT OFF WHILE THE TRUCK WAS MOVING, THE COMPUTER SYSTEM IS PROGRAMMED TO SHIFT THE TRANSMISSION INTO PARK, BUT BECAUSE I WAS GOING 70MPH ON THE HIGHWAY (>5MPH ACCORDING TO MY USER MANUAL), IT JUST ALERTED ME THAT MY ENGINE WAS OFF AND THAT I WAS IN ACC MODE. AFTER PARKING THE TRUCK ON THE SHOULDER WITH HAZARDS ON, I TURNED THE ENGINE OFF AND WAITED A FEW SECONDS BEFORE TRYING TO START IT AGAIN. WHEN I PRESSED THE BRAKE AND THE IGNITION BUTTON, THE TRUCK STARTED UP IMMEDIATELY, LIKE NORMAL, BUT THEN 2 SECONDS LATER IT CUT OUT AGAIN WITH THE SAME RUN-TO-ACC MODE SWITCH. THIS HAPPENED 6-7 MORE TIMES BEFORE THE TRUCK SOMEHOW STAYED ON RUN. I CHECKED THE ENGINE AND MY FLUIDS FOR ANYTHING ODD, BUT MECHANICALLY, THE TRUCK WAS FINE. NO CHECK ENGINE OR WARNING LIGHTS EVER CAME ON. THE COMPUTER SYSTEM DIDN'T RECOGNIZE THAT ANYTHING WAS WRONG OTHER THAN THE INITIAL INDICATION. I WAS ABLE TO GET HOME WITHOUT ISSUES AFTER THAT, BUT WHEN I WENT TO TURN THE ENGINE OFF, I COULDN'T. THE IGNITION BUTTON HAD STOPPED RESPONDING. I TRIED ALL OF THE USER MANUAL'S METHODS TO TURN IT OFF, BUT NOTHING WORKED. THIS VEHICLE DOESN'T HAVE A MANUAL KEY IGNITION OVERRIDE, JUST THE FOB AND KEYLESS BUTTON, NEITHER OF WHICH COULD TURN THE ENGINE OFF. THE FOB'S REMOTE START/SHUTOFF DIDN'T WORK EITHER. IN THE END, I HAD TO DISCONNECT THE BATTERY TO FORCE THE ENGINE AND COMPUTER SYSTEM TO TURN OFF. I'M TAKING IT INTO THE LOCAL DEALER, VIA TOW IF IT WON'T START AGAIN, TO FIGURE OUT WHAT HAPPENED.
NHTSA ODI #11405327
Official recalls
29Jul 30, 2026
Chrysler (FCA US, LLC) is recalling certain 2019-2026 Ram 1500 vehicles. The second-row center and left-side seat belt buckle anchors may have been improperly installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: An improperly installed seat belt buckle anchor may fail to properly restrain occupants, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and attach the seat belt buckle anchor to the body structure as necessary, free of charge. Owner notification letters are expected to be mailed August 18, 2026. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 67D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 6, 2026.
Dec 1, 2025
Chrysler (FCA US, LLC) is recalling certain 2019 Ram 1500 Classic, Ram 2500, and Ram 3500 vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.
Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are C2C, C7C, and C8C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 4, 2025.
May 8, 2025
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Additional source detail variants (2)
Air Bags
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Electrical System:wiring
Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.
Jan 16, 2025
Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.
Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.
Sep 5, 2024
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Additional source detail variants (2)
Electronic Stability Control (esc):control Module
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.
Jun 8, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.
Dec 8, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
Consequence & remedy
Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
Jun 9, 2022
Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.
Consequence & remedy
Consequence: Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.
Aug 12, 2021
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Additional source detail variants (2)
Air Bags:side/window:curtain:inflator
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Air Bags:side/window:curtain
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Sep 24, 2020
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence & remedy
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Additional source detail variants (2)
Seat Belts:front:retractor
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Seat Belts
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.
Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.
Sep 10, 2020
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.
Aug 27, 2020
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles equipped with adjustable pedals. In certain accelerator pedal positions, the floormats may prevent the pedal from returning to the normal resting (idle) position.
Consequence & remedy
Consequence: A pedal that does not return as expected may affect the vehicle's deceleration, thereby increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will modify the driver's floormat to remove the potential for pedal interference, free of charge. The recall began September 10, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W63.
Apr 9, 2020
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500, 1500 Classic and Jeep Compass vehicles. The windshield wiper arm or arms may loosen, possibly causing the wipers to not operate properly and reduce the driver's visibility in certain weather conditions.
Consequence & remedy
Consequence: Reduced visibility increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will tighten the wiper nuts, free of charge. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W25.
Feb 13, 2020
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 pickup trucks equipped with four-wheel drive. A gear within the transfer case may not have been installed correctly, possibly causing the vehicle to become stuck in neutral. If this occurs while driving, there could be a sudden loss of power. Additionally, a loss of 'PARK' function may occur.
Consequence & remedy
Consequence: A sudden loss of power or a loss of 'PARK' function may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the transfer case, free of charge. The recall began March 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W06.
Dec 12, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. An incorrect Tire Pressure Monitoring System (TPMS) sensor could have been installed during production causing the sensor to not display the low tire pressure warning indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Without a warning indicator, the driver will be unaware if low tire pressure occurs, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the TPMS sensor, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE1.
Nov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. These vehicles may have been built with a contaminated electric power steering (EPS) gear that may short circuit, potentially resulting in an intermittent loss of power steering assist.
Consequence & remedy
Consequence: An intermittent loss of power steering assist may cause an inconsistent steering effort, especially during lower speed maneuvers, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the EPS gear assembly, free of charge. The recall began December 12, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA's number for this recall is VB8.
Oct 24, 2019
Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram 1500 and 1500 Classic Pickup trucks equipped with 3.0L Eco Diesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.
Consequence & remedy
Consequence: Combustion in the intake manifold can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. The recall began April 16, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB1.
Jul 26, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The instrument cluster may not properly illuminate driver warnings. As such, these vehicles fails to conform with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: Failure of the instrument cluster to properly illuminate may prevent the driver from receiving warnings about the vehicle's systems and increase the risk of crash.
Remedy: Chrysler will notify owners, and dealers will replace the instrument cluster, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V83.
Jun 13, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. The spare tire provided may differ in size and required inflation pressure from the information on the tire placard label. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: The driver, referencing the tire placard label, may incorrectly inflate the spare tire, increasing the risk of a crash.
Remedy: Chrysler has notified owners, and dealers will replace the incorrect size spare tire with the correct size spare tire, free of charge. The recall began June 27, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V67.
May 31, 2019
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence & remedy
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Additional source detail variants (3)
Air Bags: Air Bag/restraint Control Module
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Air Bags
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.
Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.
Apr 25, 2019
Chrysler (FCA US LLC) is recalling certain 2018-2019 Ram 1500 pickup trucks. The rear driveshaft may have an incomplete weld fusion between the tube and tube yoke, which may lead to weld cracking or the driveshaft fracturing.
Consequence & remedy
Consequence: A fractured rear driveshaft could detach from the vehicle and become a road hazard, or it may result in a loss of drive power, both of which can increase the risk of a crash.
Remedy: FCA US will notify owners, and dealers will replace the rear driveshaft, free of charge. The recall began June 13, 2019. Owners may contact FCA US customer service at 1-800-853-1403. The FCA US recall number is V48.
Mar 14, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and 2019 Ram 1500 vehicles. These vehicles have improperly machined steering column stub shafts that may break, possibly causing the steering wheel to detach from the steering column.
Consequence & remedy
Consequence: If the steering wheel detaches from the steering column, the driver may lose control of the vehicle, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will inspect the steering column, replacing it, as necessary, free of charge. The recall began April 5, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V29.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with a 48v auxiliary battery system located behind the rear seat (sales code: XBZ). Due to an incorrect assembly repair process, the auxiliary battery wire terminal connection may overheat.
Consequence & remedy
Consequence: If the auxiliary battery system overheats, there is an increased risk of a fire within the cabin even if the ignition is off.
Remedy: FCA US has notified owners, and dealers will properly secure the auxiliary battery fasteners, free of charge. The recall began March 15, 2019. Owners may contact Chrysler's customer service at 1-800-853-1403. The Chrysler number for this recall is V17.
Feb 5, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with adjustable pedals. The affected vehicles have a brake pedal that may move too far and separate from pedal assembly.
Consequence & remedy
Consequence: If the brake pedal separates from the pedal assembly, the driver may be unable to brake the vehicle, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will repair the adjustable pedal assembly, free of charge. The recall began on February 25, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V07.
Jan 24, 2019
Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The battery ground fastener on the driver-side front fender may have been improperly secured, possibly resulting in a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering could vary the steering effort required, possibly causing vehicle oversteer or understeer, increasing the risk of crash.
Remedy: Chrysler has notified owners, and dealers will properly secure the ground fastener, free of charge. The recall began on February 11, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V04.
Jan 24, 2019
Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 vehicles equipped with a 12" touchscreen display and a base-level heating, ventilation and air conditioning ("HVAC") system. Vehicles with this combination do not have a functioning windshield defrosting and defogging system. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield defrosting and defogging systems."
Consequence & remedy
Consequence: The lack of a functioning windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will repurchase the affected vehicles. The recall began March 7, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V12.
Nov 20, 2018
Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 trucks. The seat track position sensor on the manually-adjusted passenger seats may come loose and out of position, preventing the sensor from detecting if the seat is in the full-forward position.
Consequence & remedy
Consequence: If the sensor cannot identify that the seat is in the full-forward position and adjust the frontal air bag deployment accordingly, there would be an increased the risk of a injury in the event of a crash.
Remedy: Chrysler will notify owners and dealers will inspect the passenger seat track position sensor bracket, replacing it as necessary, free of charge. The recall began December 20, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB7.
Aug 23, 2018
Chrysler (FCA US LLC) is recalling certain 2018-2019 RAM 1500 trucks. The rear differential may have been insufficiently filled, possibly resulting in its failure.
Consequence & remedy
Consequence: If the rear axle assembly fails, it can cause a loss of drive or the rear wheels may lock up. Either scenario increases the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the rear axle oil level. Rear axles with an insufficient amount of oil will be replaced, free of charge. The recall began September 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U88.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA23001 · High Pressure Fuel Pump Failure
Opened Mar 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337
Illustration