IllustrationCRACK IN REAR AXLE CAUSED AXLE TO DISCONNECT/FALL OFF WHILE DRIVING, DRIVER LOST CONTROL, VEHICLE ROCKED BACK/FORTH, COUNTER FLIPPED OVER, LANDED ON TOP, VEHICLE TOTALED. PLEASE PROVIDE VIN. *AK
1991 Pontiac Trans Sport
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Pontiac Trans Sport do not stand out strongly from the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trans Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 36 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports2 fire reports2 injury reports
What owners actually said
36 reportsVEHICLE SMOKING FRONT BRAKES HAD A BURNING SMELL AND SMOKING,MELTED THE HUB CAPS ON THE VEHICLE. ALSO REPLACED CALIPERS. IN ADDITION, VEHICLE HAD A COOLANT LEAK. *AK
DRIVER'S SEAT BELT RETRACTOR BROKE.
DASHBOARD EQUIPMENT IS TOO REFLECTIVE. *AK
DRIVING HOME AND THE BELT JUST CAME LOOSE, TRIED TO TIGHTEN AGAINST BODY BUT IT JUST WOULDN'T TIGHTEN. *AK
AN ELECTRICAL SHORT IN THE WIRING IN THE ROOF, CAUSING VEHICLE TO CATCH ON FIRE WHILE THE VEHICLE WAS PARKED. *AK
PASSENGER SIDE SEAT BELT IS FULLY EXTENDED, AND WILL NOT RETRACT.*AK
BRAKE HOSE BROKE, CAUSING HYDRAULIC FLUID TO LEAK, BRAKE FAILURE. *SD
WHILE DRIVING EXPERIENCED FAILURE OF BOTH BRAKE LINE HOSES DUE TO EXCESSIVE WEAR, UPON BRAKING PEDAL WENT TO FLOOR THEN CONTINUED TO ROLL FORWARD,NO WARNING.*AK
TURN ON TRUCK TOOK THE EMERGENCY BRAKE OFF AND TRUCK JUMPED OUT OF PARK POSITION . TT
Official recalls
297V058000 · Structure
Apr 8, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
92V012000 · Structure:body
Jan 28, 1992
THE GLOVE COMPARTMENT DOOR WILL NOT REMAIN CLOSED DURING CERTAIN LOAD FORCES ASSOCIATED WITH A VEHICLE CRASH. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 201.
Consequence & remedy
Consequence: IN THE EVENT OF AN ACCIDENT, THE GLOVE COMPARTMENT DOORMAY OPEN AND RESULT IN OCCUPANT(S) INJURIES FROM CONTACT WITH THE GLOVECOMPARTMENT DOOR.
Remedy: REPLACE THE CURRENT UPPER GLOVE COMPARTMENT DOOR WITH A REDESIGNED UPPER GLOVE COMPARTMENT DOOR WHICH INCORPORATES A POSITIVE LATCH TO KEEP THE DOOR CLOSED SHOULD A VEHICLE CRASH OCCUR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
EA97019 · Front Seat Back Collapse
Opened Sep 30, 1997 · Closed Jun 8, 1999
Status: closed (inferred from source dates) · Seats
ALLEGED FRONT SEAT BACK COLLAPSE DUE TO RECLINER BOLT
PE97016 · Front Seat Back Collapse
Opened Apr 7, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Seats
SUBJECT VEHICLES ARE ALLEGED TO EXPERIENCE INADVERTENT FRONT SEAT BACK COLLAPSE DUE TO FRACTURE OF FRONT SEAT RECLINER MOUNTING BOLTS.
EA92035 · Apv Fuel Line Fires
Opened Oct 30, 1992 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES
PE92052 · Apv Fuel Line Fires
Opened Jun 4, 1992 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available