TL*THE CONTACT OWNS A 2004 PONTIAC SUNFIRE. WHILE DRIVING AT VARIOUS SPEEDS, THE SPEEDOMETER DISPLAYS INACCURATE READINGS. THE DEALER STATED THAT THEY WOULD HAVE TO REPLACE THE SPEEDOMETER CLUSTER IN THE INSTRUMENT CONTROL PANEL. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE COST. THE FAILURE AND CURRENT MILEAGES WERE 20,000.…
Read full complaint
TL*THE CONTACT OWNS A 2004 PONTIAC SUNFIRE. WHILE DRIVING AT VARIOUS SPEEDS, THE SPEEDOMETER DISPLAYS INACCURATE READINGS. THE DEALER STATED THAT THEY WOULD HAVE TO REPLACE THE SPEEDOMETER CLUSTER IN THE INSTRUMENT CONTROL PANEL. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE COST. THE FAILURE AND CURRENT MILEAGES WERE 20,000. UPDATED 07/09/08 *BF THE CONSUMER STATED THE PROBLEM OCCURS WHEN IT IS REALLY HOT OR COLD OUTSIDE. UPDATED
NHTSA ODI #10216893
51,550 miles · Dec 9, 2007
Electrical System
ALL GAUGES WERE ACCURATE UNTIL ONE MORNING WHEN I WAS DRIVING AND NOTICED THAT THE SPEEDOMETER WAS STUCK ON 50 WHEN CAR WASH COMPLETELY STOPPED. AS I DROVE FARTHER THE SPEEDOMETER ROSE TO 70 WHEN AT A COMPLETE STOP. THE RPM GAUGE IS READING 0 WHEN CAR IS IN MOTION WHICH IS COMPLETELY IMPOSSIBLE. *TR
NHTSA ODI #10211255
34,000 miles · Sep 19, 2006
Electrical SystemEngine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS OR WHILE STOPPED AT AN IDLE, THE ENGINE STALLED WITHOUT WARNING. AFTERWARDS, THE ENGINE WAS EASILY RESTARTED. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE BATTERY, AIR FLOW SENSOR, ALTITUDE SENSOR, AND THE FUEL FILTER FITTING NEEDED TO BE REPLACED. ALTHOUGH THE …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS OR WHILE STOPPED AT AN IDLE, THE ENGINE STALLED WITHOUT WARNING. AFTERWARDS, THE ENGINE WAS EASILY RESTARTED. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE BATTERY, AIR FLOW SENSOR, ALTITUDE SENSOR, AND THE FUEL FILTER FITTING NEEDED TO BE REPLACED. ALTHOUGH THE REPLACEMENTS WERE MADE, THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10168661
Mileage unknown · Mar 21, 2005
Electrical System
WHEN DRIVING MY 2004 SUNFIRE THE DASH SEEMS TO GET REALLY HOT AND SMELLS LIKE SOMETHING IS BURNING. I AM AFRAID THAT IT IS GOING TO CATCH ON FIRE.*AK
NHTSA ODI #10114420
13,000 miles · Feb 20, 2005
Electrical SystemFire
I WAS DRIVING MY NEW 2004 SUNFIRE THAT WAS JUST PURCHASED AT THE END OF AUGUST, WHEN I SAW A FLAME COME OUT FROM UNDER THE DASH NEAR MY FOOT. I SLAMMED ON THE BRAKES, THROUGH IT IN PARK AND JUMPED FROM THE VEHICLE. THE VEHICLE WAS TOTALED!*JB
NHTSA ODI #10111861
12,500 miles · Apr 19, 2004
Electrical SystemEngine And Engine Cooling
WHEN STOPPING AT A STOP LIGHT VEHICLE STALLED, AND THE BATTERY LIGHT CAME ON. *AK
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.
Consequence & remedy
Consequence: IN A SEVERE CRASH, THE UPPER SEAT BELT ANCHORAGE MAY SEPARATE. THE EFFECTIVENESS OF THE SEAT BELT COULD THEN BE REDUCED AND THE OCCUPANT COULD RECEIVE GREATER INJURIES.
Remedy: DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Pontiac Sunfire Problems, Complaints & Recalls | Skip That Year
Illustration