Electrical SystemEngine And Engine CoolingFuel System, Other
WHEN I BOUGHT THE CAR USED IN OCTOBER OF 2000 IT HAD TO KEEP GOING BACK TO THE DEALER FOR ABOUT 3 MONTHS BECAUSE THE ENGINE IN THE CAR KEPT CUTTING OUT WHILE DRIVING AROUND 55-60 MPH. DEALER COULD NOT DUPLICATE THE PROBLEM. FINALLY AFTER THE 3RD MONTH THEY FOUND THE MAIN COMPUTER WAS BAD. THAT WAS REPLACED. IT RAN FINE UNTIL TH…
Read full complaint
WHEN I BOUGHT THE CAR USED IN OCTOBER OF 2000 IT HAD TO KEEP GOING BACK TO THE DEALER FOR ABOUT 3 MONTHS BECAUSE THE ENGINE IN THE CAR KEPT CUTTING OUT WHILE DRIVING AROUND 55-60 MPH. DEALER COULD NOT DUPLICATE THE PROBLEM. FINALLY AFTER THE 3RD MONTH THEY FOUND THE MAIN COMPUTER WAS BAD. THAT WAS REPLACED. IT RAN FINE UNTIL THE NEXT WINTER. THE CHECK ENGINE LIGHT CAME ON & CAR KEPT STALLING WHEN AT STOP SIGNS/LIGHTS. TOOK TO DEALER HAD DIAGNOSTIC RAN WHICH READ FAULTY GAS CAP, TPS SENSOR.... I REPLACED THEM MYSELF. CHECK ENGINE LIGHT WENT OUT TILL THE NEXT DAY. TOOK CAR BACK IN FOR DIAGNOSTIC WHICH READ FAULTY GAS CAP, TPS SENSOR,EGR ,COIL PACKS,GAS TANK SENSOR.....HAD DEALER WORK ON IT.... THEY COULD NOT SEE WHY ALL THIS STUFF WAS POPPING UP ....HAD IT ALL REPLACED. REPLACING IT DID NOT WORK. CHECK ENGINE LIGHT CAME ON AGAIN ABOUT 2 DAYS LATER!!! I CHECKED CAR OVER & FOUND IF YOU WIGGLED THE MAIN WIRING HARNESS CONNECTIONS THE CAR RAN FINE & ENGINE LIGHT WENT OUT! TOOK TO DEALER TO HAVE WIRING FIXED. THEY TOOK ALL THE WIRING APART & CLEANED EVERYTHING. THEY FOUND NO PROBLEM IN THE WIRING. CHECK ENGINE LIGHT CAME ON NEXT DAY.TOOK TO DEALER AGAIN FINALLY THEY SAID I NEEDED A NEW BATTERY..... WEATHER WAS NICE AGAIN & HAD NO PROBLEMS WITH CAR.... NOW THAT WINTER IS HERE AGAIN THE CHECK ENGINE LIGHT IS ON AGAIN , DIAGNOSTIC STATED TPS SENSOR WAS BAD... I AGAIN REPLACED IT & CHECK ENGINE LIGHT WENT OUT FOR A COUPLE HOURS & IS BACK ON AGAIN & CAR STALLS WHEN STOPPING & TRYING TO GO ....CAR IS AT DEALER RIGHT NOW AGAIN. THE WHOLE TIME THE CHECK ENGINE LIGHT IS ON I ALSO HAVE PROBLEMS WITH THE CAR STALLING.................... HAVE HAD NUMEROUS PROBLEMS FROM 2000 TO NOW & STILL HAVING PROBLEMS. *AK
NHTSA ODI #10105764
78,150 miles · Feb 16, 2004
Fuel System, Other
THIS CONCERNS THE FUEL SYSTEM ON '98 (AND SIMILAR YEAR) PONTIAC SUNFIRES. ON DECEMBER 29, 2003 THIS VEHICLE WAS TAKEN IN FOR REPLACEMENT OF THE IN-LINE FUEL FILTER. THE VEHICLE HAD BEEN LOSING ACCELERATION AND HAS 78,000 MILES ON IT. IT WAS TAKEN TO A PONTIAC DEALER FOR THE SERVICE. THE FILTER IS CONNECTED TO THE FUEL LINE …
Read full complaint
THIS CONCERNS THE FUEL SYSTEM ON '98 (AND SIMILAR YEAR) PONTIAC SUNFIRES. ON DECEMBER 29, 2003 THIS VEHICLE WAS TAKEN IN FOR REPLACEMENT OF THE IN-LINE FUEL FILTER. THE VEHICLE HAD BEEN LOSING ACCELERATION AND HAS 78,000 MILES ON IT. IT WAS TAKEN TO A PONTIAC DEALER FOR THE SERVICE. THE FILTER IS CONNECTED TO THE FUEL LINE WITH A 'SNAP' FITTING. UPON TRYING TO SERVICE THE FILTER, EITHER THE DEALER BROKE THE SNAP FITTING OR THE PREVIOUS OWNER HAD DAMAGED IT (VEHICLE WAS PURCHASED WITH 45,000 MILES ON IT, AND THERE WERE NO LEAKS SO I SUSPECT THAT IT WASN'T DAMAGED). ALSO, THERE WAS A FAIR AMOUNT OF CORROSION ON AND IN THE FITTING. IN THE END, THE FILTER COULD NOT BE REPLACED WITHOUT CORRECTING THE 'SNAP' FITTING. TO MY SURPRISE THE FUEL LINE COULD NOT BE REPLACED AS A SEPARATE PIECE, YOU HAVE TO PURCHASE THE ENTIRE FUEL DELIVERY MODULE. THIS COST (WITH THE TECHNICIAN TIME) WAS $ 425 VS. $50 FOR A FILTER REPLACEMENT. IT WOULD SEEM TO ME THAT SINCE THE FILTER IS A CRITICAL PART OF THE SYSTEM (A CLOGGED FILTER COULD RESULT IN VEHICLE STALLS AND/OR NO STARTS, EMISSION ISSUES ETC.) THAT IT SHOULD HAVE SOME SORT OF REASONABLE WAY TO REPLACE IT WITHOUT PAYING FOR AN ENTIRE MODULE THAT WAS NOT NEEDED. THE FILTER IS A RECOMMENDED SERVICE ITEM. *AK
NHTSA ODI #10058231
Mileage unknown · Aug 20, 1998
Fuel System, Other
AFTER AIR CONDITIONER IS CUT OFF THE SPEEDOMETER GETS FOGGED UP.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Illustration