Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 119 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports11 fire reports7 injury reports
What owners actually said
119 reports
115,000 miles · Oct 6, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 1995 PONTIAC SUNFIRE. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL ENGAGED; WHEN SHE TURNED THE CRUISE CONTROL OFF AND ATTEMPTED TO SLOW DOWN, THE ACCELERATOR PEDAL SUDDENLY STUCK. AFTER REPEATED PRESSURE TO THE BRAKE PEDAL, THE ACCELERATOR PEDAL BECAME DISLODGED. THE VEHICLE HAD NOT…
Read full complaint
TL*THE CONTACT OWNS A 1995 PONTIAC SUNFIRE. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL ENGAGED; WHEN SHE TURNED THE CRUISE CONTROL OFF AND ATTEMPTED TO SLOW DOWN, THE ACCELERATOR PEDAL SUDDENLY STUCK. AFTER REPEATED PRESSURE TO THE BRAKE PEDAL, THE ACCELERATOR PEDAL BECAME DISLODGED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 115,000.
NHTSA ODI #10359400
157,000 miles · Mar 27, 2008
Electrical SystemFire
TL*THE CONTACT OWNS A 1995 PONTIAC SUNFIRE. THE CONTACT EXPERIENCED DIFFICULTY STARTING HER VEHICLE AND TURNING THE IGNITION SWITCH. THE FOLLOWING MORNING, SHE OPENED THE DOOR AND NOTICED THAT THE STEERING COLUMN MELTED AND WAS LYING ON THE FLOORBOARD. A POLICE REPORT WAS FILED. THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBE…
Read full complaint
TL*THE CONTACT OWNS A 1995 PONTIAC SUNFIRE. THE CONTACT EXPERIENCED DIFFICULTY STARTING HER VEHICLE AND TURNING THE IGNITION SWITCH. THE FOLLOWING MORNING, SHE OPENED THE DOOR AND NOTICED THAT THE STEERING COLUMN MELTED AND WAS LYING ON THE FLOORBOARD. A POLICE REPORT WAS FILED. THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 02V070000 (ELECTRICAL SYSTEM:IGNITION:SWITCH). PONTIAC STATED THAT THE VEHICLE HAD TO BE TOWED TO THE CLOSEST DEALER. THE DEALER INSPECTED THE VEHICLE, BUT WERE UNABLE TO CORRECT THE FAILURE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 157,000.
NHTSA ODI #10222508
180,000 miles · Aug 14, 2005
Fuel System, Gasoline
I SMELLED GAS AND LOSS OF FUEL. GAS LEAKING OUT FROM INJECTOR ONTO HOT ENGINE COULD CAUSE FIRE. HAD PART REPLACED- FUEL INJECTORS #2 AND 3. NOW ANOTHER IS LEAKING. HAVE TO TAKE IT IN, BUT MONEY IS AN OBJECT. *NM
NHTSA ODI #10132798
Mileage unknown · Dec 22, 2004
Engine And Engine Cooling
THE HEAD GASKET WAS LEAKING ANTIFREEZE WHICH CAUSED THE VEHICLE TO OVERHEAT. *JB.
NHTSA ODI #10105187
Mileage unknown · Nov 12, 2004
Seat Belts
CONSUMER NOTICED THAT THE REAR MIDDLE SEAT BELT UNLOCKED ON ITS OWN. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED. *AK
NHTSA ODI #10099909
100,000 miles · Oct 30, 2004
Electrical System
WE HAVE HAD THIS CAR FOR ABOUT 2 YEARS, AND HAVE HAD PROBLEMS SINCE THE BEGINNING. FIRST THING WAS THE COOLING FAN. IT QUIT WORKING ABOUT 6 MONTHS AFTER WE BOUGHT THE CAR. WE HAD THAT FIXED THEN STARTED HAVING OTHER ELECTRICAL PROBLEMS. THE BRAKE LIGHTS WOULD WORK HERE AND THERE, THE TURN SIGNALS WOULD WORK ONE DAY AND NOT …
Read full complaint
WE HAVE HAD THIS CAR FOR ABOUT 2 YEARS, AND HAVE HAD PROBLEMS SINCE THE BEGINNING. FIRST THING WAS THE COOLING FAN. IT QUIT WORKING ABOUT 6 MONTHS AFTER WE BOUGHT THE CAR. WE HAD THAT FIXED THEN STARTED HAVING OTHER ELECTRICAL PROBLEMS. THE BRAKE LIGHTS WOULD WORK HERE AND THERE, THE TURN SIGNALS WOULD WORK ONE DAY AND NOT THE NEXT, NOW THEY DON'T WORK AT ALL. THE ABS LIGHT WOULD FLASH OFF AND ON AND THE BRAKE LIGHT WOULD COME ON ALSO. WE KNOW THAT FILING THIS COMPLAINT WILL NOT FIX THE PROBLEMS WE ARE HAVING WITH THE CAR, WE JUST WANTED TO MAKE IT KNOWN THAT WE WILL NEVER BUY ANOTHER PONTIAC DUE TO THE PROBLEMS WE ARE HAVING WITH THIS ONE. THANK YOU FOR YOUR TIME. *JB
NHTSA ODI #10098031
96,000 miles · May 15, 2004
Service Brakes, Hydraulic
1995 SUNFIRE, I BOUGHT THIS CAR IN 1997. THE BRAKES LOCK-UP WHEN I AM DRIVING AND I HAVE TO STOP A A CORNER OR LIGHT. THIS USUALLY ONLY HAPPENS WHEN OR AFTER IT RAINS. IT IS VERY SCARY I ALMOST LOSE CONTROL OVER THE CAR.MY HEAD GASKETS HAVE BEEN REPLACED TWICE. THE ENGINE GAGE RISES ALMOST TO OVER HEATING WHEN IT IS HOTOUTSIDE, …
Read full complaint
1995 SUNFIRE, I BOUGHT THIS CAR IN 1997. THE BRAKES LOCK-UP WHEN I AM DRIVING AND I HAVE TO STOP A A CORNER OR LIGHT. THIS USUALLY ONLY HAPPENS WHEN OR AFTER IT RAINS. IT IS VERY SCARY I ALMOST LOSE CONTROL OVER THE CAR.MY HEAD GASKETS HAVE BEEN REPLACED TWICE. THE ENGINE GAGE RISES ALMOST TO OVER HEATING WHEN IT IS HOTOUTSIDE, AND THE AIR DOES NOT WORK I HAVE TO GET IT CHARGED EVERY YEAR. IS THIS CAR A LEMON OR WHAT?*AK
NHTSA ODI #10072648
Mileage unknown · Oct 27, 2003
Latches/locks/linkages
DRIVER AND PASSENGER DOORS LOCKED AND UNLOCKED FOR NO APPARENT REASON WHILE DRIVING. THE DOOR MECHANISM WAS THE PROBLEM. DEALER WAS NOTIFIED. *AK
NHTSA ODI #10044774
51,867 miles · Oct 14, 2003
Suspension
WHILE MAKING A LEFT TURN AT A STOP SIGN AND WITHOUT WARNING LEFT FRONT LOWER BALL JOINT SNAPPED IN TWO. WHEN THIS OCCURRED, LEFT WHEEL ALMOST CAME COMPLETELY OFF. *AK
NHTSA ODI #10042887
Mileage unknown · Jul 25, 2003
Electrical SystemEngine And Engine CoolingVisibilityFire
JUST FOUND OUT ABOUT RECALL ABOUT STARTER. HAD FIRE (SMOKE) IN STEERING WHEEL AND ENTIRE ELECTRICAL SYSTEM NOT WORKING RIGHT. WINDOWS STUCK HALF WAY, BLINKING LIGHTS IN DASH AND HAD MOTOR REPLACED, BUT VERY BAD, DUE TO SUDDEN LOSS OF OIL AND MOTOR FROZE. CAR IS IN DESTRUCTION MODE.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
THE INSTRUMENT PANEL CLUSTER TRIM PLATE/BEZEL CAN SAG AND COVER THE LIGHT EMITTING DIODE PORTION (LIGHTED POINTED ABOVE PANEL) OF THE TRANSAXLE SHIFT INDICATOR DISPLAY. THIS DOES NOT COMPLY WITH FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE DRIVER OF THE VEHICLE WOULD NOT BE ABLE TO SEE THE ACTUAL POSITION OF THE TRANSAXLE GEAR SELECTOR RESULTING IN A DRIVER EITHER INADVERTENTLY LEAVING A PARKED OR IDLING VEHICLE IN DRIVE, REVERSE, OR NEUTRAL RATHER THAN PARK, OR SELECTING AN INCORRECT TRANSAXLE SHIFT POSITION WHILE DRIVING THE VEHICLE.
Remedy: DEALERS ARE TO INSTALL A NEW INSTRUMENT PANEL CLUSTER TRIM PLATE/BEZEL ASSEMBLY WHICH IS NOT SUBJECT TO THIS CONDITION.
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
1995 Pontiac Sunfire Problems, Complaints & Recalls | Skip That Year
Illustration