IllustrationPROBLEMS OF HEATING/COOLING DEVELOPED, LEADING TO EXTENSIVE SERVICE TO CORRECT. GASKET FAILURE RECOGNIZED BY MECHANIC AFTER REPLACING HEATER CORE AND RADIATOR FAILED TO CORRECT PROBLEMS. (SISTER'S 1991 PONT SUNBIRD W/ SAME ENGINE FALED 6/99 WHILE ON HIGHWAY)
1992 Pontiac Sunbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sunbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 30 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Engine And Engine Cooling complaints
6 reportsWHILE DRIVING THE VEHICLE STALLED AND DIED BECAUSE THE TIMING CHAIN BELT SEPARATED FROM VEHICLE. DEALER HAS BEEN NOTIFIED. *AK
WHEN COMING TO A STOP THE VEHICLE ENGINE SHUTS DOWN, CAUSING THE VEHICLE TO STALL. *AK
INTERMITTENT STALLING.
WATER PUMP NOISY, REPLACED PRIOR TO RECALL. *TW
WATER PUMP FAILED PRIOR TO RECALL, CAUSING TIMING AND DRIVE BELT FAILURES/VEHICLE TO STALL. *SKD
Official recalls
393V190000 · Vehicle Speed Control
Nov 22, 1993
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING VERY COLD WEATHER, WATER THATN ENTERS THE ACCELERATOR CONTROL CABLE CONDUIT FREEZES AND CAUSES THE ACCELERATOR CABLE TO DEVELOP A HIGH EFFORT OR BINDING CONDITION.
Consequence & remedy
Consequence: IF THIS OCCURS, LOSS OF NORMAL THROTTLE CONTROL CAN RESULT, OR THE THROTTLE WILL NOT RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, CAUSING POSSIBLE LOSS OF CONTROL AND AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CONTROL ASSEMBLY.
92V048000 · Vehicle Speed Control
Apr 3, 1992
THE ACCELERATOR CABLE MAY HAVE BEEN KINKED DURING VEHICLE ASSEMBLY. THE KINK IN THE CABLE CAN CAUSE EITHER A HIGH EFFORT ACCELERATOR CABLE, STICKING ACCELERATOR CABLE, OR A BROKEN ACCELERATOR CABLE.
Consequence & remedy
Consequence: IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS IT CANRESULT IN LOSS OF THROTTLE CONTROL. IF LOSS OF THROTTLE CONTROL OCCURS WHILE THEVEHICLE IS IN MOTION, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.
91V166000 · Latches/locks/linkages:hood:latch
Sep 23, 1991
THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.
Consequence & remedy
Consequence: IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.
Remedy: INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.