SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2008 Pontiac Solstice

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2008 Pontiac Solstice do not stand out strongly from the model-year median of 97.5.

About this comparison →
159Owner complaints

Model-year median: 97.5

4Recall campaigns

View recall details →

3Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
243
2006289
2007159
200836
20090
2010
Compare all Solstice years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Air Bags
99Service Brakes, Hydraulic
29Electrical System
15Seats
10Service Brakes
7
All reported categories
Structure
6Engine
5Power Train
3Engine And Engine Cooling
2Equipment
2Latches/locks/linkages
2Unknown Or Other
2Vehicle Speed Control
2Exterior Lighting
1Seat Belts
1Service Brakes, Electric
1Suspension
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

110 reports with mileage · 49 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports0 fire reports6 injury reports

Air Bags complaints

99 reports
Clear category filter
Mileage unknown · Nov 26, 2014
Air BagsSeats

PASSENGER SEAT AIR BAG SENSOR FAILED ON VEHICLE OUT OF NOWHERE. I DO NOT CARRY PASSENGERS IN MY CAR YET THE SENSOR FAILED ON ME. I AM NOT THE FIRST TO HAVE THIS PROBLEM AND IT ACTUALLY SEEMS TO BE A VERY COMMON PROBLEM IN PONTIAC SOLSTICE'S AND IT'S SIMPLY DISHEARTENING TO SEE IT. HTTP://WWW.SOLSTICEFORUM.COM/FORUM/F12/PANSSENGE…

Read full complaint

PASSENGER SEAT AIR BAG SENSOR FAILED ON VEHICLE OUT OF NOWHERE. I DO NOT CARRY PASSENGERS IN MY CAR YET THE SENSOR FAILED ON ME. I AM NOT THE FIRST TO HAVE THIS PROBLEM AND IT ACTUALLY SEEMS TO BE A VERY COMMON PROBLEM IN PONTIAC SOLSTICE'S AND IT'S SIMPLY DISHEARTENING TO SEE IT. HTTP://WWW.SOLSTICEFORUM.COM/FORUM/F12/PANSSENGER-AIRBAG-SENSOR-75353/ LOOK HOW FAR SOME OF US HAVE GONE TO ATTEMPT TO FIX THIS PROBLEM. FROM WHAT WE'VE DISCOVERED THIS IS A PROBLEM THAT CANNOT BE REPAIRED AND INSTEAD FORCES US TO REPLACE THE ENTIRE SEAT CUSHION OUT OF POCKET. TO MAKE MATTERS WORST THE POINT OF FAILURE SEEMS TO LIE WITH GM. A DEFECTIVE SENSOR DESIGN HAS CAUSED A VERY LARGE AMOUNT OF SOLSTICE OWNERS TO HAVE ISSUES. I DON'T THINK IT'S ACCEPTABLE TO MAKE US PAY UPWARDS OF $800 FOR REPAIRS ON SOMETHING THAT IS A COMMON FAILURE ON SO MANY OF THESE BEAUTIFUL CARS. *TR

NHTSA ODI #10661020

Mileage unknown · Nov 23, 2014
Air Bags

PASSENGER AIRBAG SENSORS FAILED AT 50,000 MILES, OUTSIDE OF WARRANTY TIME LIMIT. AS A SAFETY ISSUE, THIS IS SOMETHING THAT GM NEEDS TO ACKNOWLEDGE IN GOOD FAITH. *TR

NHTSA ODI #10660306

34,000 miles · Nov 20, 2014
Air Bags

AIR BAG LIGHT CAME ON. DEALER RECOMMENDED REPLACING PASSENGER PRESENT SENSOR WHICH DETECTS THE WEIGHT OF A PASSENGER TO TURN THE AIRBAG ON OR OFF. THE COST WAS $885. I CAN'T AFFORD TO FIX IT, SO I AM RIDING AROUND WITH NONOPERATIONAL AIRBAGS WITH A CAR WITH ONLY 34K. BASED ON PONTIAC SOLSTICE FORUMS, THIS IS A COMMON P…

Read full complaint

AIR BAG LIGHT CAME ON. DEALER RECOMMENDED REPLACING PASSENGER PRESENT SENSOR WHICH DETECTS THE WEIGHT OF A PASSENGER TO TURN THE AIRBAG ON OR OFF. THE COST WAS $885. I CAN'T AFFORD TO FIX IT, SO I AM RIDING AROUND WITH NONOPERATIONAL AIRBAGS WITH A CAR WITH ONLY 34K. BASED ON PONTIAC SOLSTICE FORUMS, THIS IS A COMMON PROBLEM WITH PONTIAC SOLSTICE, BUT NO RECALL TO FIX THIS OBVIOUS SAFETY FLAW. I WOULD BE GLAD TO SEND YOU A COPY OF THE DEALER INVOICE WITH THE ERROR CODES FROM 11/14/14. *TR

NHTSA ODI #10659881

40,441 miles · Nov 11, 2014
Air Bags

GOT IN ONE DAY AND THE AIR BAG SENSOR LIGHT CAME ON. NOW IT COMES ON AND DINGS AT ME EVERY DAY AND UNTIL I GET THIS FIXED, DO NOT FEEL COMFORTABLE DRIVING MY SON TO SCHOOL.. *TR

NHTSA ODI #10654215

42,000 miles · Nov 4, 2014
Air BagsElectrical SystemSeats

GIRLFRIEND SAT IN PASSENGER SEAT AND A "SERVICE AIRBAG" LIGHT CAM ON MY INFO SCREEN. TURNED OFF AFTER A FEW SECONDS THEN TURNED BACK ON AND HAS BEEN ON SINCE. *TR

NHTSA ODI #10652502

25,000 miles · Oct 1, 2014
Air BagsSeats

THE "SERVICE AIR BAG" INDICATOR IN THE DRIVER INFORMATION CENTER CAME ON DURING THE NORMAL COURSE OF DRIVING AND HAS REMAINED ON CONSTANTLY SINCE THAT TIME, APPROXIMATELY 1 - 1.5 YRS. THIS WAS NOT RELATED TO ANY ACCIDENT. DIAGNOSIS USING ON OBD SCAN TOOL WAS COMPLETED BY A REPUTABLE LOCAL MECHANIC, WHO INDICATED THAT THE PASSE…

Read full complaint

THE "SERVICE AIR BAG" INDICATOR IN THE DRIVER INFORMATION CENTER CAME ON DURING THE NORMAL COURSE OF DRIVING AND HAS REMAINED ON CONSTANTLY SINCE THAT TIME, APPROXIMATELY 1 - 1.5 YRS. THIS WAS NOT RELATED TO ANY ACCIDENT. DIAGNOSIS USING ON OBD SCAN TOOL WAS COMPLETED BY A REPUTABLE LOCAL MECHANIC, WHO INDICATED THAT THE PASSENGER SIDE SEAT SENSOR IS DEFECTIVE AND NEEDS TO BE REPLACED. THIS APPEARS TO BE A MAJOR SAFETY CONCERN SINCE, AT A MINIMUM, THE PASSENGER SIDE AIR BAG HAS BEEN COMPROMISED AND MAY NOT DEPLOY IN THE EVENT OF A CRASH DUE TO THIS FAULTY SEAT SENSOR. FURTHER RESEARCH COMPLETED BY MYSELF INDICATES THIS FAULTY PASSENGER SEAT SENSOR MAY BE A COMMON PROBLEM IN THE PONTIAC SOLSTICE AND SATURN SKY. THIS IS A RELATIVELY EXPENSIVE REPAIR ($800+) BY AN AUTHORIZED DEALER, AND THE ASSOCIATED REPAIR COSTS SHOULD NOT BE THE RESPONSIBILITY OF THE CONSUMER TO CORRECT THIS SAFETY ISSUE. *TR

NHTSA ODI #10640576

27,200 miles · Sep 16, 2014
Air Bags

SERVICE AIR BAG IN DIC TURNED ON AND AIRBAG LIGHT INDICATOR FOR PASSENGER SEAT TURNED OFF WHILE THE AUTO WAS ZERO (0) SPEED, DRIVER'S SEAT AND PASSENGER'S SEAT WERE BOTH OCCUPIED . THIS IS A DESPICABLE DESIGN ERROR AS WELL AS A REAL WORLD OPERATIONAL FLAW, A POTENTIALLY FATAL SAFETY ISSUE THAT THOUSANDS OF SOLSTICE OWNERS…

Read full complaint

SERVICE AIR BAG IN DIC TURNED ON AND AIRBAG LIGHT INDICATOR FOR PASSENGER SEAT TURNED OFF WHILE THE AUTO WAS ZERO (0) SPEED, DRIVER'S SEAT AND PASSENGER'S SEAT WERE BOTH OCCUPIED . THIS IS A DESPICABLE DESIGN ERROR AS WELL AS A REAL WORLD OPERATIONAL FLAW, A POTENTIALLY FATAL SAFETY ISSUE THAT THOUSANDS OF SOLSTICE OWNERS ARE EXPERIENCING AND THAT THOUSANDS MORE WILL EXPERIENCE. HOW MANY FATALITIES MUST THE AMERICAN PUBLIC ENDURE BEFORE GM ACCEPTS FULL RESPONSIBILITY AND FINALLY, HOWEVER RELUCTANTLY, COWARDLY, IMMORALLY, AND DECEITFULLY , CORRECT THIS QUINTESSENTIALLY DEATH TRAP VEHICLE? *TR

NHTSA ODI #10633777

15,810 miles · Sep 15, 2014
Air BagsElectrical SystemSeats

AIRBAG SERVICE REQUIRED DTC. PROBLEM IS WITH THE PPS SYSTEM IN THE PASSENGER SEAT. PROBLEM HAS BEEN WIDELY REPORTED FOR THESE CARS, AS WELL AS, OTHER GM PRODUCTS. THIS CONDITION EFFECTIVELY RENDERS THE AIRBAG PROTECTION OF THE PASSENGER SEAR INOPERATIVE EVEN IF THE SEAT IS OCCUPIED. GM IS AWARE THE PROBLEM AND THEIR DEALERS W…

Read full complaint

AIRBAG SERVICE REQUIRED DTC. PROBLEM IS WITH THE PPS SYSTEM IN THE PASSENGER SEAT. PROBLEM HAS BEEN WIDELY REPORTED FOR THESE CARS, AS WELL AS, OTHER GM PRODUCTS. THIS CONDITION EFFECTIVELY RENDERS THE AIRBAG PROTECTION OF THE PASSENGER SEAR INOPERATIVE EVEN IF THE SEAT IS OCCUPIED. GM IS AWARE THE PROBLEM AND THEIR DEALERS WANT APPROXIMATELY BETWEEN $800 AND $1,000 TO REPLACE THE FAILED SEAT COMPONENTS. THEY FAIL BECAUSE THE DESIGN IS FAULTY IN THAT THE SENSOR PAD SENSOR CONDUCTIVE PATHWAYS SUFFER BREAKAGE. THE FORUM BLOG FOR OWNERS WITH THIS PROBLEM IS AN EXCELLENT SOURCE, INCLUDING PICTURES OF THE COMPONENT FAILURE AND POOR DESIGN, THAT CAN BE FOUND AT HTTP://WWW.SOLSTICEFORUM.COM/FORUM/F12/PASSENGER-AIRBAG-SENSOR-75353/ . *TR

NHTSA ODI #10633276

78,500 miles · Sep 12, 2014
Air Bags

TL* THE CONTACT OWNS A 2008 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER AND WAS INFORMED THAT THE PASSENGER SIDE APP SENSOR MODULE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 78,500.

NHTSA ODI #10632840

42,000 miles · Jun 30, 2014
Air BagsSeats

IN JANUARY 2014..MY PASSENGER AIRBAG LIGHT CAME ON THE DIC SAYING TO SERVICE AIRBAG??? I HAVE VERY FEW PASSENGERS FROM TIME TO TIME..MAYBE THREE A MONTH..NONE ARE HEAVY ENOUGH AS TO PLOP DOWN ON SEAT WITH ENOUGH WEIGHT TO INFLICT DAMAGE ON WHATEVER THE PROBLEM MAY BE!!! ALSO, WHEN I CLEAN THE CAR, I MAKE CERTAIN AS TO NOT KNEEL …

Read full complaint

IN JANUARY 2014..MY PASSENGER AIRBAG LIGHT CAME ON THE DIC SAYING TO SERVICE AIRBAG??? I HAVE VERY FEW PASSENGERS FROM TIME TO TIME..MAYBE THREE A MONTH..NONE ARE HEAVY ENOUGH AS TO PLOP DOWN ON SEAT WITH ENOUGH WEIGHT TO INFLICT DAMAGE ON WHATEVER THE PROBLEM MAY BE!!! ALSO, WHEN I CLEAN THE CAR, I MAKE CERTAIN AS TO NOT KNEEL OR PUT ANY SORT OF WEIGHT AS TO BREAK THE CIRCUIT IN WHICH I'VE BEEN READING ABOUT ALL THE MANY OTHERS!!! HAS ANYBODY GIVEN ANY THOUGHT THAT MAYBE IT'S A DEFAULT?? IT HAPPENS SO VERY OFTEN WITH MANY OF THE OTHER AUTOMOBILES...SO WHAT MAKES OUR CAR ANY DIFFERENT??? IT HAPPENS!!! AS MY WORD, I DID NOTHING IN ANY WAY, SHAPE OR FORM TO DAMAGE IT!!!! I LOVE MY SOLSTICE, BUT IF NOTHING IS DONE ABOUT THIS, I , MY FAMILY, FRIENDS AND WHOEVER ELSE I MAY INFORM WILL NEVER DO BUSINESS WITH GM AGAIN..SORRY, BUT THIS JUST ISN'T RIGHT...SAFETY!!!LOL *TR

NHTSA ODI #10607143

Official recalls

4

17V061000 · Air Bags:sensor:occupant Classification

Jan 26, 2017

General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.

Consequence & remedy

Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.

Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

07V454000 · Seat Belts:front:anchorage

Sep 26, 2007

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." AND STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THESE VEHICLES MAY HAVE ONE TO FOUR INBOARD SEAT STUD FASTENERS THAT DO NOT MEET SPECIFICATION FOR STRENGTH.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT AND SEAT BELT ASSEMBLY MAY NOT RESTRAIN THE OCCUPANT AS INTENDED AND COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy: DEALERS WILL INSPECT THE INBOARD SEAT STUDS AND, IF NECESSARY, REMOVE THE STUD AND INSTALL A BOLT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2007. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP20002 · Hvac Blower Motor Connector

Opened Feb 7, 2020 · Closed Oct 27, 2022

Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash

The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f

DP16001 · Passenger Sensing System Sensor Mat

Opened May 16, 2016 · Closed Apr 24, 2017

Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification

The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.

PE08016 · Inadequate Brake Power Assist

Opened Mar 6, 2008 · Closed Jun 24, 2008

Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Service Brakes, Hydraulic:power Assist:vacuum

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Additional source detail variants (6)

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Service Brakes, Hydraulic

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Service Brakes, Hydraulic:power Assist

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Service Brakes, Hydraulic:power Assist:hydraulic

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Service Brakes, Hydraulic:power Assist:vacuum

IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.