NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
243 reports23,632 miles · May 10, 2014
Air Bags
INITIALLY MY SERVICE PASSENGER AIR BAG LIGHT WOULD MALFUNCTION THEN WORK. FINALLY IT HAS STOPPED WORKING ALL TOGETHER ABOUT THE DATE NOTED. I CURRENTLY HAVE NO EVIDENCE IF THE PASSENGER AIRBAG WILL WORK OR NOT AS THE SENSOR IS NOT WORKING TO SHOW OCCUPANCY IN THE SEAT. I HAVE READ HUNDREDS OF COMPLAINTS ABOUT THIS. MAYBE WHEN EN…
Read full complaint
INITIALLY MY SERVICE PASSENGER AIR BAG LIGHT WOULD MALFUNCTION THEN WORK. FINALLY IT HAS STOPPED WORKING ALL TOGETHER ABOUT THE DATE NOTED. I CURRENTLY HAVE NO EVIDENCE IF THE PASSENGER AIRBAG WILL WORK OR NOT AS THE SENSOR IS NOT WORKING TO SHOW OCCUPANCY IN THE SEAT. I HAVE READ HUNDREDS OF COMPLAINTS ABOUT THIS. MAYBE WHEN ENOUGH PEOPLE DIE OR ARE INJURED GM WILL ADMIT IT IS A FAULTY SEAT WIRE AND RECALL IT. ACCORDING TO MY RESEARCH, SPENDING $850 TO REPLACE IT WILL NOT PREVENT IT FROM FAILING AGAIN. THEREFORE THE CUSTOMER WILL NOT CONTINUE TO REPLACE IT. *TR
NHTSA ODI #10587620
40,000 miles · May 9, 2014
Air Bags
PASSENGER PRESENCE AIRBAG SENSOR FAILED IN THE PASSENGER SEAT. IT IS A THIN SENSOR MAT AND THE BREAK IN THE COPPER IS VERY CLEAR TO SEE. *TR
NHTSA ODI #10587515
82,000 miles · May 5, 2014
Air Bags
AN ERROR MESSAGE IN THE DRIVER INFORMATION CENTER INDICATES THAT THE PASSENGER SIDE AIRBAG REQUIRES SERVICE. THE DASH LIGHT INDICATES THAT THE PASSENGER SIDE AIRBAG IS OFF EVEN WHEN SOMEONE WEIGHING MORE THAN 150 LBS. IS SITTING IN THE SEAT. *TR
NHTSA ODI #10586644
60,000 miles · May 5, 2014
Air Bags
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE SERVICE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE PASSENGER MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT AND …
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE SERVICE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE PASSENGER MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10586632
18,200 miles · Apr 28, 2014
Air BagsElectrical SystemSeats
DRIVING DOWN THE STREET WITH A PASSENGER AND SERVICE AIR BAG LIGHT CAME ON THE DIC. TOOK SOLSTICE IN TO BUICK, PONTIAC, GMC DEALER, FOR IGNITION RECALL AND PASSENGER AIRBAG LIGHT DIAGNOSED AS A BAD PASSENGER PRESSENCE SENSOR. ESTIMATED REPLACEMENT CHARGE OF $850. CHARGED $120 FOR DIAGNOSIS. SEARCHING ONLINE FORUMS SHOWS TH…
Read full complaint
DRIVING DOWN THE STREET WITH A PASSENGER AND SERVICE AIR BAG LIGHT CAME ON THE DIC. TOOK SOLSTICE IN TO BUICK, PONTIAC, GMC DEALER, FOR IGNITION RECALL AND PASSENGER AIRBAG LIGHT DIAGNOSED AS A BAD PASSENGER PRESSENCE SENSOR. ESTIMATED REPLACEMENT CHARGE OF $850. CHARGED $120 FOR DIAGNOSIS. SEARCHING ONLINE FORUMS SHOWS THIS IS A COMMON OCCURENCE DUE TO A FAULTY DESIGNED SEAT SENSOR. OWNERS ARE PAYING FOR THE REPLACEMENT ONLY FOR THE PART TO BREAK AGAIN. MAKING THIS A $970 REPAIR (DIAGNOSIS + PARTS + LABOR). PLEASE EXPEDITE A RECALL, BECAUSE THIS MAKES THIS TWO SEAT CONVERTIBLE, A ONE PERSON CAR! *TR UPDATED 10/9/2014 *JS
NHTSA ODI #10585390
28,000 miles · Apr 24, 2014
Air Bags
DEALER DIAGNOSED WARNING LIGHT TO FAULTY AIR BAG SENSOR, PART #19124219 AND QUOTED OVER $800 TO FIX. QUICK GOOGLE SEARCH INDICATES THIS IS A COMMON AND KNOWN ISSUE, BUT AS OF YET NO RECALL ISSUED. GIVEN THE VAST NUMBER OF COMPLAINTS, AND THE FACT THIS IS DIRECTLY TIED TO SAFETY ISSUE, ITS APPALLING THAT NOTHING HAS BEEN DONE T…
Read full complaint
DEALER DIAGNOSED WARNING LIGHT TO FAULTY AIR BAG SENSOR, PART #19124219 AND QUOTED OVER $800 TO FIX. QUICK GOOGLE SEARCH INDICATES THIS IS A COMMON AND KNOWN ISSUE, BUT AS OF YET NO RECALL ISSUED. GIVEN THE VAST NUMBER OF COMPLAINTS, AND THE FACT THIS IS DIRECTLY TIED TO SAFETY ISSUE, ITS APPALLING THAT NOTHING HAS BEEN DONE TO RECTIFY THE KNOWN ISSUE. I'M GOING TO BUY AND INSTALL THE PART MYSELF, WHICH WILL STILL COST $400 BUT WILL ENSURE THAT THE VEHICLE MEETS THE SAFETY STANDARDS IT WAS DESIGNED AND TESTED FOR. HOW MANY COMPLAINTS DOES IT TAKE BEFORE ANY ACTION IS TAKEN? *TR
NHTSA ODI #10584769
70,000 miles · Apr 7, 2014
Air Bags
I AM PART OF THE GM IGNITION RECALL... AND HAVE DONE EXTENSIVE RESEARCH NOW ON HOW IT MAY BE TIED TO THE AIRBAG ISSUE I SEEM TO BE HAVING. THE WARNING THAT MY AIRBAGS DO NOT WORK AND NEED TO BE SERVICED KEEPS COMING UP. (SO I AM DRIVING WITH NO AIRBAGS ACCORDING TO MY DEALERSHIP, THEY SAID IT SEEMS TO BE A COMMON COMPLAINT, BUT …
Read full complaint
I AM PART OF THE GM IGNITION RECALL... AND HAVE DONE EXTENSIVE RESEARCH NOW ON HOW IT MAY BE TIED TO THE AIRBAG ISSUE I SEEM TO BE HAVING. THE WARNING THAT MY AIRBAGS DO NOT WORK AND NEED TO BE SERVICED KEEPS COMING UP. (SO I AM DRIVING WITH NO AIRBAGS ACCORDING TO MY DEALERSHIP, THEY SAID IT SEEMS TO BE A COMMON COMPLAINT, BUT OF COURSE THERE IS NO RECALL!!). *TR
NHTSA ODI #10578026
37,200 miles · Apr 4, 2014
Electrical SystemPower Train
PURCHASED THIS CAR USED 2/4/14 FROM A LOCAL REPUTABLY DEALER.THIS 06 SOLSTICE SHOWED ONLY 36998 MILES AND HAD A CLEAN CAR FAX REPORT. HAVE DRIVEN THE CAR ONLY A COUPLE OF HUNDRED MILES DUE TO THE FOLLOWING . THE FEW TIMES THAT THE VEHICLE HAS BEEN DRIVEN THERE SEEMS TO BE A GRINDING NOISE IN THE REAR END ONLY AT LOW SPEED AND ON…
Read full complaint
PURCHASED THIS CAR USED 2/4/14 FROM A LOCAL REPUTABLY DEALER.THIS 06 SOLSTICE SHOWED ONLY 36998 MILES AND HAD A CLEAN CAR FAX REPORT. HAVE DRIVEN THE CAR ONLY A COUPLE OF HUNDRED MILES DUE TO THE FOLLOWING . THE FEW TIMES THAT THE VEHICLE HAS BEEN DRIVEN THERE SEEMS TO BE A GRINDING NOISE IN THE REAR END ONLY AT LOW SPEED AND ONLY WHILE TURNING ,MOSTLY PARKING LOT SPEED .THE CAR WILL GRIND AND "VIOLENT SNATCH" AS IF SOMETHING IS BINDING OR CATCHING. THE LOCAL MECHANIC SAYS THIS IS A DEFECT IN CLUTCHES OF THE REAR END ON THESE MODELS (06) AND THAT GM SHOULD HAVE REPAIRED IT A LONG TIME AGO .WELL, APPARENTLY MINE WAS NOT .ADDED THE REQUIRED GM ADDITIVE TO THE REAR ,BUT CAR CONTINUES TO GRIND.I HAVE READ MANY HORROR STORIES ON LINE FROM OTHER OWNERS WHO HAVE HAD THERE REAR WHEELS" LOCKING UP "AT SPEED AND CAUSING LOSS OF CONTROL IN THESE CARS (.I AM NOT ABOUT TO LET MY WIFE EVER DRIVE THIS CAR AGAIN.) PROBLEM #(2) I THOUGHT WAS INSIGNIFICANT UNTIL I SAW THIS CAR WAS RECALLED LAST WEEK ,AND NOW MY EXPERIENCE MAKES SENSE. NOT ONLY WILL THESE SWITCHES SHUT OFF DURING OPERATING THEY WILL ALSO UNINTENTIONALLY START DUE TO WEAK DETENTE IN SWITCH. ( NO HARM NO FOUL )...SO FAR....PROBLEM#3 MY PASS SIDE AIRBAG LIGHT ON THIS CAR WORKS ABOUT HALF THE TIME. MEANING THE PASS SIDE BAG IS ACTIVE AND OPERATING ABOUT HALF THE TIME.(MY DAUGHTER HAS HAD HER LAST RIDE AS WELL) THE REAL PROBLEM HERE IS THAT I STILL OWE 14000 ON A CAR THAT LOOKS GREAT BUT CAN'T BE SAFELY DRIVEN . THIS PURCHASE IS MY FIRST SINCE BANKRUPTCY 2 YRS AGO ,AND IT LOOKS AS IF I WILL BE GIVING IT BACK TO THE FINANCE COMPANY AND WILL BE OUT MY 2000 DOLLARS DOWN PAYMENT. AFTER PURCHASING THIS CAR I HAVE RESEARCHED AND FOUND THESE PROBLEMS I AM HAVING ,HAVE BEEN AN ONGOING FOR GM.WHY ARE THEY STILL OUT THERE BEING SOLD TO THE CONSUMER? AND TO THINK I CHEERED WHEN GM WAS BAILED OUT!! BLAME GOES TO ME FOR TRUSTING GM? *TR
NHTSA ODI #10577465
22,500 miles · Apr 4, 2014
Air Bags
ON THE SOLSTICE WEBSITE THERE ARE MANY MANY COMPLAINTS OF THIS SAME PROBLEM. THE PASSENGER PRESENT SENSOR FAILS. THE HAVE AIRBAG SERVICED WARNING LIGHT IS ON. PASSENGER AIRBAG LIGHT IS OFF WHEN A PASSENGER IS PRESENT. THIS MEANS MY PASSENGER IS NOT PROTECTED BY THE AIRBAG IN THE EVENT OF A CRASH. THIS IS A MAJOR SAFETY ISSUE. *…
Read full complaint
ON THE SOLSTICE WEBSITE THERE ARE MANY MANY COMPLAINTS OF THIS SAME PROBLEM. THE PASSENGER PRESENT SENSOR FAILS. THE HAVE AIRBAG SERVICED WARNING LIGHT IS ON. PASSENGER AIRBAG LIGHT IS OFF WHEN A PASSENGER IS PRESENT. THIS MEANS MY PASSENGER IS NOT PROTECTED BY THE AIRBAG IN THE EVENT OF A CRASH. THIS IS A MAJOR SAFETY ISSUE. *TR
NHTSA ODI #10577429
11,000 miles · Apr 3, 2014
Electrical SystemSteering
I RECEIVED A LETTER ON THE IGNITION SWITCH RECALL AND HOW IMPORTANT (BOLDED AND UNDERSCORED) THAT IT WAS TO CONTACT THE DEALER AND GET THE REPORT COMPLETED. HOWEVER THE DEALER WON'T TAKE AN APPOINT BECAUSE THE PARTS ARE NOT IN. THE THINKS NEXT WEEK, BUT NOW HE SAID I'D NEED ANOTHER LETTER FROM GM BEFORE I CAN SCHEDULE AN A…
Read full complaint
I RECEIVED A LETTER ON THE IGNITION SWITCH RECALL AND HOW IMPORTANT (BOLDED AND UNDERSCORED) THAT IT WAS TO CONTACT THE DEALER AND GET THE REPORT COMPLETED. HOWEVER THE DEALER WON'T TAKE AN APPOINT BECAUSE THE PARTS ARE NOT IN. THE THINKS NEXT WEEK, BUT NOW HE SAID I'D NEED ANOTHER LETTER FROM GM BEFORE I CAN SCHEDULE AN APPOINTMENT. ALSO THE GM GUY WON'T SCHEDULE AN APPOINTMENT EVEN IF HE HAS THE PARTS IN. IF I WANT TO SCHEDULE AN APPOINT FOR A DATE NEXT WEEK I WOULD HAVE TO PURCHASE SERVICE -- LIKE AN OIL CHANGE TO SECURE THAT DAY/TIME. I CALLED GM CUSTOMER SERVICE SPECIFIC TO THE RECALL AND THEY SAID THAT PARTS SHOULD BE AT THE DEAL IN ABOUT A WEEK AND LIKELY RECEIVE A SECOND LETTER. SO NOW THAT I'VE WASTED AN HOUR OF TIME GOING THRU ALL THE STEPS THE FIRST LETTER ASKS, I'M GOING TO BE DRIVING A "DANGEROUS VEHICLE", UNTIL I GET A LETTER -- REGARDLESS OF THE PARTS ARE IN. BUT -- IF I PAY FOR ADDITIONAL SERVICE I WILL BE GRANTED AN APPOINTMENT. *TR
NHTSA ODI #10577092
Official recalls
4Jan 26, 2017
General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.
Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP20002 · Hvac Blower Motor Connector
Opened Feb 7, 2020 · Closed Oct 27, 2022
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f
DP16001 · Passenger Sensing System Sensor Mat
Opened May 16, 2016 · Closed Apr 24, 2017
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration