NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
81 reports27,000 miles · Nov 28, 2006
Visibility
DT*: THE CONTACT STATED WHILE OPERATING THE VEHICLE DURING ALL WEATHER CONDITIONS, THE POWER WINDOW SWITCH WAS INOPERATIVE ON THE DRIVER SIDE, PASSENGER SIDE, AND IN THE REAR VENT. THERE WAS NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER NUMEROUS TIMES, WHO COULD NOT BE DUPLICATE THE PROBL…
Read full complaint
DT*: THE CONTACT STATED WHILE OPERATING THE VEHICLE DURING ALL WEATHER CONDITIONS, THE POWER WINDOW SWITCH WAS INOPERATIVE ON THE DRIVER SIDE, PASSENGER SIDE, AND IN THE REAR VENT. THERE WAS NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER NUMEROUS TIMES, WHO COULD NOT BE DUPLICATE THE PROBLEM. THE MANUFACTURER WAS INFORMED AND A CLAIM # WAS PROVIDED.
NHTSA ODI #10174568
27,000 miles · Nov 11, 2006
Latches/locks/linkages
THE DOOR OPENS BY ITSELF EVEN WHEN IT SHOULD BE LOCKED. *NM
NHTSA ODI #10173200
40,000 miles · Oct 2, 2006
Electrical SystemLatches/locks/linkages
THIS IS A SAFETY ISSUE INVOLVING ABS SYSTEM FOR MY 2005 PONTIAC SV6 MONTANA. ON OR ABOUT AUGUST 11, 2006 MY ABS LIGHT CAME ON WHILE UNDER NORMAL OPERATION OF THE VAN. THIS HAS BEEN AN INTERMITTENT PROBLEM OVER THE PAST 6 WEEKS. I TOOK IT TO A LOCAL INDEPENDENT SHOP TO HAVE IT DIAGNOSED AND THE LOCAL SHOP INFORMED ME THAT THE COD…
Read full complaint
THIS IS A SAFETY ISSUE INVOLVING ABS SYSTEM FOR MY 2005 PONTIAC SV6 MONTANA. ON OR ABOUT AUGUST 11, 2006 MY ABS LIGHT CAME ON WHILE UNDER NORMAL OPERATION OF THE VAN. THIS HAS BEEN AN INTERMITTENT PROBLEM OVER THE PAST 6 WEEKS. I TOOK IT TO A LOCAL INDEPENDENT SHOP TO HAVE IT DIAGNOSED AND THE LOCAL SHOP INFORMED ME THAT THE CODES WERE TO NEW THAT I WOULD HAVE TO TAKE IT TO A DEALERSHIP. AFTER TAKING IT TO THE DEALERSHIP THEY DIAGNOSED IT AS HAVING AN ELECTRICAL PROBLEM. THERE WERE NO FAULTY MODULES BUT THAT THIS WAS A WIRING PROBLEM. I AM THE ONLY OWNER OF AN 05 PONTIAC MONTANA THAT I KNOW. RECENTLY I HAVE HAD VARIOUS OTHER PROBLEMS WITH THE POWER SLIDING DOOR INTERMITTENTLY OPENING WHENEVER YOU ENGAGE THE TRANSMISSION INTO REVERSE (RIGHT SIDE ONLY). MY 6 YEAR OLD SITS IN THE RIGHT REAR SEAT. HOPE THIS DOESN'T HAPPEN WHILE DRIVING DOWN THE HIGHWAY. DOES THIS VEHICLE HAVE FAULTY WIRING OR DO I JUST HAVE BAD LUCK. *JB
NHTSA ODI #10169802
28,000 miles · Sep 11, 2006
Electrical SystemEngine And Engine CoolingTires
DT*: THE CONTACT STATED THE VEHICLE'S HEADLIGHTS HAD AN ELECTRICAL ISSUE THAT CAUSED THE LIGHTS TO FLICKER AND NOT REMAIN ILLUMINATED. PREVIOUSLY, THE BRAKE LIGHTS AND DASH LIGHTS HAD ALSO EXPERIENCED THIS ISSUE. THE VEHICLE HAD BEEN TO THE SERVICE DEALER TWELVE TIMES, BUT WERE UNABLE TO CORRECT THE ISSUE. UPDATED 10/14/2006 …
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE'S HEADLIGHTS HAD AN ELECTRICAL ISSUE THAT CAUSED THE LIGHTS TO FLICKER AND NOT REMAIN ILLUMINATED. PREVIOUSLY, THE BRAKE LIGHTS AND DASH LIGHTS HAD ALSO EXPERIENCED THIS ISSUE. THE VEHICLE HAD BEEN TO THE SERVICE DEALER TWELVE TIMES, BUT WERE UNABLE TO CORRECT THE ISSUE. UPDATED 10/14/2006 - THE DEALER HAD REPLACED THE ALTERNATOR TO TRY TO ALLEVIATE ELECTRICAL PROBLEMS. THE REAR POWER WINDOWS SOMETIME WOULD NOT OPEN OR SHUT, THE REAR WASHER AND WIPER FAILED INTERMITTENTLY. THE DEALER REPLACED THE WIRES, MOTORS REGULATORS, ETC. BU THE PROBLEMS RECURRED. THE CONSUEMR WAS GIVEN A 100,000 MILE WARRANTY ON THE ELECTRICAL SYSTEM. THE TIRES STARTED CUPPING AND CAUSED SERIOUS ROAD NOISE. THE VEHICLE BEGAN TO LEAK OIL. THE DEALR REPLACED THE MAIN SEAL. *NM
NHTSA ODI #10167895
25,000 miles · Aug 30, 2006
Unknown Or Other
TRIM STRIPS ON BOTH SIDES OF VAN WERE RUSTING EVEN THOUGH THEY WERE PLASTIC. WAS TOLD THAT THIS WAS A KNOWN PROBLEM, THERE SHOULD BE SERVICE BULLETIN ON IT, AND THAT THE PAINT SURFACE WAS NOT CLEANED PROPERLY BEFORE PAINTING IT, THEREFORE IRON/RUST WAS BLEEDING THROUGH. THIS HAPPENED ONLY ON THE TRIM STRIPS ON THE FRONT DOORS, N…
Read full complaint
TRIM STRIPS ON BOTH SIDES OF VAN WERE RUSTING EVEN THOUGH THEY WERE PLASTIC. WAS TOLD THAT THIS WAS A KNOWN PROBLEM, THERE SHOULD BE SERVICE BULLETIN ON IT, AND THAT THE PAINT SURFACE WAS NOT CLEANED PROPERLY BEFORE PAINTING IT, THEREFORE IRON/RUST WAS BLEEDING THROUGH. THIS HAPPENED ONLY ON THE TRIM STRIPS ON THE FRONT DOORS, NO WHERE ELSE ON VAN. STRIPS WERE REPLACED SINCE STILL UNDER WARRANTY AND NO PROBLEMS YET AFTER 2 MONTHS. *JB
NHTSA ODI #10167058
22,000 miles · Aug 28, 2006
Service Brakes, HydraulicCrash
THE ATTACHED DATE IS THE LATEST OF THE FAILURES. I ALREADY HAD A COMPLAINT SUBMITTED REGARDING A CRASH DUE TO ABS FAILURE ON DECEMBER 31, 2005. SINCE THE DAMAGE WAS FIXED FROM THE ACCIDENT AND THE ABS WAS SUPPOSEDLY FIXED, WE HAVE HAD MANY MORE ABS FAILURES. IT HAS BEEN TO THE DEALER 3 TIMES (THIS TIME BEING THE 3RD) AFTER TH…
Read full complaint
THE ATTACHED DATE IS THE LATEST OF THE FAILURES. I ALREADY HAD A COMPLAINT SUBMITTED REGARDING A CRASH DUE TO ABS FAILURE ON DECEMBER 31, 2005. SINCE THE DAMAGE WAS FIXED FROM THE ACCIDENT AND THE ABS WAS SUPPOSEDLY FIXED, WE HAVE HAD MANY MORE ABS FAILURES. IT HAS BEEN TO THE DEALER 3 TIMES (THIS TIME BEING THE 3RD) AFTER THE INITIAL PROBLEM AND EACH TIME THEY SUPPOSEDLY FIX IT (BETWEEN THE WIRING HARNESS, THE EBCM, AND THE WHEEL SPEED SENSOR I DON'T KNOW WHAT IS CAUSING IT NOW). THEY KEEP TELLING US IT IS A NON-CRITICAL SYSTEM, BUT IT CAUSED AN ACCIDENT. WITH THE OTHER FAILURES AFTER THE ACCIDENT, THE ABS WOULD KICK IN FOR NO REASON, I REACT WITH MORE PRESSURE (SINCE I'M NOT EXPECTING THE ABS TO COME IN TO PLAY DURING A NORMAL BRAKING SITUATION), THEN FAIL IN THE MIDDLE OF A NORMAL STOP CAUSING A NEAR WHEEL LOCK-UP. I BELIEVE THIS IS A BIG SAFETY PROBLEM AND WARRANTS A GOOD LOOK. *JB
NHTSA ODI #10166754
29,000 miles · Aug 15, 2006
Electrical SystemFire
DT*: THE CONTACT STATED THE VEHICLE CAUGHT FIRE WHILE PARKED. THE FIRE WAS LOCALIZED IN THE ENGINE COMPARTMENT. THE VEHICLE WAS CONSIDERED A TOTAL LOSS, AND A POLICE REPORT WAS TAKEN. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE, AND THE CAUSE OF THE FIRE WAS NOT DETERMINED.*AK
NHTSA ODI #10165504
500 miles · Jul 10, 2006
Latches/locks/linkages
DT*: THE CONTACT STATED THE SLIDING DOOR TO THE VEHICLE WAS NOT SHUTTING PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER 3 TIMES. BOTH THE MANUFACTURER AND DEALER DETERMINED THAT THEY COULD NOT FIX THE PROBLEM WITH THE SLIDING DOOR. THERE WERE NO ACCIDENTS WHICH BEFORE THE PROBLEMS WITH THE SLIDING DOOR, BUT THE CONTACT EXPRESS…
Read full complaint
DT*: THE CONTACT STATED THE SLIDING DOOR TO THE VEHICLE WAS NOT SHUTTING PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER 3 TIMES. BOTH THE MANUFACTURER AND DEALER DETERMINED THAT THEY COULD NOT FIX THE PROBLEM WITH THE SLIDING DOOR. THERE WERE NO ACCIDENTS WHICH BEFORE THE PROBLEMS WITH THE SLIDING DOOR, BUT THE CONTACT EXPRESSED THAT THE VEHICLE IS TOO DANGEROUS TO DRIVE. ONE DOES NOT KNOW WHEN THE DOOR WILL OPEN. THE DOOR COMES OFF OF THE TRACK AT TIMES.
NHTSA ODI #10162022
600 miles · Jun 2, 2006
Exterior LightingStructure
WHISTLE NOISE FROM FRONT OF VEHICLE AROUND 60 MPH. DEALER HAS REPLACED THE FRONT WINDSHIELD SEAL, DOOR SEAL, AND A GASKET UNDER THE HOOD BUT THIS HAS NOT HELPED. THE DEALER TOLD ME THAT THEY DIDN'T HEAR THE WHISTLE UNLESS THEY DROVE IT 90 MPH!!! I WAS TOLD THAT THIS IS A PROBLEM WITH PONTIAC'S DESIGN AND IT CAN NOT BE FIXED. …
Read full complaint
WHISTLE NOISE FROM FRONT OF VEHICLE AROUND 60 MPH. DEALER HAS REPLACED THE FRONT WINDSHIELD SEAL, DOOR SEAL, AND A GASKET UNDER THE HOOD BUT THIS HAS NOT HELPED. THE DEALER TOLD ME THAT THEY DIDN'T HEAR THE WHISTLE UNLESS THEY DROVE IT 90 MPH!!! I WAS TOLD THAT THIS IS A PROBLEM WITH PONTIAC'S DESIGN AND IT CAN NOT BE FIXED. PASSENGER SIDE SLIDING DOOR DOESN'T STAY SHUT AND DOESN'T OPEN WHEN OUTSIDE HANDLE IS PULLED AND MOTOR RUNNING TOO LONG AND GRINDING AFTER DOOR HAS CLOSED. THE DOOR MOTOR HAS BEEN REPLACED YET THERE IS STILL A GRINDING NOISE WHEN THE DOOR SHUTS. HEADLIGHTS SURGING CAUSING ME TO CONSTANTLY BE BRIGHT LIGHTED BY ONCOMING TRAFFIC. THE DEALER TOLD ME THAT THIS IS NORMAL!*JB
NHTSA ODI #10158836
11,036 miles · May 15, 2006
Electrical SystemExterior Lighting
DT*: THE CONTACT STATED THE HEADLIGHTS AND DASHBOARD LIGHTS PULSATE, BRIGHTER TO DARKER. THE DEALERSHIP DETERMINED THIS WAS HOW THE VEHICLE WAS MANUFACTURED.
NHTSA ODI #10157556
Official recalls
5Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration