NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
99 reportsClear category filter34,000 miles · Nov 3, 2003
Air BagsEngine And Engine Cooling
VEHICLE COMES EQUIPPED WITH SIDE AIR BAGS WHICH ARE LOCATED IN THE FRONT SEAT BACKS. THE PADDING WASN'T PROPERLY DESIGNED WHEN MANUFACTURED. AS A RESULT, SEAT COVER MATERIAL IS RIPPING, WHICH WILL EVENTUALLY LEAVE THE BOX CONTAINING THE SIDE AIR BAG EXPOSED. ALSO, AT 33,000 MILES THE HEAD GASKET DEVELOPED A LEAK AND DESTROYE…
Read full complaint
VEHICLE COMES EQUIPPED WITH SIDE AIR BAGS WHICH ARE LOCATED IN THE FRONT SEAT BACKS. THE PADDING WASN'T PROPERLY DESIGNED WHEN MANUFACTURED. AS A RESULT, SEAT COVER MATERIAL IS RIPPING, WHICH WILL EVENTUALLY LEAVE THE BOX CONTAINING THE SIDE AIR BAG EXPOSED. ALSO, AT 33,000 MILES THE HEAD GASKET DEVELOPED A LEAK AND DESTROYED THE ENGINE MOTOR. *AK
NHTSA ODI #10046161
59,000 miles · Sep 24, 2003
Engine And Engine Cooling
COMPLETE ENGINE FAILURE AND RADIATOR SLUDE ON 1999 PONTIAC MONTANA AS A RESULT OF DEX-COOL COOLANT
NHTSA ODI #10039477
52,000 miles · Sep 16, 2003
Engine And Engine Cooling
I HAVE JUST TAKEN IN OUR 99 MONTANA AND HAVE LEARNED THAT I HAVE AN ENGINE GASKET LEAK. THIS WILL BE THE 2ND GASKET LEAK THE ENGINE HAS INCURRED. THE FIRST ONE WAS A HEAD GASKET AND THIS MOST RECENT GASKET IS A LOWER INTAKE. THE REASON THIS CONCERNS ME IS THAT I HAD A DEAR FRIEND HAVE AN AUTOMOBILE ISSUE WHERE HE HAD TO PULL …
Read full complaint
I HAVE JUST TAKEN IN OUR 99 MONTANA AND HAVE LEARNED THAT I HAVE AN ENGINE GASKET LEAK. THIS WILL BE THE 2ND GASKET LEAK THE ENGINE HAS INCURRED. THE FIRST ONE WAS A HEAD GASKET AND THIS MOST RECENT GASKET IS A LOWER INTAKE. THE REASON THIS CONCERNS ME IS THAT I HAD A DEAR FRIEND HAVE AN AUTOMOBILE ISSUE WHERE HE HAD TO PULL OVER ON THE SIDE OF THE HIGHWAY. IT HAPPENED TO BE FRIDAY WITH HEAVY TRAFFIC. TOO MAKE A LONG STORY SHORT, WHILE HE WENT OUT FOR REPAIRS HIS VEHICLE WAS REAR ENDED WHILE ON THE SIDE OF THE ROAD AND HE LOST HIS FIRST SON AND HIS SECOND SON HAD BRAIN DAMAGE. THE REASON I BRING THIS UP IS BECAUSE I'VE BEEN LUCKY AS FAR AS CATCHING THESE GASKET ISSUES IN THEIR EARLY STAGES OF FAILURE. I COULD HAVE BEEN THAT GUY STUCK ON THE HIGHWAY WITH A GASKET THAT HAS FAILED, NOT ONCE BUT MAYBE TWICE. IT SEEMS OBVIOUS THAT GM HAS A SERIOUS GASKET ISSUE WITH THIS PARTICULAR ENGINE AND ARE NOT CONCERNED ABOUT THEIR CUSTOMER'S FAMILIES SAFETY. *JB
NHTSA ODI #10039025
70,000 miles · Aug 21, 2003
Engine And Engine Cooling
I HAVE A 1999 PONTIAC MONTANA THAT THE COOLANT LIGHT CAME ON AND NOTICED WATER MISSING FROM COOLANT RECOVERY TANK. THIS HAD HAPPENED BEFORE SO I TOOK THE VEHICLE TO A LOCAL GM DEALER. AFTER THEY TESTED IT I WAS TOLD THAT THE INTAKE MANIFOLD AND HEAD GASKETS WERE LEAKING AND WOULD NEED TO BE REPLACED AT A COST OF $1540.39. AF…
Read full complaint
I HAVE A 1999 PONTIAC MONTANA THAT THE COOLANT LIGHT CAME ON AND NOTICED WATER MISSING FROM COOLANT RECOVERY TANK. THIS HAD HAPPENED BEFORE SO I TOOK THE VEHICLE TO A LOCAL GM DEALER. AFTER THEY TESTED IT I WAS TOLD THAT THE INTAKE MANIFOLD AND HEAD GASKETS WERE LEAKING AND WOULD NEED TO BE REPLACED AT A COST OF $1540.39. AFTER DOING A SMALL AMOUNT OF RESEARCH ON THE INTERNET I FOUND HUNDREDS OF WEBSITES OF PEOPLE HAVING THE SAME PROBLEM WITH THIS VEHICLE. I CONTACTED GM FOR ASSISTANCE AND I WAS TOLD THAT MY VEHICLE WAS OUT OF WARRANTY AND THEY WERE NOT AWARE OF THIS TYPE OF PROBLEM FROM ANYONE ELSE. I KNOW TWO OTHER PEOPLE THAT OWN PONTIAC MONTANA'S IN THE TOWN I LIVE IN THAT HAVE HAD THE SAME PROBLEM. THEY BOTH CALLED GM AND WERE GIVEN THE SAME STORY I WAS TOLD. WITH AS MANY PEOPLE HAVING THIS PROBLEM WITH THE SAME TYPE ENGINE/VEHICLE I FEEL LIKE GM SHOULD STAND BEHIND THERE PRODUCT AND PAY FOR THIS REPAIR.*AK
NHTSA ODI #10033234
61,139 miles · Aug 12, 2003
Engine And Engine Cooling
I TOOK MY 1999 PONTIAC MONTANA IN FOR AN OIL CHANGE AND WAS TOLD THAT I HAVE AN INTAKE MANIFOLD GASKET THAT IS LEAKING. I WAS TOLD THAT IF IT WAS NOT REPAIRED SERIOUS ENGINE DAMAGE COULD RESULT. I HAVE 63,000 MILES ON THE VEHICLE AND BELIEVE THAT THIS IS NOT NORMAL WEAR AND TEAR BUT RATHER A FACTORY ASSEMBLY DEFECT OR POOR DESI…
Read full complaint
I TOOK MY 1999 PONTIAC MONTANA IN FOR AN OIL CHANGE AND WAS TOLD THAT I HAVE AN INTAKE MANIFOLD GASKET THAT IS LEAKING. I WAS TOLD THAT IF IT WAS NOT REPAIRED SERIOUS ENGINE DAMAGE COULD RESULT. I HAVE 63,000 MILES ON THE VEHICLE AND BELIEVE THAT THIS IS NOT NORMAL WEAR AND TEAR BUT RATHER A FACTORY ASSEMBLY DEFECT OR POOR DESIGN. *AK
NHTSA ODI #10032682
70,030 miles · Aug 7, 2003
Engine And Engine Cooling
WHILE DRIVING 65 MPH THE INTAKE MANIFOLD GASKET FAILED AND ALLOWED COOLANT TO MIX WITH THE ENGINE OIL. THIS CAUSED THE ENGINE TO OVERHEAT AND SHUT DOWN. THE CONSUMER FOUND OUT THAT THE MANUFACTURER WAS AWARE OF THE PROBLEM AND REDESIGNED THE GASKET. CHEVROLET OWNERS WITH 3.8L ENGINES WERE NOTIFIED OF THE POTENTIAL FAILURE, BU…
Read full complaint
WHILE DRIVING 65 MPH THE INTAKE MANIFOLD GASKET FAILED AND ALLOWED COOLANT TO MIX WITH THE ENGINE OIL. THIS CAUSED THE ENGINE TO OVERHEAT AND SHUT DOWN. THE CONSUMER FOUND OUT THAT THE MANUFACTURER WAS AWARE OF THE PROBLEM AND REDESIGNED THE GASKET. CHEVROLET OWNERS WITH 3.8L ENGINES WERE NOTIFIED OF THE POTENTIAL FAILURE, BUT OWNER OF GM VEHICLES WITH 3.1L AND 3.4L ENGINES WERE NOT CONTACTED. *AK *PH *NLM
NHTSA ODI #10029582
76,005 miles · Aug 5, 2003
Engine And Engine Cooling
MY 1999 PONTIAC MONTANA OVERHEATED. THERE WERE NO SIGNS OTHER THAN MY WIFE MENTIONING A FUNNY SMELL. HAD TO REPLACE BOTH INTAKE MANIFOLD GASKETS AND HAVE THE COOLING SYSTEM FLUSHED. HE CLAIMED DEX-COOL CAUSES THIS PROBLEM. *AK
NHTSA ODI #10030875
95,000 miles · Aug 3, 2003
Engine And Engine Cooling
GMC KNEW OF A PROBLEM WITH LEAKING MANIFOLD INTAKE GASKETS. I RECENTLY HAD THE PROBLEM, PAID OVER $600 TO HAVE IT REPAIRED, AND A FEW WEEKS LATER, THE ENGINE BLEW...COSTING ME CLOSE TO AN ADDITIONAL $3500. I CONTACTED GM BEFORE THE REPAIRS WERE DONE, AND THEY REFUSED TO HELP ME.*AK
NHTSA ODI #10030699
44,000 miles · Jun 5, 2003
Engine And Engine Cooling
LEAKING INTAKE MANIFOLD GASGET AT 44,000 MILES. WAS FOUND BY DEALER WHEN IN FOR NORMAL SERVICE. TOLD THEY LOOK FOR THIS PROBLEM. THIS IS OUT OF WARRANTY SERVICE EVEN THOUGH THIS IS A COMMON PROBLEM ON THE 3.4L ENGINE. *AK
NHTSA ODI #10021097
58,000 miles · May 30, 2003
Engine And Engine Cooling
1999 POTIAC MONTANA - MANIFOLD FAILURE, COOLANT LEAK. A COSTLY AND APPRANTLY FREQUENT PROBLEM. *AK
NHTSA ODI #10020743
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jan 25, 2002
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE DRIVER'S AIR BAG INFLATOR MODULES COULD PRODUCE EXCESSIVE INTERNAL PRESSURE. IN THE EVENT OF A CRASH THAT WOULD TRIGGER A DRIVER'S AIR BAG DEPLOYMENT, THE INCREASED INTERNAL PRESSURE CAN CAUSE THE INFLATOR MODULE TO EXPLODE.
Consequence & remedy
Consequence: METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN FEBRUARY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
RQ00006 · Traction Control
Opened Feb 16, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration