NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
499 reports73,940 miles · Nov 16, 2004
Steering
I OWN A 1998 PONTIAC GRANDPRIX AND MY STEERING GOT VERY HARD TO TUN TO THE LEFT AND IT SEEMED JUST LIKE THE SAME PROBLEM THAT I READ ABOUT NHTSA CAMPAIGN ID # 02V286000 EVERYTHING IN THAT WAS WHAT WAS HAPPENING TO MY CAR I TOOK IT INTO THE DEALER AND THEY SAID IT WAS THE GEAR BOX WHICH IS ALSO KNOWN AS THE RACK AND PINION BUT TH…
Read full complaint
I OWN A 1998 PONTIAC GRANDPRIX AND MY STEERING GOT VERY HARD TO TUN TO THE LEFT AND IT SEEMED JUST LIKE THE SAME PROBLEM THAT I READ ABOUT NHTSA CAMPAIGN ID # 02V286000 EVERYTHING IN THAT WAS WHAT WAS HAPPENING TO MY CAR I TOOK IT INTO THE DEALER AND THEY SAID IT WAS THE GEAR BOX WHICH IS ALSO KNOWN AS THE RACK AND PINION BUT THAT THIS CAR WAS NOT UNDER THE RECALL BECAUSE IT WAS MADE IN 8/13/98. AND IT ONLY WENT ON THE RECALL TILL OCT 31, 1997. I THINK THAT THIS SHOULD BE LOOKED INTO AS I BELEIVE THIS PROBLEM DID NOT STOP IN 1997 PRODUCTION.*AK
NHTSA ODI #10098918
Mileage unknown · Nov 15, 2004
Service Brakes, HydraulicVehicle Speed Control
CONSUMER WAS TRAVELING 65 MPH APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THEN, VEHICLE SUDDENLY ACCELERATED UNCONTROLLABLY. VEHICLE CONTINUED TO SPEED. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE BY PULLING THE EMERGENCY BRAKE IN ORDER TO STOP. TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETE…
Read full complaint
CONSUMER WAS TRAVELING 65 MPH APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THEN, VEHICLE SUDDENLY ACCELERATED UNCONTROLLABLY. VEHICLE CONTINUED TO SPEED. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE BY PULLING THE EMERGENCY BRAKE IN ORDER TO STOP. TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK
NHTSA ODI #10100003
77,000 miles · Nov 10, 2004
Exterior Lighting
HEADLIGHTS ON 98 GRAND PRIX GT ARE FOGGING UP AND GETTING MOISTURE INSIDE THE PROTECTIVE COVER AND REDUCING THE LIGHT THE HEADLIGHT IS SENDING OUT. THIS IS MAKING NIGHT TIME DRIVING VERY DIFFICULT AND DANGEROUS. NOONE HAS BEEN INJURIED YET AND THE NUMBER OF FAILURES IS DAILY BECAUSE THE LAMPS NEVER CLEAR UP. HAPPENED AFTER WA…
Read full complaint
HEADLIGHTS ON 98 GRAND PRIX GT ARE FOGGING UP AND GETTING MOISTURE INSIDE THE PROTECTIVE COVER AND REDUCING THE LIGHT THE HEADLIGHT IS SENDING OUT. THIS IS MAKING NIGHT TIME DRIVING VERY DIFFICULT AND DANGEROUS. NOONE HAS BEEN INJURIED YET AND THE NUMBER OF FAILURES IS DAILY BECAUSE THE LAMPS NEVER CLEAR UP. HAPPENED AFTER WARRANTY EXPIRED AND SHOULD NOT BE PLACED ON THE OWNER TO FIX, BECAUSE THIS IS A FAULT CAUSED BY THE FAILURE OF PARTS.
NHTSA ODI #10098606
59,950 miles · Nov 3, 2004
Steering
1998 GRAND PRIX WITH ABOUT 59000 MILES. POWER STEERING TO THE LEFT SEEMED TO BE CUTTING OUT PERIODICALLY ABOUT A WEEK BEFORE ALL POWER STEERING TO THE LEFT FAILED. VERY DIFFICULT TO TURN LEFT AT LOW SPEEDS. FINE TURNING TO THE RIGHT, BUT VERY DIFFICULT TO TURN LEFT, MUST USE A LOT OF MUSCLE. ALSO MAKES A GRINDING OR WHINING …
Read full complaint
1998 GRAND PRIX WITH ABOUT 59000 MILES. POWER STEERING TO THE LEFT SEEMED TO BE CUTTING OUT PERIODICALLY ABOUT A WEEK BEFORE ALL POWER STEERING TO THE LEFT FAILED. VERY DIFFICULT TO TURN LEFT AT LOW SPEEDS. FINE TURNING TO THE RIGHT, BUT VERY DIFFICULT TO TURN LEFT, MUST USE A LOT OF MUSCLE. ALSO MAKES A GRINDING OR WHINING NOISE WHEN TURNED ALL THE WAY LEFT. STEERING FAILED ALL OF THE SUDDEN. NEARLY HAD AN ACCIDENT. LUCKILY GOING SLOW ENOUGH TO STOP WITHOUT GETTING HIT. VERY DIFFICULT TO STEER LEFT.*AK
NHTSA ODI #10098227
Mileage unknown · Oct 28, 2004
Engine And Engine Cooling
REPLACED OIL PAN GASKET DUE TO LEAKAGE. STARTED LEAKING AGAIN. OIL PAN WAS NOT DESIGNED RIGHT, HAS RIPPLES IN IT. *BF THE CONSUMER WAS TOLD THERE WAS A TECHNICAL SERVICE BULLETIN OUT WHICH RECOMMENDED USING SILICONE AS A GASKET. *JB
NHTSA ODI #10099465
Mileage unknown · Oct 6, 2004
Air BagsCrashInjury
I WAS IN A CAR ACCIDENT. A CAR WENT THROUGH A RED LIGHT AND STRUCK ME.THE AIRBAG ON THE PASSENGER SIDE DEPLOYED AND BROKE THE WINDSHIELD. THE AIRBAG DID MORE DAMAGE TO THE CAR.*AK
NHTSA ODI #10093701
100,000 miles · Sep 30, 2004
EquipmentVisibility
ALL FOUR OF MY WINDOWS HAVE GONE OUT! I HAVE POWER WINDOWS, AND NONE OF THEM WORK. ONE GOES DOWN ABOUT TWO INCHES, TWO DON'T BUDGE, AND THE OTHER FALLS DOWN IF IT ISN'T PROPPED UP WITH SOMETHING WEDGING IT BETWEEN THE GLASS AND THE DOOR. I HAVE BEEN TOLD THIS WILL COST ME WELL OVER $1500 TO FIX, AND I KNOW THERE'S A PROBLEM I…
Read full complaint
ALL FOUR OF MY WINDOWS HAVE GONE OUT! I HAVE POWER WINDOWS, AND NONE OF THEM WORK. ONE GOES DOWN ABOUT TWO INCHES, TWO DON'T BUDGE, AND THE OTHER FALLS DOWN IF IT ISN'T PROPPED UP WITH SOMETHING WEDGING IT BETWEEN THE GLASS AND THE DOOR. I HAVE BEEN TOLD THIS WILL COST ME WELL OVER $1500 TO FIX, AND I KNOW THERE'S A PROBLEM IF ALL FOUR QUIT WORKING IN THE SAME YEAR!*AK
NHTSA ODI #10093375
Mileage unknown · Sep 23, 2004
Engine And Engine Cooling
WHILE DRIVING, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE BUT WAS UNABLE TO DO SO. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATED THE PROBLEM. THE CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM HAS OCCURRED MORE THAN ONCE AND THE PROBLEM HAS NOT B…
Read full complaint
WHILE DRIVING, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE BUT WAS UNABLE TO DO SO. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATED THE PROBLEM. THE CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM HAS OCCURRED MORE THAN ONCE AND THE PROBLEM HAS NOT BEEN RESOLVED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10094231
98,000 miles · Sep 22, 2004
Engine And Engine Cooling
COOLANT ELBOW PRODUCED A CRACK. AS A RESULT, ANTI FREEZE LEAKED. THE PART WAS REPLACED TWICE. HOWEVER, THE PROBLEM RECURRED. *AK
NHTSA ODI #10094084
Mileage unknown · Sep 17, 2004
Service Brakes, Hydraulic
WHILE DRIVING CONSUMER HEARD A LOUD CLANKING NOISE. BRAKES DROPPED AN INCH. THE SHAFT THAT WENT FROM THE PEDAL TO THE BOOSTER BROKE IN HALF. THE STEEL SLEEVE THAT ENCASED THE BOOSTER WAS SHATTERED. *AK
NHTSA ODI #10092661
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
Illustration