NO OTHER MANUFACTURER, AMERICAN OR FORIEGN, HAS A HIGHER INCIDENCE OF WARPED FRONT ROTORS, AND WITHIN THE LAST DECADE THIS PROBLEM INCREASINGLY SHOWS ITSELF AT RELATIVEY LOW MILAGE. MY MOST RECENT EXPERIENCE (LAST 3 YEARS) WAS A NEW GRAND AM SE DEVELOPING PULSATING BRAKES AT 20K MI. THE DEALER FOUGHT WITH US TOOTH & NAIL AND SA…
Read full complaint
NO OTHER MANUFACTURER, AMERICAN OR FORIEGN, HAS A HIGHER INCIDENCE OF WARPED FRONT ROTORS, AND WITHIN THE LAST DECADE THIS PROBLEM INCREASINGLY SHOWS ITSELF AT RELATIVEY LOW MILAGE. MY MOST RECENT EXPERIENCE (LAST 3 YEARS) WAS A NEW GRAND AM SE DEVELOPING PULSATING BRAKES AT 20K MI. THE DEALER FOUGHT WITH US TOOTH & NAIL AND SAID "THAT'S YOUR FAULT, WE AINT PAYING FOR ANYTHING!" I CALLED THE PONTIAC ZONE AND RAISED HELL, ..NO CIGAR. FINALLY GOT WITH THE SHOP MANAGER TO PULL THE ROTORS & PUT THEM ON THE LATHE AND SEE HOW TRUE THEY WERE. THEY WEREN'T, BUT WE KNEW THAT BEFORE WE GOT STARTED. THE BRAKE PADS SHOWED VERY LITTLE WEAR. CONCLUSION, I GOT HUSTLED OUT OF THE SHOP WITH "WE'LL TAKE CARE OF IT." THEY DID, A NEW BRAKE JOB AT NO CHARGE. THE SECOND CAR WAS A 2000 MALIBU. CHEVROLET, THEY SAID PAY US FOR NEW ROTORS OR TAKE A HIKE. WE HIKED. REPLACED THE BRAKES MYSELF AND THE PROBLEM CAME RIGHT BACK AROUND 18K MI. I SOLD THE CAR INSTEAD OF FIXING IT. MY LAST GM CAR IS AN 04 GRAND AM, AND WITH JUST 11K MI, ...HERE WE GO AGAIN!! GENERAL MOTORS KNOWS OF THIS PROBLEM. IT'S RAMPANT IN THE PRODUCT LINE- UP. TO ANNOUNCE A CHANGE WOULD BE STRICTLY FORBIDDEN AS A MATTER OF CORPORATE POLICY AS THAT MIGHT DRAW LIABILITY LEADING TO POSSIBLE CLASS ACTION SUITS. KEEP IN MIND THAT BRAKES ARE A SAFETY ITEM NOT SUBJECT TO LIMITATIONS OF WARRANTY OR LIABILITY WHERE IT CAN BE SHOWN THAT GM "KNEW, OR SHOULD HAVE KNOWN", THAT THIS PROBLEM EXISTS. ERGO, OPENED ENDED LIABILITY. FURTHER, GM HAS KNOWN OF THESE POORLY PERFORMING PARTS THRU THEIR DEALERSHIPS AND HIGH VOLUME REPLACEMENTS ORDERED THRU THE DEALERS AND INDEPENDENT PARTS OUTLETS. AND FINALLY, THE ASTONISHING THING ABOUT THIS PART IS THAT IT'S AS LOW TECH AS IT GETS. IT'S NOTHING MORE THAN CAST PIG IRON. THE FIX IS IN THE METAL CHEMISTRY AND CASTING TECHNIQUE. WHERE GM GETS A FREE RIDE IS TO ARGUE THAT THIS ITEM IS "CONSUMABLE" AND SUBJECT TO WEAR AND ABUSE BEYOND THE MANUFACTURERS CONTROL.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK THAT DOES NOT MEET SPECIFICATION. A WELD ON THESE FUEL TANKS MAY BE INSUFFICIENT, RESULTING IN A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK, AND REPLACE IT, IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration