Electrical System. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

24 crash reports7 fire reports12 injury reports

Engine And Engine Cooling complaints

12 reports

Clear category filter

400 miles · Aug 16, 2005

Engine And Engine CoolingPower TrainService Brakes, Hydraulic

Read full complaint

DT: WHILE DRIVING IN RAINY WEATHER IT SOUNDED FROM THE RIGHT FRONT CORNER OF THE CAR UNDER THE HOOD LIKE SOMETHING WAS GRINDING OR ABRASION. IT SOUNDED LIKE TWO BEARINGS RUBBING AGAINST EACH OTHER. TOOK THE CAR TO THE DEALER, AND THEY WERE NOT ABLE TO HEAR IT. THE DEALER TOOK IT FOR A TEST DRIVE, LIFTED IT UP ONTO THE LIFT AND WAS NOT ABLE TO HEAR ANY NOISE.*AK UPDATED 8/14/2006 - THE RIGHT FRONT TIRE WARPED. THE BRAKE CALIPERS WARPED SHORTLY AFTER THE VEHICLE WAS PURCHASED. BOTH FRONT ROTORS HAD TO BE REPLACED DUE TO WARPAGE. THE CONSUMER HEARD NOISE ON THE DRIVER'S SIDE FRONT END. THE DEALER REPLACED THE UPPER STRUT MOUNT, BEARING PLATE AND ALIGNED THE FRONT END. THE VEHICLE WOULD LOSE POWER WHILE DRIVING. THE DEALER REPROGRAMMED THE ENGINE CONTROL MODULE. THE MASTER CYLINDER LEAKED AND HAD TO BE REPLACED. POWER STEERING PUMP LEAKED AND WAS REPLACED. THE TRAMSMISSION WAS SLIPPING. *NM

NHTSA ODI #10133010

Mileage unknown · Jun 2, 2005

Engine And Engine Cooling

2004 PONTIAC GRAND PRIX SHUTS DOWN WHILE DRIVING AND THE POWER STEERING AND BRAKING ABILITY ARE LOST.*MR *NM

NHTSA ODI #10124713

Official recalls

14V400000 · Electrical System:ignition

Jul 3, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

04V301000 · Fuel System, Gasoline:storage

Jun 30, 2004

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK THAT DOES NOT MEET SPECIFICATION. A WELD ON THESE FUEL TANKS MAY BE INSUFFICIENT, RESULTING IN A FUEL LEAK.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANK, AND REPLACE IT, IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.