IllustrationNON-POWER WINDOWS. WAS TOUGH TO ROLL DOWN, THEN ONE DAY WOULDN'T ROLL UP. REPAIR SHOP LOOKED AT IT, STATED THAT THE WINDOW REGULATOR WAS BROKEN BENT WHICH WAS MAKING WINDOW TRY TO ROLL OFF-TRACK. *AK
1994 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 1994 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 27 of 377 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
58 crash reports28 fire reports38 injury reports
What owners actually said
377 reportsCAR HAD TOUGH TIME TO ACCELERATE, AFTER THREE VISITS TO REPAIR SHOP, PROBLEM WAS DIAGNOSED AS THE TERMINALS FROM THE MAIN COMPUTER TO THE 02 SENSOR WERE BAD. HAD TO REPLACE COMPUTER AND SENSOR. HEAD GASKET WAS LEAKING, TAKEN IN TO BE REPAIRED AND FOUND OUT THAT THE ENGINE HEAD ITSELF WAS CRACK WHERE #2 CYLINDER IS LOCATED. RE…
Read full complaint
CAR HAD TOUGH TIME TO ACCELERATE, AFTER THREE VISITS TO REPAIR SHOP, PROBLEM WAS DIAGNOSED AS THE TERMINALS FROM THE MAIN COMPUTER TO THE 02 SENSOR WERE BAD. HAD TO REPLACE COMPUTER AND SENSOR. HEAD GASKET WAS LEAKING, TAKEN IN TO BE REPAIRED AND FOUND OUT THAT THE ENGINE HEAD ITSELF WAS CRACK WHERE #2 CYLINDER IS LOCATED. REPAIR SHOP STATED IS A COMMON PROBLEM WITH QUAD FOUR GRAND AMS. HAD TO PAY APPROX. $2,500 IN REPAIRS
WHILE DRIVING WITH LIGHTS ON DASHBOARD, HEADLIGHTS WOULD CONSTANTLY GO OUT, AND AT THIS TIME, WERE NOT WORKING. ALSO, TAIL LIGHTS WORKED ERRATICALLY. CONSUMER WAS UNABLE TO DRIVE WITHOUT LIGHTS. IN ADDITION, STARTER AND BATTERY HAD TO BE REPLACED. *AK
TIRE TREAD CAME UNDONE IN A TIRE WITH ONLY 31,000 MILES. DAMGAE WAS DONE. *AK (DOT NUMBER: P1857514 TIRESIZE: P18575R14)
BUBBLE IN BRAKE CASING CAUSED BRAKE PADS TO PREMATURELY WEAR. PLEASE GIVE ANY FURTHER DETAILS. *AK
EA00007; A FIRE STARTED IN STEERING COLUMN. THERE SEEMED TO BE AN EXPLOSION. TOTAL LOSS. *AK
ENGINE HEAD CRACKED, CAUSING THE WATER TO LEAK, AND A ROUGH RIDE IN VEHICLE. DEAELR HAS BEEN CONTACTED. *AK
WINDSHIELD WIPERS WORKED INTERMITTETLY, THEN STOPPED ALL TOGETHER. *AK
THE HEAD CRACKED ON THE ENGINE. AFTER TALKING WITH SEVERAL DEALERS THIS IS A COMMON OCCURRENCE AMONG GRAND AM'S. PLEASE INQUIRE SILENT RECALL.*AK
POWER WINDOWS STOPPED WORKING AND HEATER COIL WENT OUT, AND RADIATER BROKE AND STEERING WILL AND PUT SOMETHING IN THE STEERING COLUMN HAD WHEEL CYLINDER REPLACED HEAD GASKET , AND CRUISE CONTROL STOPPED WORKING. *AK
Official recalls
200V287000 · Electrical System:starter Assembly
Oct 2, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE ENGINE STARTER FAILS TO ENGAGE AND THE DRIVER HOLD THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, PRODUCING HEAT THAT CAN MELT SWITCH PARTS.
Consequence & remedy
Consequence: A FIRE COULD OCCUR IN THE STEERING COLUMN AND SPREAD TO THE INTERIOR OF THE CAR.
Remedy: DEALERS WILL INSTALL A RELAY KIT AND VERIFY THAT THE VEHICLE WILL START WITH A PROPERLY CHARGED BATTERY IN GOOD OPERATING CONDITION (ADEQUATE RESERVE CAPACITY, OR COLD CRANKING AMPS). THIS CAMPAIGN DOES NOT COVER BATTERY REPLACEMENT OR UNRELATED STARTING SYSTEM OR ELECTRICAL SYSTEM REPAIRS.
94V122000 · Fuel System, Gasoline:storage:tank Assembly
Jul 1, 1994
THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT TO COMPLY WITH THE REQUIREMENTS PERTAINING TO FUEL TANK LEAKAGE IN THE EVENT OF A REAR IMPACT COLLISION. THE FUEL TANK ASSEMBLIES DO NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: THIS CAN RESULT IN AN INCREASED RISK OF A VEHICLE FIRE IN THE EVENT OF A REAR IMPACT COLLISION.
Remedy: DEALER WILL INSTALL RIVETS ADJACENT TO THE LOCATIONS WHERE THE SUSPECT WELDS ARE LOCATED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA00007 · Steering Column Fires
Opened Mar 3, 2000 · Closed Feb 7, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE99063 · Steering Column Fire
Opened Oct 7, 1999 · Closed Mar 3, 2000
Status: closed (inferred from source dates) · Steering
ODI HAS EXPANDED THE SCOPE OF ITS INVESTIGATION OF STEERING COLUMN FIRES TO INCLUDE ALL MODELS BUILT ON THE N-PLATFORM.GM HAS INDICATED IN ITS RESPONSE THAT THE SUBJECT VEHICLES ARE EQUIPPED WITH A ROTARY IGNITION SWITCH THAT HAS BEEN IN USE IN A NUMBER OF VEHICLE MODELS SINCE 1991 ON BOTH THE N AND J-PLATFORMS.HOWEVER, THE 1994-1995 N-PLATFORM IS OVER REPRESENTED ACCOUNTING FOR 83 (81%) OF THE COMBINDED TOTAL OF 102 REPORTS DESPITE BEING ONLY 14.2% OF THE COMBINED POPULATION. OF THE 10 NEW REPORTS RECEIVED SINCE OPENING EA99-063, 7 INCLUDE ALLEGATIONS OF A NO START CONDITION WHEN ATTEMPTING TO ENGAGE THE STARTER.A FIRE IS CLAIMED TO HAVE ENSUED IN THE STEERING COLUMN IMMEDIATELY THERAFTER.GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB) (NO. 433203) JULY 1994 WHIICH ADDRESSED OWNER COMPLAINTS THAT THE IGNITION SWITCH MAY NOT RETURN TO THE RUN POSITION AFTER THE VEHICLE HAS STARTED.THE TSB ADVISES THAT THE IGNITION SWITCH MOUNTING SCREWS MAY BE EXCESSIVELY TORQUED RESULTING IN DISTORTION OF THE SWITCH HOUSING.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE ROOT CAUSE(S) AND TO DETERMIN IF A SAFETY DEFECT EXISTS.