IllustrationPOWER STIRRING WENT OUT SUDDENLY CAUSING THE CAR TO SHAKE AND NOT RESPOND PROPERLY TO DRIVER OPERATION. OTHER MALES HAVE HAD ISSUE BUT 2007 G6 HARD TOP CONVERTIBLE DIDN'T MAKE THAT LIST, EVEN THOUGH MANY OTHER OWNERS HAVE HAD THIS SAFETY ISSUE ON SAME MODEL AND YEAR.
2007 Pontiac G6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Pontiac G6 do not stand out strongly from the model-year median of 679.
About this comparison →How this year compares
Owner complaints by model year
Compare all G6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
980–25K
13925–50K
18050–75K
20175–100K
249100–150K
137150K+
1,004 reports with mileage · 227 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 540 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 232 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 197 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
54 crash reports24 fire reports24 injury reports
Unknown Or Other complaints
28 reportsFOR AWHILE NOW MY CHECK ENGINE LIGHT HAS BEEN ON AND MY NO TRACTION CONTROL LIGHT HAS BEEN BLINKING SO I HAD A FULL DIAGNOSTIC INSPECTION DONE THAT READ NOTHING. AS A RESULT, I HAD THEM DO A FUEL SYSTEM CLEANING SINCE THERE IS A SMALL JERKY FEEL EVERY TIME I DRIVE. I ALSO HAD THEM DO A BREAK FLUID EXCHANGE BUT THE NO TRACTION CO…
Read full complaint
FOR AWHILE NOW MY CHECK ENGINE LIGHT HAS BEEN ON AND MY NO TRACTION CONTROL LIGHT HAS BEEN BLINKING SO I HAD A FULL DIAGNOSTIC INSPECTION DONE THAT READ NOTHING. AS A RESULT, I HAD THEM DO A FUEL SYSTEM CLEANING SINCE THERE IS A SMALL JERKY FEEL EVERY TIME I DRIVE. I ALSO HAD THEM DO A BREAK FLUID EXCHANGE BUT THE NO TRACTION CONTROL LIGHT STILL BLINKS. ALONG WITH THAT, MOST TIMES AFTER FUELING UP MY CAR, MY CAR DRIVES WELL AND JUST FINE BUT ON SEPTEMBER 18TH, AFTER FUELING UP, I WAS TURNING INTO TRAFFIC PROCEEDING TO THE FARTHEST LANE SO THAT I CAN TURN LEFT INTO MY APARTMENTS THEN POP! AND THE STEERING WHEEL LOCKED AND THE GEAR HAD LOCKED IN DRIVE. THIS SCARED ME SO BAD SO I BRAKED IN EVERY WAY I COULD HOPING I WOULDN'T CRASH THEN TRIED SHIFTING GEARS AND CRANKING MY CAR AGAIN. I GOT INTO THE GATES AND INTO THE PARKING LOT THEN MY CAR STALLED AND CUT OFF AGAIN. I FINALLY PARKED MY CAR, POPPED THE HOOD, AND THERE WAS NOTHING WRONG THAT I COULD SEE FROM MY VIEW. SO, THE NEXT DAY SEPTEMBER 19TH I DROVE TO CLASS THAT MORNING AND IT STALLED A BIT ANY TIME I INCREASED MY SPEED AS IF IT WANTED TO CUT OFF. I GOT INTO THE PARKING LOT OF MY COLLEGE AND IT CUTS OFF AS SOON AS I BEGIN TO TURN INTO A PARKING SPOT BETWEEN TWO CARS. I CRANK IT UP, COMPLETE MY PARK THEN I GO INSIDE FOR CLASS UNTIL LUNCH. ON LUNCH, I CRANK UP MY CAR AND WOW THE CHECK ENGINE LIGHT IS FINALLY OFF BUT AS USUAL THE NO TRACTION CONTROL LIGHT IS BLINKING. I TEST DRIVE MY CAR TO THE LOCAL WINN DIXIE AND BACK AND ON THE WAY BACK POP! THEN IT STALLS TO CUT OFF BUT DOESN'T CUT OFF SO I TAKE IT BACK TO MY COLLEGE BEFORE LUNCH IS OVER AND PARK IT. NOW IT'S THE END OF THE DAY AND I'M OUT OF CLASS AND HEADED HOME. THIS TIME I MAKE IT INTO THE GATE BUT I'M GETTING CLOSE TO GOING OVER A SPEED BUMP AND POP! IT DOESN'T CUT OFF BUT IT'S STALLS BADLY LIKE IT WANTS TOO SO I PROCEED TO DRIVE THEN PARK IT. PLEASE, HELP.
AIRBAG LIGHT COMES ON ALL OF THE TIME AFTER STARTING THERE IS AN ODD WHISTLE TYPE NOISE THAT WE CANNOT FIGURE OUT. IT OCCURS WHEN ACCELERATING.
I AM GREATLY IN NEED OF YOUR ASSISTANCE. I OWN A 2007 PONTIAC G6 HARDTOP CONVERTIBLE. I PURCHASED IT IN JANUARY 2016. ABOUT A MONTH AFTER PURCHASE, I TRIED TO PUT THE TOP UP . ON ITS WAY TO CLOSING AND LOCKING ITS MECHANISM CAUSED A MALFUNCTION AND BROKE THE PART NUMBER 25887153 AWAY. I IMMEDIATELY CONTACTED THE DEALER @ GM OF …
Read full complaint
I AM GREATLY IN NEED OF YOUR ASSISTANCE. I OWN A 2007 PONTIAC G6 HARDTOP CONVERTIBLE. I PURCHASED IT IN JANUARY 2016. ABOUT A MONTH AFTER PURCHASE, I TRIED TO PUT THE TOP UP . ON ITS WAY TO CLOSING AND LOCKING ITS MECHANISM CAUSED A MALFUNCTION AND BROKE THE PART NUMBER 25887153 AWAY. I IMMEDIATELY CONTACTED THE DEALER @ GM OF VACAVILLE, CA. THE DEALERSHIP TOLD ME, 'THIS PART IS NO LONGER AVAILABLE', & THEY HAD MY VEHICLE FOR 3 WEEKS. I HAVE INCURRED $ 1400. IN AUTO RENTAL FEES. I HAVE TALKED WITH MORE THAN 20 PONTIAC DEALERS ALL STATE; "WE HAVE BEEN TOLD BY GM TO SAY - THE PART NO LONGER EXIST AND IS NOT AVAILABLE"THE PARTS MANUFACTURE, KARMANN MADE THE PART FOR GM. THEY MAY HAVE THE PART IN THEIR WAREHOUSE. BUT, ACCORDING TO THEIR EMPLOYEE, GM WILL NOT GIVE THEIR PERMISSION TO SELL IT THE WORST THING IS: I HAVE BEEN IN CONTACT WITH OVER 25 PARTS DEALERS I CALLED GM AT 1-866-790-5600 EXT. 5914235 AND SPOKE WITH NATALIE. SHE ATTEMPTED TO ASSIST BUT AFTER NO PROGRESS . A MALE ANSWERED THE PHONE HE INDICATED THAT HE WAS HER SUPERVISOR, HOWEVER REFUTED TO GIVE ME HIS NAME, AND THEN STATED, 'IT'S NOT AVAILABLE, THE PART IS DISCONTINUED, AND PONTIAC DOESN'T EXIST SO GET OVER IT, OR DEAL WITH IT! IT'S NOT MY PROBLEM, IT'S YOURS, AND YOU DON'T EVEN HAVE A WARRANTY CAUSE ITS EXPIRED.' HE SLAMMED THE PHONE DOWN IN MY EAR. PLEASE ASSIST ME TO GET THE PART, OR BUY BACK THE VEHICLE AND RETURN MY INCURRED COSTS OF $13,500.THE "TOP IS NOT SECURE" HAS LEFT NO OPTION BUT TO PURCHASE ANOTHER VEHICLE. THE G6 IS GARAGED AND UNDRIVABLE
LEFT PASSENGER HEADLIGHT CONSTANTLY GOES OUT. I HAVE REPLACED BULB SEVERAL TIMES BUT WHEN I TOOK TO THE SHOP THE PLUG WAS MELTED. I HAD TO BUY A REPLACEMENT HEADLIGHT ENSEMBLE. SEVERAL CARS THIS MODEL IS DRIVING AROUND WITH ONE HEADLIGHT ON DIM AND TWO ON BRIGHT.
I'VE HAD SEVERAL PROBLEMS (4) TO WHERE MY POWER STEERING WILL GO OUT. I WOULDN'T BE ABLE TO TURN MY STEERING WHEEL PROPERLY. I'VE HAD TO GET THIS FIX MULTIPLE OF TIMES AND DECIDED TO CHECK AND SEE IF THERE WAS A RECALL ON MY VEHICLE FOR IT. I DON'T SEE IT SO I DECIDED TO RIGHT A REVIEW ABOUT IT. I HOPE THIS HELPS SOMEONE ELSE NO…
Read full complaint
I'VE HAD SEVERAL PROBLEMS (4) TO WHERE MY POWER STEERING WILL GO OUT. I WOULDN'T BE ABLE TO TURN MY STEERING WHEEL PROPERLY. I'VE HAD TO GET THIS FIX MULTIPLE OF TIMES AND DECIDED TO CHECK AND SEE IF THERE WAS A RECALL ON MY VEHICLE FOR IT. I DON'T SEE IT SO I DECIDED TO RIGHT A REVIEW ABOUT IT. I HOPE THIS HELPS SOMEONE ELSE NOT JUST ME THAT FEARS FOR THIS TO HAPPEN TO THEM. ALSO, THE DRIVER (FRONT) AND BRAKE/REVERSE LIGHTS HAS WENT OUT. I CAN'T SEEM TO GET ANYONE THAT KNOWS HOW TO FIX MY BRAKE/REVERSE LIGHTS. I'VE GOT MY DRIVER SIDE FIXED SEVERAL TIME AS WELL AND IT STILL TENDS TO GO OUT ON ME.
THE HARDTOP HAS NO POWER IT RETRACTABLE HARDTOP CONTROL MODULE IS BAD I CAN'T DRIVE IT IT GOT A DIC CODE SAYING TOP INSURCURE TRUNK INSURCURE.
PLEASE ASSIST ME WITH A HUGE AUTOMOBILE CONGLOMERATE . EVEN THE ASSIST OF THE EXECUTIVE DEPT. COULD NOT HELP MEPLEASE READ WHAT I WROTE TO THE EXECUTIVE OFFICER OF GM I OWN A 2007 PONTIAC G6 HARDTOP CONVERTIBLE I PURCHASED IT IN JANUARY 2016. ABOUT A MONTH AGO, I TRIED TO PUT THE TOP DOWN ITSMECHANISM CAUSED A MALFUNCTION A…
Read full complaint
PLEASE ASSIST ME WITH A HUGE AUTOMOBILE CONGLOMERATE . EVEN THE ASSIST OF THE EXECUTIVE DEPT. COULD NOT HELP MEPLEASE READ WHAT I WROTE TO THE EXECUTIVE OFFICER OF GM I OWN A 2007 PONTIAC G6 HARDTOP CONVERTIBLE I PURCHASED IT IN JANUARY 2016. ABOUT A MONTH AGO, I TRIED TO PUT THE TOP DOWN ITSMECHANISM CAUSED A MALFUNCTION AND BROKE THE PART NUMBER 25887153 AWAY. I IMMEDIATELY CONTACTED THE DEALER @ GM OF VACAVILLE, CA. THE DEALERSHIP TOLD ME, 'THIS PART IS NO LONGER AVAILABLE', A WEEK LATER. NEEDLESS TO SAY THEY HAVE HAD MY VEHICLE FOR 3 WEEKS. I HAVE INCURRED $ 1400. IN AUTO RENTAL FEES. THEY HAVE ATTEMPTED A MASS SEARCH FOR THE PART AS DID I, TO NO AVAIL. I HAVE TALKED WITH MORE THAN 20 PONTIAC/GM DEALERS AROUND THE U.S. THEY ALL STATE; "WE HAVE BEEN TOLD BY GM TO SAY - THE PART NO LONGER EXIST AND IS NOT AVAILABLE" I WAS ALWAYS TOLD: "BY LAW AN AUTO MANUFACTURE MUST MAKE REPLACEMENT PARTS AVAILABLE FOR UP TO 10 YEARS. THE PARTS MANUFACTURE, KARMANN MADE THE PART FOR GM. THEY MAY HAVE THE PART IN THEIR WAREHOUSE. BUT, ACCORDING TO THEIR EMPLOYEE, GM WILL NOT GIVE THEIR PERMISSION TO SELL IT - EVEN TO A GM DEALER. THE WORST THING IS: I HAVE BEEN IN CONTACT WITH OVER 25 PARTS DEALERS AND THEY ALL HAVE SAID: "YOU ARE ONE OF HUNDREDS OF CALLS WE ARE GETTING ABOUT THIS SAME PROBLEM".. I AM A SINGLE HARDWORKING MOTHER WHO WAS FINALLY ABLE TO PURCHASE HERSELF A DREAM VEHICLE, ONLY TO HAVE THIS HAPPEN WITH NO RESOLUTION IN SIGHT. PLEASE ASSIST ME TO GET THE PART, OR BUY BACK THE VEHICLE AND RETURN MY INCURRED COSTS OF $13,500.
WHEN I TURN MY DIM LIGHTS ON FROM BRIGHT THEY ALL GO COMPLETELY OUT FOR A BRIEF SECOND,2 TIMES ON COUNTRY ROAD N ONCE ON THE HIGHWAY, IN MOTION ON STRAIGHT RD VERY SCARY,LOTS OF COMPLAINTS ABOUT THIS..ALSO LEAKIN OIL N NOONE SEEMS TO KNOW WHERE, N,, THE LIGHT SAYS IM ALWAYS IN DRIVE EVEN WHEN IN PARK OR REVER, PLEASE HELP ME GET…
Read full complaint
WHEN I TURN MY DIM LIGHTS ON FROM BRIGHT THEY ALL GO COMPLETELY OUT FOR A BRIEF SECOND,2 TIMES ON COUNTRY ROAD N ONCE ON THE HIGHWAY, IN MOTION ON STRAIGHT RD VERY SCARY,LOTS OF COMPLAINTS ABOUT THIS..ALSO LEAKIN OIL N NOONE SEEMS TO KNOW WHERE, N,, THE LIGHT SAYS IM ALWAYS IN DRIVE EVEN WHEN IN PARK OR REVER, PLEASE HELP ME GET A RECALL ON THIS PROBLEM, AND OIL LEAK FOR ABOUT 8 MTHS
CAR SMELLS LIKE GAS WHEN DRIVING AND WHEN PARKED. IT ALSO SMELLS LIKE GAS WHEN IT'S OFF.
Official recalls
415V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
07V146000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Mar 30, 2007
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE RIGHT FRONT PASSENGER SEATS IN THESE VEHICLES ARE BUILT WITH A PASSENGER AIR BAG SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE, UNRESTRAINED SIX YEAR OLD CHILD, THE SYSTEM IS REQUIRED TO TURN OFF THE RIGHT FRONT PASSENGER'S AIRBAG. INTERFERENCE DURING SYSTEM CALIBRATION CAUSED THE SEATS TO BE OUT OF SPECIFICATION.
Consequence & remedy
Consequence: THIS CAN INCREASE THE RISK OF INJURY TO A CHILD SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE PASSENGER SENSING SYSTEM FREE OF CHARGE. THE RECALL WILL BEGIN ON APRIL 17, 2007. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA13005 · Brake Light Switch/sensor Malfunction
Opened Jun 6, 2013 · Closed Jul 1, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
RQ13001 · Brake Light Malfunction
Opened Feb 4, 2013 · Closed Jun 6, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
PE08054 · Stop Lamp Malfunction
Opened Sep 15, 2008 · Closed Jan 30, 2009
Status: closed (inferred from source dates) · Electrical System:software; Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Additional source detail variants (2)
Electrical System:software
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.