IllustrationSAME ISSUE AS CADILAC RECALL FOR PASSENGER PRESENCE MODULE DEFECT..WILL NOT DETECT PASSENGER PRESENCE IN SEAT, PASSENGER AIRBAG LIGHT STAYS OFF...AIRBAG WILL NOT DEPLOY IN AN ACCIDENT. *TR
2007 Pontiac G5
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all G5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
3925–50K
3550–75K
2575–100K
38100–150K
11150K+
165 reports with mileage · 23 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports2 fire reports6 injury reports
What owners actually said
188 reportsTL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND CRASHED INTO THE PASSENGER'S SIDE OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE NECK AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER PERFORMED AN INSPECTION TO DETERMINE THE AIR…
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND CRASHED INTO THE PASSENGER'S SIDE OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE NECK AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER PERFORMED AN INSPECTION TO DETERMINE THE AIR BAG FAILURE BUT WAS NOT ABLE TO DO SO. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,052.
SEEMS TO ME SEARCHING ONLINE ITS A COMMON THING TO HAVE THE GAS TANK CRACK. THERE ARE A BUNCH OF RECALLS ALREADY FOR THE CAR ONE INCLUDING THE FUEL SYSTEM BUT THEY WILL ONLY REPLACE THE GAS PUMP WHICH HAD TO BE REPLACED BECAUSE IT WAS DEFECTIVE BUT WANTED TO CHARGE OVER 1,000 FOR THE CRACKED FUEL TANK WHICH BY THE WAY HOW DOES …
Read full complaint
SEEMS TO ME SEARCHING ONLINE ITS A COMMON THING TO HAVE THE GAS TANK CRACK. THERE ARE A BUNCH OF RECALLS ALREADY FOR THE CAR ONE INCLUDING THE FUEL SYSTEM BUT THEY WILL ONLY REPLACE THE GAS PUMP WHICH HAD TO BE REPLACED BECAUSE IT WAS DEFECTIVE BUT WANTED TO CHARGE OVER 1,000 FOR THE CRACKED FUEL TANK WHICH BY THE WAY HOW DOES THAT HAPPEN ON A PRETTY RECENT CAR AND I AM NOT ALONE. THE SMELL ITS PRETTY STRONG AND I AM SURE ITS NOT SAFE BEEN LOOKING FOR ONE THROUGH JUNKERS BECAUSE I CANT AFFORD THE 1000 FOR SOMETHING THAT CAME DEFECTIVE. *TR
TL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS LEAKING AND THERE WAS A HOLE IN THE FUEL TANK. AS A RESULT, THE FUEL TANK AND FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS LEAKING AND THERE WAS A HOLE IN THE FUEL TANK. AS A RESULT, THE FUEL TANK AND FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 30,000.
TL- THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE LOST CONTROL. THE VEHICLE CRASHED INTO A TREE AND THE AIRBAGS DEPLOYED. THERE WERE NO WARNING LIGHT INDICATORS ON THE INSTRUMENT PANEL. A POLICE REPORT WAS FILED AND THERE WERE NO MAJOR INJURIES. THE DRIVER AND THE PASSENGE…
Read full complaint
TL- THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE LOST CONTROL. THE VEHICLE CRASHED INTO A TREE AND THE AIRBAGS DEPLOYED. THERE WERE NO WARNING LIGHT INDICATORS ON THE INSTRUMENT PANEL. A POLICE REPORT WAS FILED AND THERE WERE NO MAJOR INJURIES. THE DRIVER AND THE PASSENGER WAS NOT INJURED. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT INSPECTED NOR DIAGNOSED. AFTER THE ACCIDENT THE RIGHT REAR PASSENGERS SIDE BACK WHEEL LOCKS UP. THE VEHICLE WAS NOT INSPECTED NOR DIAGNOSED. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AFTER THE FAILURE OCCURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120000. DYD
WHILE DRIVING ON ICY ROADS, THE CAR BEGAN TO SLIDE AND SPIN OUT OF CONTROL. AS I ATTEMPTED TO CORRECT THE MOTION OF THE CAR, THE ENGINE SWITCHED OFF. AND BECAUSE THE ENGINE HAD SWITCHED OFF, IT BECAME IMPOSSIBLE TO TURN THE STEERING WHEEL. THE CAR SPUN AROUND AT LEAST 3 COMPLETE ROTATIONS (OF 360 DEGREES) BEFORE SLIDING TO A …
Read full complaint
WHILE DRIVING ON ICY ROADS, THE CAR BEGAN TO SLIDE AND SPIN OUT OF CONTROL. AS I ATTEMPTED TO CORRECT THE MOTION OF THE CAR, THE ENGINE SWITCHED OFF. AND BECAUSE THE ENGINE HAD SWITCHED OFF, IT BECAME IMPOSSIBLE TO TURN THE STEERING WHEEL. THE CAR SPUN AROUND AT LEAST 3 COMPLETE ROTATIONS (OF 360 DEGREES) BEFORE SLIDING TO A STOP ON THE SIDE OF THE ROAD. THE GEAR SHIFT WAS STILL IN DRIVE, AND COULD NOT IMMEDIATELY BE CHANGED TO PARK. BUT NATURALLY, THE CAR HAD TO BE RESTARTED, WHICH IT FINALLY DID AFTER MUCH EFFORT. AND THE CAR COULD BE PUT INTO PARK AFTER THE ENGINE HAD RESTARTED. *TR
TL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT WHEN STARTING THE ENGINE, A FUEL ODOR WAS PRESENT INSIDE THE VEHICLE. THE CONTACT DISCOVERED FUEL LEAKING FROM UNDER THE VEHICLE NEAR THE DRIVER'S SIDE DOOR. THE VEHICLE WAS TOWED TO THE DEALER AND DIAGNOSED. THE CONTACT INDICATED THAT THE ENTIRE FUEL LINE SYSTEM WA…
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT WHEN STARTING THE ENGINE, A FUEL ODOR WAS PRESENT INSIDE THE VEHICLE. THE CONTACT DISCOVERED FUEL LEAKING FROM UNDER THE VEHICLE NEAR THE DRIVER'S SIDE DOOR. THE VEHICLE WAS TOWED TO THE DEALER AND DIAGNOSED. THE CONTACT INDICATED THAT THE ENTIRE FUEL LINE SYSTEM WAS REPLACED TO REMEDY THE DEFECT. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 72,000. *TR
FILLED UP THE FUEL TANK AND WHEN I ARRIVED HOME NOTICED A STRONG SMELL OF FUEL. LOOKED UNDER CAR AND NOTICED FUEL LEAK COMING FROM FUEL TANK AREA. THE CAR WAS TAKEN TO THE LOCAL GM DEALER AND THEY ADVISED THE FUEL TANK HAS A 5 INCH CRANK ON THE TOP AREA WHERE THE FUEL NECK HOSE CONNECTS. THIS VEHICLE HAS A PRIOR RECALL FOR FUEL …
Read full complaint
FILLED UP THE FUEL TANK AND WHEN I ARRIVED HOME NOTICED A STRONG SMELL OF FUEL. LOOKED UNDER CAR AND NOTICED FUEL LEAK COMING FROM FUEL TANK AREA. THE CAR WAS TAKEN TO THE LOCAL GM DEALER AND THEY ADVISED THE FUEL TANK HAS A 5 INCH CRANK ON THE TOP AREA WHERE THE FUEL NECK HOSE CONNECTS. THIS VEHICLE HAS A PRIOR RECALL FOR FUEL TANK PARTS THAT CAN CRACK AND LEAK FUEL LEADING TO THE POSSIBILITY OF A FIRE. THE FUEL TANKS SHOULD HAVE BEEN INCLUDED IN THE RECALL SINCE THEY ARE MADE OF PLASTIC AS WELL AND ARE CRACKING. I SPOKE TO THE SERVICEMAN AT THE DEALERSHIP AND HE ADVISED HE HAS SEEN THREE CARS WITH THE SAME CONDITION IN THE SHOP. IS THE NATIONAL HIGHWAY SAFETY TRAFFIC ADMINISTRATION RECEIVING THE SAME COMPLAINT THAT I AM WRITING ABOUT AND ARE YOU DOING ANYTHING TO ADDRESS THIS ISSUE WITH GM? THIS CAR IS DRIVEN BY MY DAUGHTER TO ATTEND COLLEGE AND IT COULD HAVE CAUGHT ON FIRE.... *TR
I WAS JUST DRIVING HOME AN ON THE FREEWAY THE CAR JUST STOPPED, I WAS LUCKY THAT I COULD JUST COAST IN TO A SAFE AREA. AFTER AWHILE I TURNED IT ON AN IT STARTED UP.. THE SAME THING HAPPENED TODAY 2/26/14 I STOPPED AT THE POST OFFICE AND IT WOULD NOT TURN ON I WAITED ABOUT TEN MINUTES AND IT STARTED. IT S…
Read full complaint
I WAS JUST DRIVING HOME AN ON THE FREEWAY THE CAR JUST STOPPED, I WAS LUCKY THAT I COULD JUST COAST IN TO A SAFE AREA. AFTER AWHILE I TURNED IT ON AN IT STARTED UP.. THE SAME THING HAPPENED TODAY 2/26/14 I STOPPED AT THE POST OFFICE AND IT WOULD NOT TURN ON I WAITED ABOUT TEN MINUTES AND IT STARTED. IT SEEMS TO BE THE IGNITION. *TR
HEADLIGHTS STAYING ON AFTER CAR IS TURNED OFF AND KEYS ARE TAKEN OUT. THIS HAS BEEN GOING ON FOR APPROX.A YEAR. NOW THE LIGHTS WILL SHUT COMPLETELY OFF LOWERING THE LIGHT TO OR FROM HIGHBEAM. CAN CAUSE AN ACCIDENT BY RUNNING OFF ROAD IN THE DARK OR CAUSING AN ACCIDENT LEAVING BRIGHT LIGHTS ON IN ON COMING TRAFFIC. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.