IllustrationDT THE HEAD REST DID NOT PROVIDE ANY TYPE OF SUPPORT. VEHICLE WAS INVOLED IN A REAR END CRASH IN FEBRUARY. IT DOES NOT PROVIDE ANY SUPPORT. HAD A CASE OF WHIP LASH. THE CONSUMER CAN RAISE THE HEAD REST UP BUT CAN NOT PULL IT FORWARD. THIS FEBR 14TH, 2005. *AK
2002 Pontiac Bonneville
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bonneville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1525–50K
850–75K
875–100K
7100–150K
4150K+
54 reports with mileage · 35 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports3 injury reports
What owners actually said
89 reportsDEAR SIR OR MADAM, I WAS INVOLVED IN A REAR-END COLLISION IN A 2002 PONTIAC BONNEVILLE AND RECEIVED A CASE OF WHIPLASH, WHICH I BELIEVE WAS DUE TO A POORLY DESIGNED HEAD REST. WHEN I PURCHASED THE CAR I DID NOT CHECK OUT THE HEAD REST AS I DON'T USE HEAD RESTS DURING THE COURSE OF NORMAL DRIVING. IT WAS NOT UNTIL A FEW MONTHS …
Read full complaint
DEAR SIR OR MADAM, I WAS INVOLVED IN A REAR-END COLLISION IN A 2002 PONTIAC BONNEVILLE AND RECEIVED A CASE OF WHIPLASH, WHICH I BELIEVE WAS DUE TO A POORLY DESIGNED HEAD REST. WHEN I PURCHASED THE CAR I DID NOT CHECK OUT THE HEAD REST AS I DON'T USE HEAD RESTS DURING THE COURSE OF NORMAL DRIVING. IT WAS NOT UNTIL A FEW MONTHS LATER THAT I NOTICED I COULD NOT TOUCH THE BACK OF MY HEAD TO THE HEAD REST UNLESS I LEANED SO FAR BACK THAT THERE WAS NO WAY I COULD DRIVE, AND IT WAS VERY UNCOMFORTABLE. THERE ARE NO ADJUSTMENTS TO BRING THE HEAD REST FORWARD ONLY ONE ADJUSTMENT TO RAISE THE HEAD REST HEIGHT. OF COURSE THIS MAKES THE HEAD REST EVEN MORE UNUSABLE BECAUSE THE HIGHER YOU RAISED IT THE FARTHER YOU HAD TO LEAN YOUR HEAD BACK TO MAKE CONTACT WITH THE HEAD REST. I COMMENTED TO MY WIFE THAT IF WE WERE EVER INVOLVED IN A REAR-END COLLISION THESE HEAD RESTS WOULD PROVIDE NO PROTECTION AND OUR HEADS AND NECKS WOULD TAKE THE FULL IMPACT OF THE COLLISION. WOULDN'T YOU KNOW THAT ON FEBRUARY 14, 2005 I WAS HIT FROM BEHIND ON THE WAY TO WORK. THE OTHER DRIVER WAS GOING NO MORE THAN 15 OR 20 MPH, BUT MY HEAD NEVER TOUCHED THE HEAD REST AND I RECEIVED A CASE OF WHIPLASH FAR MORE SERIOUS THAN ONE WOULD PROBABLY EXPERIENCE IF THE HEAD REST HAD ABSORBED SOME OF THE IMPACT INSTEAD OF MY HEAD AND NECK TAKING THE FULL FORCE OF THE COLLISION. THE DAMAGE TO MY CAR WAS ONLY ABOUT $600, SO THE OTHER DRIVER'S INSURANCE COMPANY SAYS MY INJURY COULD NOT BE A SEVERE AS I AM CLAIMING. THEREFORE, THEY ARE ONLY WILLING TO PAY PART OF MY MEDICAL BILL. I WOULD LIKE TO FILE A COMPLAINT AGAINST GENERAL MOTORS AND PONTIAC FOR THE FAULTY DESIGN OF THIS HEAD REST. I NO LONGER OWN THE 2002 PONTIAC BONNEVILLE AS I WAS NOT ABOUT TO KEEP A CAR THAT INJURED ME INSTEAD OF PROTECTING ME DURING A MINOR ACCIDENT. SINCERELY, SHAWN BRENNING. *NM
WHILE DRIVING ABOUT 25 MPH, OVER A SERIES OF SMALL BUMPS, STEERING COLUMN SHAKES AND FEELS LIKE SOMETHING IS GOING TO BREAK IN FRONT END, NO ACCIDENTS OF LOSS OF STEERING, GM HAS REPLACED THE INTERMEDIATE SHAFT 3 TIMES, THEN STRUTS, BUSHINGS AND MOUNTS AND LUBED THEM 2 OR 3 TIMES ALSO
PROBLEMS WITH WINDSHIELD WIPER EQUIPMENT ON 2002 PONTIAC BONNEVILLE.*MR WHILE DRIVING DURING A SNOW STORM THE VEHICLE'S WIPERS BEGAN OPERATING ERRATICALLY AND BY THE END OF THE TRIP THE STOPPED WORKING ALTOGETHER. IT WAS LATER DETERMINED THAT THE WIPER MOTOR HAD FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS BUT THE …
Read full complaint
PROBLEMS WITH WINDSHIELD WIPER EQUIPMENT ON 2002 PONTIAC BONNEVILLE.*MR WHILE DRIVING DURING A SNOW STORM THE VEHICLE'S WIPERS BEGAN OPERATING ERRATICALLY AND BY THE END OF THE TRIP THE STOPPED WORKING ALTOGETHER. IT WAS LATER DETERMINED THAT THE WIPER MOTOR HAD FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS BUT THE DEALER DIDN'T HAVE THE PART AVAILABLE. THE CONSUMER LATER FOUND OUT THAT THIS WAS A COMMON PROBLEM DUE TO MOISTURE SEEPING INTO THE WIPER CONTROL MODULE. *NM
THE CONSUMER LOST STEERING CONTROL WHILE DRIVING AT 45 MPH. THE CONSUMER WAS ABLE TO BRING THE VEHICLE UNDER CONTROL WITHOUT BEING INVOLVED IN A VEHICLE CRASH. THE VEHICLE WAS TOWED TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE HIGH PRESSURE HOSE FOR THE POWER STEERING ASSIST ERUPTED. THE CONSUMER WAS CONCERNED SINCE A SI…
Read full complaint
THE CONSUMER LOST STEERING CONTROL WHILE DRIVING AT 45 MPH. THE CONSUMER WAS ABLE TO BRING THE VEHICLE UNDER CONTROL WITHOUT BEING INVOLVED IN A VEHICLE CRASH. THE VEHICLE WAS TOWED TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE HIGH PRESSURE HOSE FOR THE POWER STEERING ASSIST ERUPTED. THE CONSUMER WAS CONCERNED SINCE A SIMILAR INCIDENT OCCURRED BEFORE. *AK THE INTERMEDIATE STEERING SHAFT WAS REPLACED, BOTH FRONT WINDOW LIFT MOTORS WERE REPLACED, WATER LEAKED IN THE FRONT PASSENGER DOOR, THERE WAS AN EXTREME AMOUNT OF ENGINE NOISE AS WELL AS HEAT AND EXHAUST ENTERING THE PASSENGER COMPARTMENT, THERE WAS TWO INCHES OF PLAY IN THE STEERING WHEEL, THE STEERING LOCKED UP, THERE WAS A LACK OF POWER STEERING FLUID IN THE RESERVOIR, HIGH PRESSURE HOSE FLUID LEAKED ALL OVER THE UNDERSIDE OF THE VEHICLE AND THROUGHOUT THE ENGINE, THE UPPER NUT AND THE BOLT THAT HELD THE INTERMEDIATE STEERING SHAFT TO THE STEERING WHEEL ASSEMBLY WAS EXTREMELY LOOSE. *SC
[1]CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING NEUVER/STEERING WHEEL ROTATION; [2]SAME AS #1; [3]STEERING COLUMN REPLACED [OLD PART IS NOT AVAILABLE. *AK
THE POWER WINDOWS FAILED WITHOUT WARNING. AS A RESULT, THE CONSUMER HAD TO WIRE THE WINDOW IN ORDER FOR THE WINDOW TO STAY SHUT. THE DEALER STATED THE PARTS WERE ON NATIONAL BACK ORDER. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
CLUNK SOUND COMING FROM THE TURNING OF THE STEERING WHEEL DURING COURSE OF DRIVING. *AK
BOTH REAR SEAT BUCKLES BROKE, AND LEFT THE REAR OCCUPANTS WITHOUT ANY RESTRAINT WHILE DRIVING OR IF BECOMING INVOLVE IN A CRASH. DEALER WAS NOTIFIED.*AK
2002 PONTIAC,STEERING ASSEMBLY CLUNKING NOISE. *BF THE DEALER HAS A KIT THAT CAN BE INSTALL TO ALLEVIATE THE CLUNKING NOISE BUT THE CONSUMER FEELS THE PROBLEM SHOULD BE RECALLED. *NM
Official recalls
203V238000 · Fuel System, Gasoline:storage:tank Assembly
Jul 1, 2003
ON CERTAIN CADILLAC DEVILLE AND SEVILLE PASSENGER VEHICLES, FUNERAL COACHES, AND LIMOUSINES EQUIPPED WITH A V8 (4.6L) ENGINE, OLDSMOBILE AURORA PASSENGER VEHICLES EQUIPPED WITH A V8 (4.0L ) ENGINE, AND PONTIAC BONNEVILLE SSEI PASSENGER VEHICLES EQUIPPED WITH A SUPERCHARGED V6 (3.8L) ENGINE, THE FUEL TANK PRESSURE SENSORS ARE UNUSUALLY SUSCEPTIBLE TO MALFUNCTIONS. IF THE SENSOR MALFUNCTIONS, EXCESSIVE VACUUM CAN BE APPLIED DURING SELF-DIAGNOSTIC TESTING.
Consequence & remedy
Consequence: FUEL SYSTEM COMPONENTS CAN BE DAMAGED AND FUEL CAN LEAK FROM THE VEHICLE WHEN IT IS REFUELED. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK PRESSURE SENSOR. OWNER NOTIFICATION BEGAN ON OCTOBER 17, 2003. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.