IllustrationLATE MARCH 2007 REAR DRIVER WINDOW WOULD NOT WORK. ELECTRIC MOTOR CABLE TWISTED. COST $400. AT THIS TIME BACK PASSENGER WINDOW WILL NOT WORK. FELL OFF TRACK , POSSIBLE MOTOR CABLE PROBLEM . FRONT PASSENGER WINDOW WILL NOT WORK. FROZE IN POSITION. *AK
2002 Pontiac Bonneville
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bonneville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1525–50K
850–75K
875–100K
7100–150K
4150K+
54 reports with mileage · 35 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports3 injury reports
What owners actually said
89 reportsWINDOW ON 2002 PONTIAC BONNEVILLE FALL DOWN , WHEN PROBLEM WAS LOCATED THE WINDOW REGULATOR GUIDE WIRE WAS TWISTED. REGULATOR WAS REPLACED AND THE WIRE TWISTED ON IT ALSO. CAR SEAMS TO HAVE ELECTRICAL PROBLEMS, SEAT WARMERS WILL NOT TURN ON WHEN TURNED ON. WINDOWS ALSO WILL NOT LET DOWN AT TIMES. *JB
TL*THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE DEALER HAS REPLACED THE FUSES FOR THE TRUNK AND INNER DOME LIGHTS FIVE TIMES, AND THREE TIMES BY THE OWNER. THE FUSES FOR THE TAIL LIGHTS WERE REPLACED TWICE. THE TRUNK AJAR INDICATOR LIGHT ILLUMINATED WHEN THE TRUNK WAS CLOSED. THE DEALER STATED TH…
Read full complaint
TL*THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE DEALER HAS REPLACED THE FUSES FOR THE TRUNK AND INNER DOME LIGHTS FIVE TIMES, AND THREE TIMES BY THE OWNER. THE FUSES FOR THE TAIL LIGHTS WERE REPLACED TWICE. THE TRUNK AJAR INDICATOR LIGHT ILLUMINATED WHEN THE TRUNK WAS CLOSED. THE DEALER STATED THAT THERE WAS A SHORT IN THE ELECTRIC SYSTEM, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 78,000, AND FAILURE MILEAGE WAS 76,560. *AK
THE TIP OF A SPARK PLUG BROKE OFF INTO THE PISTON CAUSING ME TO HAVE TO REPLACE THE ENGINE. GM HAS REFUSED TO REIMBURSE ME FOR MY REPLACEMENT ENGINE. *JB
COOLANT LEAKING FROM THE PLENIUM GASKET, CRACKED MANIFOLD. *AK
AFTER STARTING MY PONTIAC BONNEVILLE 2002 THE 'AIR BAG' LIGHT LIT AND STAYED ON. DRIVING NORMALLY DOWN THE HIGHWAY AT NORMAL SPEEDS, SUDDENLY THE PASSENGER SIDE AIR BAG DEPLOYED WITH NO WARNING. CAR CONTINUED TO OPERATE NORMALLY. DEALER HAS NEVER ENCOUNTERED SUCH A PROBLEM WHERE AIR BAG WOULD SUDDENLY DEPLOY UNDER NORMAL DRIV…
Read full complaint
AFTER STARTING MY PONTIAC BONNEVILLE 2002 THE 'AIR BAG' LIGHT LIT AND STAYED ON. DRIVING NORMALLY DOWN THE HIGHWAY AT NORMAL SPEEDS, SUDDENLY THE PASSENGER SIDE AIR BAG DEPLOYED WITH NO WARNING. CAR CONTINUED TO OPERATE NORMALLY. DEALER HAS NEVER ENCOUNTERED SUCH A PROBLEM WHERE AIR BAG WOULD SUDDENLY DEPLOY UNDER NORMAL DRIVING CONDITIONS. LONG PONTIAC OF FRAMINGHAM, MA REPLACED THE SDM MODULES AND AIR BAG.
HEARD A CLUNKING NOISE IN THE STEERING 9/02. THE PONTIAC SERVICE DEPARTMENT CLEANED AND LUBED THE INTERMEDIATE SHAFT. THE SAME CLUNKING NOISE CAME BACK IN MARCH 2005 THIS TIME THE PONTIAC SERVICE DEPARTMENT SAID THE INTERMEDIATE SHAFT WAS WORN AND NOISY. THEY REPLACE THE INTERMEDIATE SHAFT UNDER GOODWILL, BUT I HAD TO PAY $181.…
Read full complaint
HEARD A CLUNKING NOISE IN THE STEERING 9/02. THE PONTIAC SERVICE DEPARTMENT CLEANED AND LUBED THE INTERMEDIATE SHAFT. THE SAME CLUNKING NOISE CAME BACK IN MARCH 2005 THIS TIME THE PONTIAC SERVICE DEPARTMENT SAID THE INTERMEDIATE SHAFT WAS WORN AND NOISY. THEY REPLACE THE INTERMEDIATE SHAFT UNDER GOODWILL, BUT I HAD TO PAY $181.86 FOR LABOR. NOW JANUARY 2007 THE SAME CLUNKING NOISE IS BACK. I ALSO HAVE A 2003 GMC PICKUP THAT IS DOING THE SAME THING. I WOULD LIKE TO SEE A RECALL ON GM INTERMEDIATE SHAFT. I BELIEVE THAT THIS IS A SAFETY CONCERN BECAUSE THE PONTIAC SERVICE DEPARTMENT PAPER WORK SAID "DIAGNOSTICS REVEALED STEERING INTERMEDIATE SHAFT JOINT WORN CAUSING NOISE HEARD". *NM
TL*- THE CONTACT STATED THAT HIS 2002 PONTIAC BONNEVILLE IS EXHIBITING THE SAME FAILURE WITH HIS STEERING COLUMN WHICH HE PREVIOUSLY REPAIRED WHEN THE VEHICLE HAD AN ODOMETER READING OF 35,398 MILES. THE CONTACT STATED THAT HIS STEERING COLUMN FEELS LOOSE, AND DOES NOT RESPOND READILY TO CHANGES IN DIRECTION. HE DID TAKE HIS VE…
Read full complaint
TL*- THE CONTACT STATED THAT HIS 2002 PONTIAC BONNEVILLE IS EXHIBITING THE SAME FAILURE WITH HIS STEERING COLUMN WHICH HE PREVIOUSLY REPAIRED WHEN THE VEHICLE HAD AN ODOMETER READING OF 35,398 MILES. THE CONTACT STATED THAT HIS STEERING COLUMN FEELS LOOSE, AND DOES NOT RESPOND READILY TO CHANGES IN DIRECTION. HE DID TAKE HIS VEHICLE TO DEALERSHIP AND WAS TOLD THAT THIS IS NORMAL WEAR AND TEAR ON THIS VEHICLE. THE CONTACT HAS FOUND SEVERAL COMPLAINTS ON THE NHTSA WEBSITE FOR THE SAME REASONS. THE CONTACT GAVE SEVERAL COMPLAINT # 1009722 AND 10157566. THE CONTACT FEELS THIS IS A SAFETY ISSUE AND IS AFRAID THE STEERING COLUMN WILL SEPARATE WHILE DRIVING. THE CONTACT STATED HE DID FILE A COMPLAINT WITH THE MANUFACTURE AND GAVE THEM A FILE # 71-467055915 WITH DATE OF FILING 01/10/07. THE DEALERSHIP STATED THAT THE STEERING COLUMN HAS BEEN A REDESIGNED INTERMEDIATE AND A REPLACEMENT THAT WOULD COST THE CONTACT $ 274.00. *NM
TL*- THE CONTACT STATES THAT THE ENGINE COOLANT IS LEAKING AT THE UPPER INTAKE MANIFOLD. THE CONTACT STATES THAT THERE WAS A SAFETY CAMPAIGN REGARDING THE SAME ISSUE HE HAS WITH HIS VEHICLE AND THAT HE WASN'T AWARE ABOUT THE ISSUE UNTIL HE WAS DOING RESEARCH ONLINE. BY THE TIME THE CONTACT FOUND OUT ABOUT THE SAFETY CAMPAIGN …
Read full complaint
TL*- THE CONTACT STATES THAT THE ENGINE COOLANT IS LEAKING AT THE UPPER INTAKE MANIFOLD. THE CONTACT STATES THAT THERE WAS A SAFETY CAMPAIGN REGARDING THE SAME ISSUE HE HAS WITH HIS VEHICLE AND THAT HE WASN'T AWARE ABOUT THE ISSUE UNTIL HE WAS DOING RESEARCH ONLINE. BY THE TIME THE CONTACT FOUND OUT ABOUT THE SAFETY CAMPAIGN THE TIME FOR THE CAMPAIGN HAD EXPIRED. THE CONTACT IS CONCERNED BECAUSE WHEN HE TOOK IT TO THE DEALERSHIP AND THEY STATED THAT THE PROBLEM WITH HIS VEHICLE IS A COMMON PROBLEM THAT HAS BEEN HAPPENING WITH VARIOUS 2002 PONTIAC BONNEVILLE.
I HAVE OWNED A 2000 PONTIAC GRAND PRIX AND A 2002 PONTIAC BONNEVILLE. THE WINDOW MOTOR ON BOTH VEHICLES SEEM DEFECTIVE. ON MY GRAND PRIX, 3 OF THE FOUR WINDOW MOTORS STOPPED WORKING. ON MY BONNEVILLE, ALL 4 WINDOW MOTORS STOPPED. THE WINDOW WOULD NOT MOVE UP OR DOWN. VERY OFTEN IT HAS BEEN STUCK DOWN (WINDOW OPEN) AND I COU…
Read full complaint
I HAVE OWNED A 2000 PONTIAC GRAND PRIX AND A 2002 PONTIAC BONNEVILLE. THE WINDOW MOTOR ON BOTH VEHICLES SEEM DEFECTIVE. ON MY GRAND PRIX, 3 OF THE FOUR WINDOW MOTORS STOPPED WORKING. ON MY BONNEVILLE, ALL 4 WINDOW MOTORS STOPPED. THE WINDOW WOULD NOT MOVE UP OR DOWN. VERY OFTEN IT HAS BEEN STUCK DOWN (WINDOW OPEN) AND I COULD NOT "ROLL" IT BACK UP. EACH TIME I GOT IT FIXED, THEY SAID IT WAS THE MOTOR. I HAVE DISCUSSED THIS PROBLEM WITH OTHER PONTIAC OWNERS AND THEY HAVE ALL EXPERIENCED. 8JB
Official recalls
203V238000 · Fuel System, Gasoline:storage:tank Assembly
Jul 1, 2003
ON CERTAIN CADILLAC DEVILLE AND SEVILLE PASSENGER VEHICLES, FUNERAL COACHES, AND LIMOUSINES EQUIPPED WITH A V8 (4.6L) ENGINE, OLDSMOBILE AURORA PASSENGER VEHICLES EQUIPPED WITH A V8 (4.0L ) ENGINE, AND PONTIAC BONNEVILLE SSEI PASSENGER VEHICLES EQUIPPED WITH A SUPERCHARGED V6 (3.8L) ENGINE, THE FUEL TANK PRESSURE SENSORS ARE UNUSUALLY SUSCEPTIBLE TO MALFUNCTIONS. IF THE SENSOR MALFUNCTIONS, EXCESSIVE VACUUM CAN BE APPLIED DURING SELF-DIAGNOSTIC TESTING.
Consequence & remedy
Consequence: FUEL SYSTEM COMPONENTS CAN BE DAMAGED AND FUEL CAN LEAK FROM THE VEHICLE WHEN IT IS REFUELED. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK PRESSURE SENSOR. OWNER NOTIFICATION BEGAN ON OCTOBER 17, 2003. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.