NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
22 reportsClear category filter136,000 miles · Feb 14, 2014
Electrical SystemEngine And Engine CoolingFire
WE HAD A LOT OF SNOW AND I LIVE ON A SLIGHT HILL. WENT TO START THE CAR THAT WAS COVERED IN SNOW TO MOVE THE CAR ON THE OTHER SIDE OF THE STREET FACING DOWN HILL. I TURNED THE KEY TO START THE CAR AND HEARD IT POP OR BACKFIRE WHICH IT HAD NEVER DONE BEFORE. I TRIED AGAIN TO START THE CAR AND NOW IT SOUNDED LIKE THE BATTERY WAS…
Read full complaint
WE HAD A LOT OF SNOW AND I LIVE ON A SLIGHT HILL. WENT TO START THE CAR THAT WAS COVERED IN SNOW TO MOVE THE CAR ON THE OTHER SIDE OF THE STREET FACING DOWN HILL. I TURNED THE KEY TO START THE CAR AND HEARD IT POP OR BACKFIRE WHICH IT HAD NEVER DONE BEFORE. I TRIED AGAIN TO START THE CAR AND NOW IT SOUNDED LIKE THE BATTERY WAS DEAD (WHICH I KNEW IT COULD NOT HAVE BEEN). THE NEXT THING I KNEW, A NEIGHBOR RIPPED OPEN MY DRIVER DOOR AND WAS PULLING ME OUT OF THE CAR SAYING "YOUR CAR IS ON FIRE". MY NEIGHBORS CALLED 911 FOR THE FIRE DEPARTMENT WHO CAME AND PUT THE FIRE OUT BUT THE CAR WAS TOTALED! I AM FORTUNATE THAT THE NEIGHBORS HEARD THE POP, CAME OUTSIDE, SAW THE FLAMES UNDER THE CAR, AND I WAS NOT HURT. THIS HAPPENED WITH THE CAR PARKED RIGHT IN FRONT OF MY HOUSE! STILL UNBELIEVABLE AND VERY FRIGHTENING! *TR
NHTSA ODI #10564372
166,000 miles · Dec 3, 2013
Engine And Engine Cooling
WHEN I DRIVE MY CAR IT SHUTS DOWN ON ME WHILE DRIVING AND I HAVE TO WAIT AT LEAST 20 MINS BEFORE IT STARTS BACK UP AND SOMETIMES IT SMELLS LIKE SOMETHING IS BURNING. *TR
NHTSA ODI #10554700
197,313 miles · Oct 29, 2011
Electrical SystemEngine And Engine CoolingFireInjury
ON OCTOBER 27,2011 I CAME ON FROM WORK AROUND 7:00 PM TURN MY CAR OF AND WENT INTO THE HOUSE. I HEARD SOME ONE BAMMING ON THE BACK DOOR , I OPEN THE DOOR AND A GUY SAID THAT YOUR CAR IS ON FIRE HE ASKED IF I HAD ANY ON ELSE IN THE HOUSE I TOLD HIM YES SO I GO INSIDE TO GET MY CHILDREN OUT THE HOUSE. THAT IS WHEN I SAW THE SAM…
Read full complaint
ON OCTOBER 27,2011 I CAME ON FROM WORK AROUND 7:00 PM TURN MY CAR OF AND WENT INTO THE HOUSE. I HEARD SOME ONE BAMMING ON THE BACK DOOR , I OPEN THE DOOR AND A GUY SAID THAT YOUR CAR IS ON FIRE HE ASKED IF I HAD ANY ON ELSE IN THE HOUSE I TOLD HIM YES SO I GO INSIDE TO GET MY CHILDREN OUT THE HOUSE. THAT IS WHEN I SAW THE SAME GUY WHO WAS KNOCK ON THE DOOR USE MY HOSE PIPE SPRAYING WATER ON THE CAR. AT THAT TIME I CALLED THE SHERIFF'S DEPARTMENT THEY ADVISE ME THAT THE PLAQUEMINE FIRE DEPARTMENT WAS ON THERE WAY. THE FIRE DEPARTMENT PUT THE REST OF THE FIRE OUT. ONE OF THE FIRE FIGHTER TOLD ME THAT IT WAS AN ELECTRICAL FIRE. *TR
NHTSA ODI #10433516
120,000 miles · May 16, 2010
Engine And Engine CoolingFire
BATTERY DEAD, CHARGED THE CAR, STARTED IT UP...THE ENGINE CAUGHT FIRE(PLENUM). INS AGENT SAID IT WAS THE PLENUM AND THAT IT IS A COMMON PROBLEM WITH THESE VEHICLES. GM IS LUCKY NO ONE WAS HURT!!!! *TR
NHTSA ODI #10330629
93,767 miles · Jun 18, 2009
Engine And Engine CoolingVisibility
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT NOTICED COOLANT LEAKING UNDERNEATH THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE INTAKE GASKET, VALVE COVER GASKET, OIL PAN, AND SEVERAL PIPING COMPONENTS AT THE COST OF $1,400. THE REPAIRS WERE MADE AT THE CONTACT'S EXPENSE; HOWEVE…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT NOTICED COOLANT LEAKING UNDERNEATH THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE INTAKE GASKET, VALVE COVER GASKET, OIL PAN, AND SEVERAL PIPING COMPONENTS AT THE COST OF $1,400. THE REPAIRS WERE MADE AT THE CONTACT'S EXPENSE; HOWEVER, THE VEHICLE CONTINUED TO LEAK COOLANT. THE DEALER STATED THAT THE CONTACT SHOULD NOT BE CONCERNED. THE CONTACT LATER TOOK THE VEHICLE TO A DIFFERENT DEALER AND THEY FOUND THAT A COOLANT ELBOW PIPE HAD BEEN KNOCKED OUT OF PLACE, WHICH CAUSED THE LEAK. THE NECESSARY REPAIRS WERE MADE TO THE VEHICLE FOR THE SECOND TIME AT THE COST OF $10, DUE TO THE FAILURE OF THE INITIAL DEALER. THE FAILURE MILEAGE WAS 93,767 AND CURRENT MILEAGE WAS LESS THAN 105,000. UPDATED 07/08/09 *BF THE FRONT PASSENGER ELECTRIC WINDOW MOTOR FAILED AND NEEDS TO BE REPLACED FOR A SECOND TIME. UPDATED 07/08/09.*JB
NHTSA ODI #10274226
81,821 miles · May 12, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT SMELLED SOMETHING SIMILAR TO THAT OF AN ELECTRICAL FIRE COMING FROM THE VEHICLE. A LEAKING VALVE COVER GASKET WAS REPLACED AND THE CONTACT REALIZED THAT THERE WAS A RECALL ON 3.8 V6 GM ENGINES. AT THE TIME, NHTSA CAMPAIGN ID NUMBER 09V116000 ONLY APPLIED TO PONTIAC GR…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT SMELLED SOMETHING SIMILAR TO THAT OF AN ELECTRICAL FIRE COMING FROM THE VEHICLE. A LEAKING VALVE COVER GASKET WAS REPLACED AND THE CONTACT REALIZED THAT THERE WAS A RECALL ON 3.8 V6 GM ENGINES. AT THE TIME, NHTSA CAMPAIGN ID NUMBER 09V116000 ONLY APPLIED TO PONTIAC GRAND PRIX'S, NOT BONNEVILLES. THE CONTACT WANTS THE MANUFACTURER TO PAY FOR THE REPAIR COST SINCE THE FAILURES WERE IDENTICAL. SHE FEELS THAT IT IS A MAJOR SAFETY ISSUE. THE CURRENT MILEAGE WAS 83,000 AND FAILURE MILEAGE WAS 81,821. UPDATED 05/19/09 *BF UPDATED 05/20/09.*JB
NHTSA ODI #10268505
120,000 miles · Apr 20, 2009
Engine And Engine CoolingFuel System, Gasoline
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT HER VEHICLE WOULD NOT START AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, SHE SMELLED A STRONG ODOR OF GASOLINE COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, SHE NOTICED THAT THE INTAKE MANIFOLD WAS RUPTURED. THE M…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT HER VEHICLE WOULD NOT START AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, SHE SMELLED A STRONG ODOR OF GASOLINE COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, SHE NOTICED THAT THE INTAKE MANIFOLD WAS RUPTURED. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIRS BECAUSE THE VIN WAS EXLCUDED FROM NHTSA CAMPAIGN ID NUMBER 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 120,000. UPDATED 5/7/09 *CN UPDATED 05/08/09.*JB
NHTSA ODI #10266049
141,000 miles · Jan 20, 2009
Engine And Engine CoolingFire
DROVE VEHICLE FOR 25 MILES FROM WORK TO DAY-CARE FACILITY TO PICK UP MY DAUGHTER. DROVE UNDER VARIOUS SPEEDS. PARKED CAR AND WENT INTO PICK UP DAUGHTER CAME BACK OUT AND SMOKE WAS COMING FROM BENEATH THE HOOD. OPENED THE HOOD AND THERE WAS A FIRE NEAR THE EXHAUST MANIFOLD AND VALVE COVER AREA. FIRE WAS SPREADING TO PLUG WIR…
Read full complaint
DROVE VEHICLE FOR 25 MILES FROM WORK TO DAY-CARE FACILITY TO PICK UP MY DAUGHTER. DROVE UNDER VARIOUS SPEEDS. PARKED CAR AND WENT INTO PICK UP DAUGHTER CAME BACK OUT AND SMOKE WAS COMING FROM BENEATH THE HOOD. OPENED THE HOOD AND THERE WAS A FIRE NEAR THE EXHAUST MANIFOLD AND VALVE COVER AREA. FIRE WAS SPREADING TO PLUG WIRES, PLASTIC ENGINE COVER AND THE WIRING HARNESS NEAR THE THROTTLE BODY. *TR
NHTSA ODI #10255720
Mileage unknown · Oct 9, 2008
Engine And Engine Cooling
2001 BONNEVILLE SSEI 3.8L SUPERCHARGED V-6 ENGINE IDENTICAL TO ENGINES IN RECALL NUMBER EA07008. STRONG BURNING SMELL. VALVE COVER GASKET, OIL PAN GASKET, INTAKE MANIFOLD GASKET ALL LEAKING! OIL IS LEAKING INTO AND CONTAMINATING ENGINE COOLING SYSTEM! WHY ISN'T THIS MODEL INCLUDED IN EA07008 RECALL? YOUR WEBSITE DOESN'T EVEN LIS…
Read full complaint
2001 BONNEVILLE SSEI 3.8L SUPERCHARGED V-6 ENGINE IDENTICAL TO ENGINES IN RECALL NUMBER EA07008. STRONG BURNING SMELL. VALVE COVER GASKET, OIL PAN GASKET, INTAKE MANIFOLD GASKET ALL LEAKING! OIL IS LEAKING INTO AND CONTAMINATING ENGINE COOLING SYSTEM! WHY ISN'T THIS MODEL INCLUDED IN EA07008 RECALL? YOUR WEBSITE DOESN'T EVEN LIST BONNEVILLES FOR 2001. PLEASE INVESTIGATE AND RESPOND!!! *TR
NHTSA ODI #10244963
100,000 miles · Mar 15, 2008
Engine And Engine Cooling
REF NHTSA INVESTIGATION EA07008, WHY DOESN'T IT INCLUDE 2001 BONNEVILLE SSEI ,I DO HAVE THE SAME PROBLEM AS THE GRAND PRIX AND THE REGAL GS. *TR
NHTSA ODI #10221264
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration