IllustrationCONSUMER RECEIVED NHTSA RECALL 04V090000 REGARDING FUEL PRESSURE REGULATOR FAILURE. AFTER HAVING THE FUEL PRESSURE REGULATOR REPLACED VEHICLE FAILED TO START. ALSO, WHILE DRIVING VEHICLE STALLED. *AK
1998 Pontiac Bonneville
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bonneville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1325–50K
5050–75K
2975–100K
18100–150K
3150K+
117 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 194 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports28 fire reports6 injury reports
Fuel System, Other complaints
3 reportsHAD TUNE-UP AND REGULATORS CHANGED (BASED ON RECALL) ON 7/19/04. THEN ON 7/22/04 SMOKE EMITTING FROM EXHAUST AND THEN CAR WOULD NOT START. CAR TOWED AND REPAIRED (MANIFOLD CRACKED). ON 7/26/04 CAR TAKEN FROM SHOP, 2 HRS LATER CAR WOULD NOT START AGAIN. THIS TIME CLAIMED STARTER WAS THE PROBLEM. CONSEQUENCES: OVER $1,500 IN REPA…
Read full complaint
HAD TUNE-UP AND REGULATORS CHANGED (BASED ON RECALL) ON 7/19/04. THEN ON 7/22/04 SMOKE EMITTING FROM EXHAUST AND THEN CAR WOULD NOT START. CAR TOWED AND REPAIRED (MANIFOLD CRACKED). ON 7/26/04 CAR TAKEN FROM SHOP, 2 HRS LATER CAR WOULD NOT START AGAIN. THIS TIME CLAIMED STARTER WAS THE PROBLEM. CONSEQUENCES: OVER $1,500 IN REPAIRS.
VEHICLE WAS OPERATING UNDER NORMAL CONDITIONS, VEHICLE WAS PURCHASED USED. TWO BLOCKS FROM MY DESTINATION, THE CAR WAS RUNNING ROUGH, ALMOST LIKE IT WAS SPUTTERING. I PARKED THE CAR IN THE HOPES IT WOULD START,THE BACKFIRE THAT I NEVER HEARD, NOT ONLY BROKE THE NOSE OFF THE STARTER, BLEW A HOLE IN THE INTAKE MANIFOLD AND FILLED…
Read full complaint
VEHICLE WAS OPERATING UNDER NORMAL CONDITIONS, VEHICLE WAS PURCHASED USED. TWO BLOCKS FROM MY DESTINATION, THE CAR WAS RUNNING ROUGH, ALMOST LIKE IT WAS SPUTTERING. I PARKED THE CAR IN THE HOPES IT WOULD START,THE BACKFIRE THAT I NEVER HEARD, NOT ONLY BROKE THE NOSE OFF THE STARTER, BLEW A HOLE IN THE INTAKE MANIFOLD AND FILLED THE ENGINE WITH ANTIFREEZE. LUCKILY FOR ME I HAD SHUT THE CAR OFF BEFORE ANY MAJOR DAMAGE HAD BEEN DONE TO THE ENGINE. I HAD THE CAR TOWED BACK TO THE DEALER I HAD PURCHASED THE VEHICLE FROM. MONDAY CAME AND I THEN WENT TO THE DEALER TO HAVE THEM FIX THIS VEHICLE I HAD JUST PURCHASED ONLY 3 MONTHS PRIOR, THEY LOOKED AT IT AND GAVE ME A $700 ESTIMATE, KNOWING FULL WELL THAT THIS IS A DEFECT WITH THE VEHICLE, BUT WOULD NOT PROVIDE ME WITH TEMPORARY TRANSPORTATION WHILE WAITING FOR THE REPARS TO BE DONE. I ASKED THAT THEY PUT THE OLD PARTS THAT HAD BEEN REPLACED INTO THE TRUNK FOR FURTHER INVESTIGATION BY ME. HAVE DONE RESEARCH ON THIS ON THE INTERNET ONLY TO FIND THIS A MORE COMMON PROBLEM WITH THIS VEHICLE THAN HAD BEEN IMAGINED. WHY MUST SOMEONE DIE BEFORE SOMETHING IS DONE ABOUT THIS DEFECT WITH THIS VEHICLE???*AK
Official recalls
104V090000 · Fuel System, Gasoline:delivery
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.