Electrical SystemEngine And Engine CoolingFuel/propulsion SystemFire
TL* THE CONTACT OWNS A 1996 PONTIAC BONNEVILLE. THE CONTACT STATED THAT SEVERAL ATTEMPTS HAD TO BE MADE BEFORE SUCCEEDING IN STARTING VEHICLE. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE THE FAILURE WAS LOCATED AT THE INTAKE MANIFOLD AND OXYGEN SENSOR. THE INTAKE MANIFOLD CAP WAS MELTING AND CAUSING OIL TO SPILL. IN ADDITION, THE …
Read full complaint
TL* THE CONTACT OWNS A 1996 PONTIAC BONNEVILLE. THE CONTACT STATED THAT SEVERAL ATTEMPTS HAD TO BE MADE BEFORE SUCCEEDING IN STARTING VEHICLE. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE THE FAILURE WAS LOCATED AT THE INTAKE MANIFOLD AND OXYGEN SENSOR. THE INTAKE MANIFOLD CAP WAS MELTING AND CAUSING OIL TO SPILL. IN ADDITION, THE FAILURE WAS PRODUCING WHITE SMOKE FROM THE TAILPIPE EXHAUST. THE VEHICLE WAS REPAIRED BUT THE CONTACT WAS UNSURE AS TO THE EXACT REPAIRS MADE TO THE VEHICLE. THE CONTACT ALSO STATED THAT THE ANTI-THEFT SYSTEM FAILED AND WOULD ALERT THE CONTACT THAT THE DOORS WERE OPENED, AND THE SEAT BELTS WERE NOT SECURED ERRONEOUSLY. THE FUEL INJECTION SYSTEM WAS ALSO DEFECTIVE AND WAS REPAIRED BY REPLACING THE FUEL INJECTOR, AND ADDING FUEL CLEANER. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBERS: 96V116000 (FUEL SYSTEM, GASOLINE: FUEL INJECTION SYSTEM) AND 95V204000 (ELECTRICAL SYSTEM: IGNITION: ANTI-THEFT CONTROLLER) HOWEVER, THE CONTACT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN EITHER RECALL CAMPAIGN. THE CURRENT MILEAGE WAS 158,000. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10463433
55,000 miles · May 15, 2012
Electrical SystemEngine And Engine CoolingFuel/propulsion System
THIS CAR BELONGS TO MY ELDERLY MOTHER WHICH SHE BOUGHT USED AND HAS BEEN AN ON GOING PROBLEM! OCCASIONALLY WHEN STARTING THE CAR, THE ENGINE WILL BACKFIRE, AFTER STARTING IT WOULD RUN OK. THE CAR NOW DOES NOT RUN AS THE INTAKE MANIFOLD IS BROKEN FROM THE BACKFIRING AND ALMOST CAUGHT ON FIRE THE LAST TIME IT WAS ATTEMPTED TO STAR…
Read full complaint
THIS CAR BELONGS TO MY ELDERLY MOTHER WHICH SHE BOUGHT USED AND HAS BEEN AN ON GOING PROBLEM! OCCASIONALLY WHEN STARTING THE CAR, THE ENGINE WILL BACKFIRE, AFTER STARTING IT WOULD RUN OK. THE CAR NOW DOES NOT RUN AS THE INTAKE MANIFOLD IS BROKEN FROM THE BACKFIRING AND ALMOST CAUGHT ON FIRE THE LAST TIME IT WAS ATTEMPTED TO START THE MOTOR! ACCORDING TO PONTIAC THERE IS NO RECALL ON THIS CAR BY THE VIN NUMBER!! *JS
A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION" AND FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." IN ADDITION, OTHER CHIME REMINDER FUNCTIONS, INTERIOR LIGHTING CONTROLS, AND POWER DOOR LOCKING FEATURES ARE ALSO AFFECTED.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
1996 Pontiac Bonneville Problems, Complaints & Recalls | Skip That Year
Illustration