IllustrationI HAVE A 2001 AZTEC PONTIAC. DURING A ROUTINE VISIT IN A CAR SHOP, THEY TOLD ME MY CAR HAS AN INTAKE GASKET LEAK AND THEY CANNOT REPAIR IT. THEY SUGGESTED ME TO SEE GM IN DIRECT AND FIND A DEAL WITH THEM. HOW CAN IT BE POSSIBLE SINCE MY CAR HAS ONLY 60,000 MILES ?*JB
2001 Pontiac Aztek
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Pontiac Aztek do not stand out strongly from the model-year median of 121.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aztek years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
2625–50K
3250–75K
2375–100K
16100–150K
7150K+
120 reports with mileage · 96 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports6 fire reports15 injury reports
Engine And Engine Cooling complaints
28 reportsBOUGHT 2001 AZTEC BECAUSE I HAD ALWAYS LIKED THE DESIGN. HAD CAR FOR FOUR MONTHS AND BRAKES WERE SQUEALING. TOOK BACK TO DEALERSHIP AND WAS TOLD THEY NEEDED CLEANING. DIDN'T HELP. TOOK BACK AND THEN THEY WANTED TO REPLACE THE PADS,WHICH THEY SAID WEREN'T ORIGINAL GM PADS(EVEN THOUGH THEY WERE INSPECTED BEFORE I BOUGHT IT) AND I …
Read full complaint
BOUGHT 2001 AZTEC BECAUSE I HAD ALWAYS LIKED THE DESIGN. HAD CAR FOR FOUR MONTHS AND BRAKES WERE SQUEALING. TOOK BACK TO DEALERSHIP AND WAS TOLD THEY NEEDED CLEANING. DIDN'T HELP. TOOK BACK AND THEN THEY WANTED TO REPLACE THE PADS,WHICH THEY SAID WEREN'T ORIGINAL GM PADS(EVEN THOUGH THEY WERE INSPECTED BEFORE I BOUGHT IT) AND I WOULD HAVE TO PAY BECAUSE THAT WASN'T COVERED BY WARRANTY. TOOK IT 2 SERVICE CENTER OUTSIDE OF DEALERSHIP AND BRAKE PADS WERE FINE JUST EMITTED A LOT OF BRAKE DUST THEY BOTH SAID. HEAD LIGHTS SOMEWHAT FLICKER WHEN DRIVING. DUAL CLIMATE CONTROL PASSENGER SIDE LIGHT ON TEMP WENT OUT. ON TAILLIGHTS THE FINISH IS COMING OFF(A COMMON PROBLEM FOR THESE VEHICLES BEING CHEAP GRADE PLASTIC). THE DRIVER SIDE WINDOW BUTTON SOMETIMES DOESN'T WORK AND THE ENTIRE UNIT FELL THROUGH AND HAD TO GET INSIDE OF DOOR TO PUSH IT BACK THROUGH TO GET WINDOW UP BECAUSE IT WAS RAINING(ANOTHER PROBLEM A LOT OF PEOPLE HAVE).IT SEEMS THESE VEHICLES HAVE DEFECTIVE GAS GAUGES. MINE WENT OUT AFTER MARATHON GAS HAD BAD GAS AND THE COMPANY HAD TO REPLACE EVERYONE'S SENSORS. I DON'T THINK IT WAS THE GAS. THE GAS GAUGE ALWAYS MOVES UP AND DOWN STILL AND WHEN IDLING GOES DOWN. THE SES LIGHT COMES ON AND THE CAR TEMP GOES OUT. HAD IT DIAGNOSED AND THE COMP SAID TEMP CONTROL MODULATOR PLUG WAS DIRTY. HAD PLUG CLEANED AND REMEDIED PROBLEM. 2 WEEKS LATER THE SAME HAPPENED AGAIN AND 5 MIN AFTER THE SES LIGHT CAME ON THE CHECK ENGINE SOON LIGHT CAME ON. NOW BOTH LIGHTS ARE ON AND THIS VEHICLE NEVER HAS NOTHING GOING RIGHT. *JB
DT: THE CONTACT OWNS A 2001 PONTIAC AZTEC. FIVE MONTHS AGO THE EXTERIOR AND INTERIOR LIGHTS MALFUNCTIONED WHILE DRIVING. THE CONTACT REPLACED TWO OXYGEN SENSORS; ONE IN MAY 2005, AND ONE IN AUGUST 2005. THE CONTACT WAS STILL EXPERIENCING THE SAME PROBLEM. THE CONTACT WENT BACK TO AUTO ZONE TODAY AND THEIR COMPUTER SHOWED…
Read full complaint
DT: THE CONTACT OWNS A 2001 PONTIAC AZTEC. FIVE MONTHS AGO THE EXTERIOR AND INTERIOR LIGHTS MALFUNCTIONED WHILE DRIVING. THE CONTACT REPLACED TWO OXYGEN SENSORS; ONE IN MAY 2005, AND ONE IN AUGUST 2005. THE CONTACT WAS STILL EXPERIENCING THE SAME PROBLEM. THE CONTACT WENT BACK TO AUTO ZONE TODAY AND THEIR COMPUTER SHOWED HER THAT SHE NEEDED ANOTHER OXYGEN SENSOR. THE CAR WAS NO LONGER UNDER WARRANTY. THE CONTACT HAS NOT SPOKEN TO THE MANUFACTURER. THE CONTACT STATED SHE HAD GONE TO SEVERAL MECHANICS, AND THEY DID NOT KNOW WHAT THE PROBLEM WAS. THE ONLY THING SHOWING UP WAS A BAD OXYGEN SENSOR. *AK
I TOOK MY VEHICLE TO MY DEALERSHIP(BUICK,PONTIAC,GMC) IN DUBLIN AFTER MY ENGINE STARTED OVERHEATING. I WAS TOLD BY THE MECHANIC THAT THE INTAKE VALVE SEAL IS LEAKING COOLANT. MY QUERY IS THIS A DEFECT BY THE MANUFACTUER? *AK
SUDDEN ACCELERATION OCCURRED SEVERAL TIMES IN THE SAME DAY. THE PROBLEM WAS NOTICED ON MY WAY TO WORK. AFTER PUTTING MY VEHICLE IN PARK, THE VEHICLE WAS STILL REVVING AT 2500 RPMS. AGAIN, ON MY WAY HOME, I AGAIN NOTICED SUDDEN ACCELERATION. MY VEHICLE WOULD INCREASE IN SPEED ON ITS OWN AFTER RELEASING MY FOOT OFF OF THE BREA…
Read full complaint
SUDDEN ACCELERATION OCCURRED SEVERAL TIMES IN THE SAME DAY. THE PROBLEM WAS NOTICED ON MY WAY TO WORK. AFTER PUTTING MY VEHICLE IN PARK, THE VEHICLE WAS STILL REVVING AT 2500 RPMS. AGAIN, ON MY WAY HOME, I AGAIN NOTICED SUDDEN ACCELERATION. MY VEHICLE WOULD INCREASE IN SPEED ON ITS OWN AFTER RELEASING MY FOOT OFF OF THE BREAK PEDAL. I DID NOT NEED TO PUSH THE GAS PEDAL AT ALL. I TRAVEL AN HOUR TO WORK, AND HAD TO RIDE MY BRAKE MOST OF THE WAY HOME. AFTER REACHING MY DRIVEWAY, BEFORE TURNING THE IGNITION OFF, I HAD MY HUSBAND COME AND WITNESS THE ISSUE. THE VEHICLE AGAIN IN PARK, WAS REVVING AT 3000 RPM'S. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP THAT EVENING. THEY LOOKED AT IT THE NEXT DAY AND TOLD US THERE WAS NOTHING WRONG WITH THE VEHICLE. THEY STATED THEY COMPLETED A DIAGNOSTIC CHECK ON THE VEHICLE AND IT WAS FINE. I AM VERY CONCERNED THAT IF IT HAPPENS AGAIN, MY BRAKES WILL NOT HOLD AND THEREFORE AN ACCIDENT WILL OCCUR. *NM
COOLANT LEAK ON PONTIAC 2001 AZTEK. THE LOWER INTAKE MANIFOLD GASKET FAILED. I DID NOT HAVE AN ACCIDENT, BUT IT COULD HAVE SEIZED THE ENGINE WITH OUT WARNING. THE LOW COOLANT WARNING NEVER CAME ON EVEN AFTER I WAS ONE GALLON LOW. DEALER REPLACED GASKET FOR COST OF $730. PONTIAC WOULD NOT HELP WITH PRICING. I DID A WEB SEAR…
Read full complaint
COOLANT LEAK ON PONTIAC 2001 AZTEK. THE LOWER INTAKE MANIFOLD GASKET FAILED. I DID NOT HAVE AN ACCIDENT, BUT IT COULD HAVE SEIZED THE ENGINE WITH OUT WARNING. THE LOW COOLANT WARNING NEVER CAME ON EVEN AFTER I WAS ONE GALLON LOW. DEALER REPLACED GASKET FOR COST OF $730. PONTIAC WOULD NOT HELP WITH PRICING. I DID A WEB SEARCH AND FOUND A TSB ON THE GASKET WHERE GM/PONTIAC AKNOWLEDGES THE PROBLEM. I AM ALSO A MEMBER OF AZTEKFANCLUB.COM AND OTHER MEMEBERS HAVE HAD THE SAME PROBLEM AND HAVE HAD PONTIAC HELP COVER THE COST OF THE REPAIR.*AK
AFTER STARTING THE VEHICLE CONSUMER HEARD A SHATTERING NOISE, THEN THE MOTOR BLEW. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
THE CONSUMER TOOK THE VEHICLE IN TO HAVE IT SERVICED FOR AN OIL CHANGE. THE CONSUMER WAS INFORMED THAT THE HEAD HAD SEPARATED FROM THE ENGINE. *JB
FAILURE OF UPPER AND LOWER INTAKE MANIFOLD GASKETS ON GM MANUFACTURED 3.4L V6 ENGINE. GASKETS REPLACED AT EXPENSE OF OWNER.*AK
I LOST HEAT IN MY 2001 PONTIAC AZTEK, BROUGHT TO REPAIR SHOP, LEAKING INTAKE MANIFOLD GASKET WAS THE CAUSE. THEY SAID THIS IS A KNOWN PROBLEM, GM HAS NEW SERVICE BULLETIN ON IT AND NEW DESIGN. COST TO REPAIR 794.00 CAR HAS 43203 MILES. CALLED GM AND THEY WILL NOT HELP, EVEN THOUGH THEY KNOW ITS A BAD GASKET DESIGN ON AND AFFECTI…
Read full complaint
I LOST HEAT IN MY 2001 PONTIAC AZTEK, BROUGHT TO REPAIR SHOP, LEAKING INTAKE MANIFOLD GASKET WAS THE CAUSE. THEY SAID THIS IS A KNOWN PROBLEM, GM HAS NEW SERVICE BULLETIN ON IT AND NEW DESIGN. COST TO REPAIR 794.00 CAR HAS 43203 MILES. CALLED GM AND THEY WILL NOT HELP, EVEN THOUGH THEY KNOW ITS A BAD GASKET DESIGN ON AND AFFECTING ABOUT EVERY GM VEHICLE WITH THE 3.4L V^ ENGINE. I PURCHASED NEW AND EXPECT GM TO COVER THESE COSTS. AND AM CURIOUS WHY A RECALL HAS NOT BEEN ISSUED?*JB
Official recalls
507V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
02V329000 · Air Bags:frontal
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
01V383000 · Seats:front Assembly:recliner
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
01V026000 · Air Bags:frontal
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.