Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

18 crash reports12 fire reports12 injury reports

Power Train complaints

55 reports

Clear category filter

156,999 miles · Jul 29, 2007

Power Train

WHILE STARTING FROM STOPPED POSITION AT TRAFFIC LIGHT, MY FRONT LEFT AXEL SNAPPED IN THE MIDDLE. IT SEEMS THERE WAS A MANUFACTURING DEFECT IN THE AXEL ROD. *TR

NHTSA ODI #10197752

126,459 miles · Jun 27, 2006

Air BagsEngine And Engine CoolingPower Train

Read full complaint

DT*: THE CONTACT STATED THERE WERE SEVERAL PROBLEMS WITH THE VEHICLE THAT WOULD BE CONSIDERED A MANUFACTURER DEFECT. THE FIRST COMPONENT OF CONCERN WAS THE BELT TENSIONER WHICH HAD TO BE REPLACED BY THE DEALER BECAUSE IT WAS OBSERVED TO BE DISMANTLED. THE SECOND COMPONENT WAS IDENTIFIED WHEN THE VEHICLE WAS TAKEN IN FOR A REGULAR OIL CHANGE. THE INDEPENDENT MECHANIC DETERMINED THERE WAS A MAJOR LEAK COMING FROM THE PUMP SEAL ON THE TRANSMISSION. ONCE THE TRANSMISSION WAS TAKEN OUT OF THE VEHICLE, A CRACK WAS OBSERVED IN THE TORQUE CONVERTER. THE TRANSMISSION HAD TO REBUILT BECAUSE A TRANSMISSION FOR REPLACEMENT COULD NOT BE FOUND. THE DEALER DETERMINED THE TRANSMISSION PROBLEM WAS DUE TO A PIN DROP WHICH HAS BEEN COMMON IN VEHICLES OF THIS YEAR, MAKE AND MODEL. THE THIRD COMPONENT WAS DISCOVERED WHILE THE CONTACT SEARCHED CAR FAX FOR HISTORY ON THE VEHICLE; THERE WAS A RECALL ON THIS VEHICLE FOR THE AIRBAG. WHEN THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REMEDY REPAIR, IT WAS NOT PERFORMED BECAUSE THE VEHICLE EXCEEDED 70,000 MILES. THE DEALER CONFIRMED THAT THE REMEDY REPAIRS WOULD BE ISSUED ONLY IF THE VEHICLE INCURRED THE CONSEQUENCES OF THE RECALL. THE LAST COMPONENT OF CONCERN WAS THE SERVICE ENGINE SOON LIGHT, WHICH CONSTANTLY ILLUMINATED. WHEN THE VEHICLE WAS TAKEN TO THE DEALER, THEY DETERMINED THERE WAS CYLINDER MISFIRE. HOWEVER, THE CONTACT EXPRESSED THAT THIS PROBLEM MAY HAVE BEEN CAUSED BY A MALFUNCTIONED COMPUTER SYSTEM. AFTER A MAJOR TUNE UP TO THE VEHICLE THE SERVICE ENGINE SOON LIGHT ONLY ILLUMINATES INTERMITTENTLY.

NHTSA ODI #10160917

133,000 miles · Jan 30, 2006

Power Train

DT*: THE CONTACT STATED A LEAK WAS NOTICED UNDER THE TRANSMISSION WHEN THE VEHICLE WAS PARKED. A LOCAL INDEPENDENT REPAIR MECHANIC REPLACED A SHAFT SEAL IN THE TRANSMISSION. HOWEVER, THAT DID NOT REMEDY THE LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR TRANSMISSION SHOP WERE IT WAS DETERMINED THE TRANSMISSION NEEDED R…

Read full complaint

NHTSA ODI #10148984

100,000 miles · Aug 10, 2005

Electrical SystemPower TrainService Brakes, Hydraulic

DT: CONTACT WENT TO HAVE BRAKES CHECKED ON 8-3-05, JUST A ROUTINE CHECK, AND THE MECHANIC NOTICED THAT LEFT FRONT CALIPER BOLTS WERE INCORRECT AND HAVE DAMAGED THE STEERING KNUCKLES. HE TOLD HER THE LEFT FRONT WHEEL WAS SPINNING INSIDE THE KNUCKLES, WITHIN 7 MONTHS AFTER PURCHASING THE CAR HAD TO REPLACE THE TRANSMISSI…

Read full complaint

NHTSA ODI #10132269

35,700 miles · Jul 15, 2005

Power Train

DT: CONTACT OWNS A 1998, PLYMOUTH, VOYAGER VAN. TRANSMISSION FAILED ON OCT. 1, 2003 AT ONLY 35,700 MILES. *AK *JB

NHTSA ODI #10126514

36,000 miles · Aug 18, 2004

Power Train

Read full complaint

PLYMOUTH VOYAGER TRANSMISSION FAILED AT 36,000 MILES. IT WAS JUST OUT OF THE 3 YEAR WARRANTY. SOME VALVE SHOT THROUGH THE TRANSMISSION HOUSING. TRANSMISSION FLUID SPRAYED ALL OVER THE ENGINE COMPARTMENT INCLUDING THE EXHAUST. I'M SURPRISED IT DIDN'T BURN. TO DO A TOTAL REBUILD THE INDEPENDENT TRANSMISSION SHOP HAD TO WELD THE CASE BECAUSE THIS FAILURE IS SO COMMON USED TRANSMISSION HOUSINGS ARE SCARCE. THIS FAILURE WAS REPEATED 3 MORE TIMES IN THE YEAR THAT I OWNED THIS VEHICLE. THERE WERE ALSO 2 FAILURES OF AN ELECTRONIC CONTROL VALVE ON THE TRANSMISSION. THE TRANSMISSION SHOP OWNER SAID HE FIXES MANY MORE CHRYSLER MINIVAN TRANSMISSIONS THAN ANY OTHER VEHICLE. HE SAID ITS BEEN AN ONGOING PROBLEM WITH THEM FOR AT LEAST A DOZEN YEARS THAT KEEPS HIS FAMILY FED. CHRYSLER DENIED ANY KNOWLEDGE OF DEFECTIVE TRANSMISSIONS IN THEIR VEHICLES. MY RESEARCH SAYS ITS AN ALL TOO COMMON FAILURE IN NOT ONLY THE MINIVANS BUT IN THE PICKUP TRUCKS AND JEEPS AS WELL. I DROVE CHYSLERS AND JEEPS ALL MY LIFE BUT NOW I WON'T BUY EITHER. *JB

NHTSA ODI #10088118

90,000 miles · Jun 24, 2004

Air BagsEngine And Engine CoolingPower Train

Read full complaint

THE AIRBAG SENSOR LIGHT CONTINUED TO STAY ON AND HORN THE WAS INOPERATIVE. THE DEALER STATED THE AIR BAG CLOCK SPRING HAD FAILED. A RECALL WAS ISSUED, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE OF THE REMEDY SCOPE. *JB THE VALVE COVER GASKET LEAKED OIL WHILE THE VEHICLE WAS STILL UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALER WHO CLAIMED THEY COULDN'T FIND A LEAK. THE VEHICLE WAS TAKEN TO TWO OTHER TECHNICIANS WHO BOTH AGREED THAT THERE WAS A LEAK. THE SERPENTINE BELT CRACKED AT 90000 MILES. THE TRANSMISSION COOLER LINE CLAMPS WERE REPLACED. *NM

NHTSA ODI #10074192

60,000 miles · Jun 14, 2004

Power TrainCrash

WHILE DRIVING APPROXIMATELY 45 MPH, THE CONSUMER HEARD A NOISE AND TRIED TO SHUT THE VEHICLE OFF. THE CONSUMER HIT THE GUARD RAIL TO GET THE VEHICLE TO STOP AND THE TRANSMISSION WENT OUT. THE DIFFERENTIAL CRACKED AND BROKE THE AXLE WHICH WENT INTO THE TRANSMISSION. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP. *AK …

Read full complaint

NHTSA ODI #10067118

100,000 miles · Apr 29, 2004

Power TrainCrashInjury

WHILE THE VEHICLE WAS ON DRIVER'S 2 YEAR OLD DAUGHTER SHIFTED THE GEAR INTO REVERSE WITHOUT APPLYING THE BRAKES AND VEHICLE MOVED AND HIT THE DRIVER. DRIVER SUSTAINED BONE BRUISES ALL OVER THE BODY, AND WAS TRANSPORTED TO THE HOSPITAL. *AK *LA

NHTSA ODI #10064718

50,000 miles · Mar 31, 2004

Electrical SystemPower TrainVehicle Speed Control

TRANSMISSION DISINTEGRATED, WIPER MOTOR PROBLEMS, AND LOST OF HORN AND CRUISE CONTROL. *PH *MR

NHTSA ODI #10065193

Official recalls

04V480000 · Air Bags

Oct 6, 2004

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V293000 · Air Bags:frontal

Nov 7, 2002

ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.

Consequence & remedy

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V076000 · Seat Belts:rear/other

Mar 8, 2002

ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

97V231000 · Child Seat

Dec 15, 1997

VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.

Consequence & remedy

Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.

Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA04013 · Driver Air Bag Clockspring Failure

Opened Jun 4, 2004 · Closed May 25, 2005

Status: closed (inferred from source dates) · Air Bags:frontal

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

RQ04001 · Driver Air Bag Clockspring Failure

Opened Jan 28, 2004 · Closed Jun 4, 2004

Status: closed (inferred from source dates) · Air Bags:frontal

COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).

PE02004 · Rear Seat Belt Malfunction

Opened Jan 16, 2002 · Closed Mar 11, 2002

Status: closed (inferred from source dates) · Seat Belts:rear/other

THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available

EA99013 · Post Collision Fuel System

Opened Jun 11, 1999 · Closed Aug 10, 2001

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

No summary supplied.

PE99010 · POST-COLLISION Fuel System Integrity

Opened Feb 3, 1999 · Closed Jun 11, 1999

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

There is no summary currently available