TL* THE CONTACT OWNS A 1995 PLYMOUTH NEON. WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ON ANOTHER OCCASION, THE CONTACT STATED THAT WHILE REVERSING, THE STEERING COLUMN STARTED SMOKING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS…
Read full complaint
TL* THE CONTACT OWNS A 1995 PLYMOUTH NEON. WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ON ANOTHER OCCASION, THE CONTACT STATED THAT WHILE REVERSING, THE STEERING COLUMN STARTED SMOKING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN COUPLER AND STEERING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT THE TURN SIGNALS AND INTERIOR LIGHTING FAILED TO OPERATE INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 97V169000 (STEERING). THE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10767353
124,800 miles · Aug 18, 2008
Air BagsInjury
WHILE DRIVING INTO THE DRIVEWAY, BOTH AIR BAGS DEPLOYED CAUSING INJURIES TO OUR 16 YEAR OLD DAUGHTER. SHE INCURRED IMPACT BURNS AND A SPRAIN TO HER LEFT WRIST.*TR
NHTSA ODI #10238719
Mileage unknown · Sep 28, 2004
Air BagsCrashInjury
DURING IMPACT AIR BAGS DEPLOYED, CAUSED NUMEROUS BURNS TO FACE, NECK, HANDS, CHEST ARMS AND SHOULDERS. *BF THE CONSUMER BELIEVES THE AIR BAG SYSTEM IN THE VEHICLE WAS DEFECTIVE AND THAT THE VEHICLE SHOULD BE RECALLED. *NM
NHTSA ODI #10095121
85,000 miles · Jan 15, 2004
Air BagsPower TrainService Brakes, HydraulicCrash
BRAKES FAILED TO WORK RIGHT WHEN MY BOYFRIEND WRECKED THE CAR WHICH THEN MADE HIM HIT THE GUARD RAIL. THE AIR BAGS DIDN'T COME OUT. WE CONTACTED THE PLACE WE GOT THE CAR FROM BUT THEY COULD NOT TELL US ANYTHING. THEN THE TRANSMISSION WENT OUT OF IT ON OCTOBER 1, 2003. THE WHOLE TRANSMISSION EXPLODED. WE WERE TOLD THE PLACE WE B…
Read full complaint
BRAKES FAILED TO WORK RIGHT WHEN MY BOYFRIEND WRECKED THE CAR WHICH THEN MADE HIM HIT THE GUARD RAIL. THE AIR BAGS DIDN'T COME OUT. WE CONTACTED THE PLACE WE GOT THE CAR FROM BUT THEY COULD NOT TELL US ANYTHING. THEN THE TRANSMISSION WENT OUT OF IT ON OCTOBER 1, 2003. THE WHOLE TRANSMISSION EXPLODED. WE WERE TOLD THE PLACE WE BOUGHT IT FROM DID NOT PUT IN NEW CLUTCH AND PRESSURE PLATE AND THROW OUT BEARINGS IN WHEN WE HAD JUST BOUGHT IT. WE HAD TOLD THEM THE CLUTCH WAS MAKING NOISE. THEY WOULD NOT FIXED IT. THEY SAID IT WAS NOTHING WHEN I TOOK IT IN; THAT'S JUST NEONS THEY SAID... MY BIGGEST CONCERN BESIDE THE TRANNY AND CLUTCH IS THE AIR BAGS NOT COMING OUT AT ALL...
NHTSA ODI #10071032
Mileage unknown · Dec 4, 2002
Air BagsCrashInjury
WAS TRING TO EXIT HIGHWAY WHEN TRAFFIC SUDDENLY STOPPED AND I HAD TO SLAM ON MY BRAKES BUT IT DIDN'T KEEP ME FROM REAR ENDING A TRUCK AND IT LEFT SKID MARKS ON THE HIGHWAY. THE AIR BAGS NEVER DEPLOYED. DT
NHTSA ODI #770456
Mileage unknown · Aug 2, 2002
Air BagsCrashInjury
WHILE SITTING AT A INTERSECTION AND WITHOUT PRIOR WARNING ,AND UPON IMPACT AIR BAGS WENT OFF AND HIT CONSUMER IN FACE. DEALERSHIP WAS AWARE OF PROBLEM. *AK
NHTSA ODI #8015422
Mileage unknown · May 18, 2002
Air BagsCrash
MINOR BUMP TO ANOTHER VEHICLE. AIRBAGS DEPLOYED AT A VERY SLOW SPEED. NO DAMAGE TO MY VEHICLE OTHER THAN THE AIRBAGS AND WINDSHIELD.*AK
NHTSA ODI #762032
Mileage unknown · Apr 12, 2002
Air BagsService Brakes, HydraulicCrashFireInjury
WHILE AT 40 MPH GOING DOWN HILL AROUND A TURN CONSUMER APPLIED BRAKES AND THEY WERE TOO HARD. CONSUMER'S VEHICLE WENT INTO OTHER LANE AND STRUCK ANOTHER VEHICLE HEAD-ON. VEHICLE BURST INTO FLAMES AND AIRBAGS DID NOT DEPLOY. *AK CONSUMER MENTIONS RECALLS 94V034, 94V033, AND 96V228, CONSUMER ATTEMPTED TO GET THESE RECALL REPAIRS…
Read full complaint
WHILE AT 40 MPH GOING DOWN HILL AROUND A TURN CONSUMER APPLIED BRAKES AND THEY WERE TOO HARD. CONSUMER'S VEHICLE WENT INTO OTHER LANE AND STRUCK ANOTHER VEHICLE HEAD-ON. VEHICLE BURST INTO FLAMES AND AIRBAGS DID NOT DEPLOY. *AK CONSUMER MENTIONS RECALLS 94V034, 94V033, AND 96V228, CONSUMER ATTEMPTED TO GET THESE RECALL REPAIRS TWO WEEKS PRIOR TO ACCIDENT, HOWEVER DEALER REFUSED DUE TO VIN, CONSUMER STATES THESE RECALLS ARE RELATED TO THE ACCIDENT. *YD
NHTSA ODI #8007519
Mileage unknown · Feb 12, 2002
Air BagsEngine And Engine CoolingStructureFireInjury
DEFECTIVE HEADGASKET CAUSED EROSION AND DAMAGE TO THE HEAD, CHRYSLER DENIES TO COVER COST OF $2500. THERE ARE MANY REPORTS ON THE INTERNET OF BROKEN HEADGASKETS IN THE NEONS AND CHRYSLER ADMITS TO THE DEFECT AND PAYS TO REPAIR SOME, BUT SAYS VEHICLE HAS TOO MANY MILES AND CONSUMER IS A THIRD OWNER SO THEY WON'T COVER IT. *AK …
Read full complaint
DEFECTIVE HEADGASKET CAUSED EROSION AND DAMAGE TO THE HEAD, CHRYSLER DENIES TO COVER COST OF $2500. THERE ARE MANY REPORTS ON THE INTERNET OF BROKEN HEADGASKETS IN THE NEONS AND CHRYSLER ADMITS TO THE DEFECT AND PAYS TO REPAIR SOME, BUT SAYS VEHICLE HAS TOO MANY MILES AND CONSUMER IS A THIRD OWNER SO THEY WON'T COVER IT. *AK ON 22-FEB-2002 CONSUMERS SON WAS HIT HEAD ON BY ANOTHER VEHICLE TRAVELING AT 35 MPH, THE DRIVER AND PASSENGER AIRBAGS DID NOT DEPLOY, THE VEHICLE CAUGHT FIRE ON IMPACT, CONSUMER WAS INJURED IN ACCIDENT, THE DOORS WOULD NOT OPEN, CONSUMER HAD TO CRAWL OUT OF THE WINDOWS. *SLC
NHTSA ODI #758154
Mileage unknown · Jun 13, 2001
Air BagsCrash
VEHICLE WAS GOING 40-45MPH AND ANOTHER VEHICLE MADE A SUDDEN STOP CAUSING CONSUMER'S VEHICLE TO REAREND OTHER VEHICLE. PASSENGER'S AIRBAG DEPLOYED, BUT DRIVER'S DIDN'T. NO INJURIES TO DRIVER. *AK *SLC
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence & remedy
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
THE REAR BRAKE HOSE MOUNTING BRACKET SCREWS CAN FAIL ALLOWING THE BRAKE HOSES TO MOVE OUT OF POSITION. THE UNRESTRAINED HOSES ARE THEN SUSCEPTIBLE TO DAMAGE WHICH COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL REDUCE THE BRAKING PERFORMANCEOF THE VEHICLE, EXTEND STOPPING DISTANCES, AND COULD RESULT IN AN ACCIDENT.
Remedy: THE REAR BRAKE LINE HOSE BRACKET SCREWS ON THESE VEHICLES WILL BE REPLACED.
THE ABS BRAKE MASTER CYLINDER REAR SEAL ALLOWS AIR TO ENTER THE BRAKE SYSTEM, CAUSING SPONGY BRAKES OR PARTIAL BRAKE SYSTEM LOSS.
Consequence & remedy
Consequence: AIR ENTERING THE BRAKE SYSTEM CAUSED EXTENDED STOPPING DISTANCE OR PARTIAL LOSS OF BRAKES WHICH MAY RESULT IN AN ACCIDENT.
Remedy: MASTER CYLINDERS WILL BE INSPECTED FOR THE SUSPECT BUILD DATE CODE RANGE AND WILL BE REPLACED IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE98012 · Underhood Fires
Opened Feb 26, 1998 · Closed Jun 23, 1998
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA98003 · Oversensitive Air Bag Deployments
Opened Jan 30, 1998 · Closed Jan 5, 2000
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
PE97042 · Oversensitive Air Bag Deployment
Opened Sep 21, 1997 · Closed Jan 30, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA97009 · Loss Of Steering Control
Opened Apr 30, 1997 · Closed Oct 8, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE97007 · Alleged Fires In Steering Column Area
Opened Jan 31, 1997 · Closed Apr 7, 1997
Status: closed (inferred from source dates) · Electrical System
THE APPARENT CAUSE OF THE PROBLEM IS THE ACCUMULATION OF BRASS POWDER, THAT WEARS OFF THE ELECTRICAL CONTACTS INSIDE THE TURN SIGNAL SWITCH.THIS POWDER COLLECTS IN SMALL TRAILS OF GREASE THAT TRACK FROM ONE CONTACT TO ANOTHER.WHEN THE CONCENTRATION OF BRASS IN THE GREASE GETS HIGH ENOUGH, IT CAN CAUSE A HIGH RESISTANCE SHORT.THIS SHORT, IN TURN CAN IGNITE THE GREASE AND CAUSE SMOKE TO BE EMITTED FROM THE STEERING COLUMN.THE GREASE USED INSIDE THE SWITCH, AS WELL AS THE VARIOUS PLASTIC COMPONENTS IN THE COLUMN, ARE FIRE RETARDANT AND WILL NOT BURN WITHOUT A SUSTAINED HEAT SOURCE.THERE HAS BEEN ONLY A SINGLE VERIFIED INCIDENT THAT RESULTED IN A VEHICLE FIRE AND THIS REPORTED FIRE WAS SMALL, INVOLVING SOME CHARRING OF THE STEERING WHEEL.ALL OTHER VERIFIED INCIDENTS WERE LIMITED TO SMOKE FROM THE COLUMN AND MINOR INTERNAL DAMAGE TO THE STEERING COLUMN.
PE96069 · Loss Of Steering Control
Opened Nov 26, 1996 · Closed Apr 30, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94095 · Loss Of Steering Control
Opened Dec 28, 1994 · Closed Apr 25, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1995 Plymouth Neon Problems, Complaints & Recalls | Skip That Year
Illustration