IllustrationI WAS IN MY WAY TO WORK WHEN IT WAS RAINING EVER TIME IT RAINS THE BELTS COMES OFF THIS IS VERY DANGEROUS. I HAD NO POWER STEERING AT ALL WHEN THIS HAPPEN WITH MUSCLE I MANAGED TO PULL OVER ONTO THE SHOULDER OF THE ROAD. ONCE WATER HITS THE TENSION WHEEL BELT IT KNOCKS IT OFF WHICH MAKES IT SLIDE OFF EVERY TIME.
1997 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1997 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 261 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports15 fire reports12 injury reports
Steering complaints
22 reportsSINCE PURCHASING THIS VAN USED LAST YEAR 2011, MY VAN HAS A HIGH PITCHED SQUEALING NOISE. DEALERSHIP (3RD PARTY) STATED IT WAS ONLY A WET BELT AND WOULD STOP ONCE THE BELT DRIED. THIS NOISE NEVER STOPPED. MY TEEN DRIVER WAS ALONE WHEN THE BELT SNAPPED CAUSING HER TO LOOSE CONTROL OF THE STEERING. SEEING OTHER POST OF SIMILAR OR …
Read full complaint
SINCE PURCHASING THIS VAN USED LAST YEAR 2011, MY VAN HAS A HIGH PITCHED SQUEALING NOISE. DEALERSHIP (3RD PARTY) STATED IT WAS ONLY A WET BELT AND WOULD STOP ONCE THE BELT DRIED. THIS NOISE NEVER STOPPED. MY TEEN DRIVER WAS ALONE WHEN THE BELT SNAPPED CAUSING HER TO LOOSE CONTROL OF THE STEERING. SEEING OTHER POST OF SIMILAR OR WORSE CASE SCENARIOS I AM LOOKING INTO FURTHER ACTION. NEITHER THE MECHANIC AT THE DEALERSHIP OR ANY OTHER MECHANIC EVER STATED TO ME THAT THIS ISSUE IS COMMON IN THIS VEHICLE. *TR
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ON…
Read full complaint
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM . *TR
DT: CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. CONTACT WAS DRIVING ON A MAJOR HIGHWAY AT 45 MPH SPEED WHEN THE STEERING COLUMN LOCKED . NO WARNING AT ALL. THE CONTACT'S VEHICLE WAS MERGING OFF THE HIGHWAY TO THE RIGHT. THEN TURNED THE STEERING WHEEL TO THE RIGHT IT WAS VERY HARD TO TURN THE STEERING WHEEL. TURNED THE WHEEL TO …
Read full complaint
DT: CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. CONTACT WAS DRIVING ON A MAJOR HIGHWAY AT 45 MPH SPEED WHEN THE STEERING COLUMN LOCKED . NO WARNING AT ALL. THE CONTACT'S VEHICLE WAS MERGING OFF THE HIGHWAY TO THE RIGHT. THEN TURNED THE STEERING WHEEL TO THE RIGHT IT WAS VERY HARD TO TURN THE STEERING WHEEL. TURNED THE WHEEL TO THE LEFT, AND IT WAS VERY HARD TO TURN. THE CONTACT TURNED THE IGNITION OFF THEN BACK ON AGAIN AND IT WAS AS IF NOTHING HAPPENED. THEN, TOOK VEHICLE TO A MECHANIC, AND HE COULD NOT DUPLICATE THE PROBLEM. TOOK THE VEHICLE TO THE PLYMOUTH VOYAGER DEALER. THEY LOOKED AT IT, AND THE REPAIR COST WILL BE $900 TO FIX THE WHOLE RACK. CALLED THE CHRYSLER MANUFACTURER, AND THE CONTACT WAS TOLD THAT THEY WOULD PAY FOR HALF OF THE REPAIR COST . CONTACTED THE MANUFACTURER ON 10-11-05 AND 10-12-05.*AK
1997 PLYMOUTH GRAND VOYAGER TIE ROD END FAILURE. THE TIE ROD END BALL JOINT SEPERATED. THIS WAS A "LIFETIME" LUBRICATED PART WITH NO GREASE FITTING. THERE WAS NO GREASE LEFT IN THE BALL JOINT, RUST AND CORROSION APPEARS TO HAVE CONTRIBUTED TO THE FAILURE. THESE JOINTS ARE OF POOR DESIGN AND SHOULD NOT FAIL TO THE POINT OF COMPL…
Read full complaint
1997 PLYMOUTH GRAND VOYAGER TIE ROD END FAILURE. THE TIE ROD END BALL JOINT SEPERATED. THIS WAS A "LIFETIME" LUBRICATED PART WITH NO GREASE FITTING. THERE WAS NO GREASE LEFT IN THE BALL JOINT, RUST AND CORROSION APPEARS TO HAVE CONTRIBUTED TO THE FAILURE. THESE JOINTS ARE OF POOR DESIGN AND SHOULD NOT FAIL TO THE POINT OF COMPLETE LOSS OF STEERING CONTROL.. HAPPENED WHILE PARKING THE VEHICLE, IF IT HAD SEPARATED ON THE HIGHWAY AT SPEED COULD HAVE BEEN A SERIOUS ACCIDENT.*AK
I HAVE PROBLEMS WITH MY WIPERS GOING ON AND RIGHT BACK OFF SINCE THE MONTH I BOUGHT THIS VEHICLE IN 2000 . I CANT GET IT FIXED BECAUSE NOONE KNOWS WHY IT DOES IT . JUST THIS WEEK I HAD MY FAN RELAY MODULE REPLACED , ONLY TO LEARN MY TRANSMISSION IS NOW NOT WORKNIG IT STOPS AT 3RD GEAR ONLY TO DROP TO 1 GEAR . WHILE TRYING TO GE…
Read full complaint
I HAVE PROBLEMS WITH MY WIPERS GOING ON AND RIGHT BACK OFF SINCE THE MONTH I BOUGHT THIS VEHICLE IN 2000 . I CANT GET IT FIXED BECAUSE NOONE KNOWS WHY IT DOES IT . JUST THIS WEEK I HAD MY FAN RELAY MODULE REPLACED , ONLY TO LEARN MY TRANSMISSION IS NOW NOT WORKNIG IT STOPS AT 3RD GEAR ONLY TO DROP TO 1 GEAR . WHILE TRYING TO GET THAT FIXXED THEY TOLD ME MY WATER PUMP IS LEAKING (WHICH IS OK AND EXPECTED OF MOST VEHICLES , ) I HAVE HAD TO HAVE MY DASH LIGHT COMPUTER RESET BECAUSE ALL MY AC DFROST AND WIPER LIGHTS WERE BLINKING CONTINUOUSLY. I DONT KNOW WHAT TO DO THIS IS ONLY A 97 MODEL AND I HAVENT EVEN MADE MY FINAL PAYMENT BUT NOW I HAVE ALL THESE EXPENSIVE REPAIRS. I HAVE HAD I TICK IN MY MOTOR THAT RATTLES ON ACCELERATIN FOREVER AND CHANGE MY OIL EVERY 3 TO 4000 MILES LIKE I SHOULD . I ALSO HAVE THE WINNING IN THE STEERING THE THUMP EVERY SO OFTEN BUT CANT TELL WHERE THAT IS COMING FROM NOT TO MENTION MY A/C COMPRESSOR RATTLES. MY BELT ON MY TENSIONER PULLY FLU AFF ABOUT 6 MONTHS AGO GOING DOWN THE ROAD I HAD TO PUT A NEW PUKKY PLUS BOTH NEW BELTS ON . AND THEY SQUEEK LIKE CRAZY . I DONT THINK THESE ARE NORMAL PROBLEMS CAN YOU HELP IT IS GETTING TO COSTLY >??????
FAILURE OF THE RACK AND PINION STEERING SYSTEM ON 1997 PLYMOUTH VOYAGERVIN [XXX]. FIRST FAILURE WAS JULY, 16 2001 AT 72,936 MILES REQUIRING COMPLETE REPLACEMENT OF THE RACK AND PINION AND THE POWER STEERING PUMP. FAILURE MODE WAS EXTREMELY DIFFICULT STEERING IE. HIGH FORCE REQUIRED ON THE STEERING WHEEL TO GUIDE THE VEHICLE. SEC…
Read full complaint
FAILURE OF THE RACK AND PINION STEERING SYSTEM ON 1997 PLYMOUTH VOYAGERVIN [XXX]. FIRST FAILURE WAS JULY, 16 2001 AT 72,936 MILES REQUIRING COMPLETE REPLACEMENT OF THE RACK AND PINION AND THE POWER STEERING PUMP. FAILURE MODE WAS EXTREMELY DIFFICULT STEERING IE. HIGH FORCE REQUIRED ON THE STEERING WHEEL TO GUIDE THE VEHICLE. SECOND FAILURE OCCURRED AT 104,575 WITH SAME SYMPTOM AS ABOVE AND AGAIN REQUIRED REPLACEMENT OF THE ENTIRE RACK AND PINION. THE DEALER CLAIMED THERE WAS NO PROBLEM AND A CALL TO CHRYSLER CUSTOMER SERVICE RESULTED IN NO ASSISTANCE OR IMPROVEMENT FOR THIS FAILURE.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
CONSUMER STATES WHILE DRIVING STEERING WHEEL LOCKS UP INTERMITTENTLY WHILE MAKING LEFT OR RIGHT TURNS. *AK
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEM WITH THE DEALER, CONSUMER RECEIVED A RECALL NOTICE ABOUT SIX MONTHS AGO, ARRANGED AN APPOINTMENT WITH THE DEALER. HAS BEEN SIX MONTHS AND THEY DON'T HAVE THE PART. PLEASE PROVIDE FURTHER INFORMATION. TS *TR
FIRST TWO TIE RODS BROKE AND FELL APART WHILE ACCELERATING TO MERGE WITH INTERSTATE TRAFFIC. *AK ENGINE FAILURE. *SLC
Official recalls
402V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.