IllustrationWE HAVE HAD THE TRANSMISSION RELACED ON APRIL 8, 1998, OCTOBER13, 2000, OCTOBER 25, 2000, AND WHEN WE PICKED THE VEHICLE UP ON OCTOBER 25, 2000 NOT 2 HOURS LATER WE WERE BROKE DOWN ON THE SIDE OF THE ROAD AGAIN.*AK
1997 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1997 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 261 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports15 fire reports12 injury reports
Power Train complaints
49 reportsA CHILD WAS ABLE TO PULL THE SHIFT LEVER WITHOUT BRAKE BEING APPLIED, CAUSING VEHICLE TO ROLL, RESULTING IN A COLLISION.*AK *SLC
CONSUMER HAS PUT 3 TRANSMISSIONS (TORQUE CONVERTERS) IN THE VEHICLE. NLM
THERE WAS NO PREVIOUS PROBLEMS WITH THE TRANSMISSION. I STARTED THE VAN PUT IT IN REVERSE AND IT SOUNDED LIKE SOMETHING CAME APART INSIDE. THERE WAS NO WARNING, NOW THE TRANSMISSION IS LOCKED UP. I AM AWARE OF CHRYSLER'S TRANSMISSION PROBLEMS AND THOUGHT THIS SHOULD BE REPORTED. I DON'T KNOW WHAT WOULD HAVE HAPPEN IF WE HAD …
Read full complaint
THERE WAS NO PREVIOUS PROBLEMS WITH THE TRANSMISSION. I STARTED THE VAN PUT IT IN REVERSE AND IT SOUNDED LIKE SOMETHING CAME APART INSIDE. THERE WAS NO WARNING, NOW THE TRANSMISSION IS LOCKED UP. I AM AWARE OF CHRYSLER'S TRANSMISSION PROBLEMS AND THOUGHT THIS SHOULD BE REPORTED. I DON'T KNOW WHAT WOULD HAVE HAPPEN IF WE HAD BEEN ON THE HIGHWAY WHEN THIS HAPPENED. THANK YOU VERY MUCH, ROGER CECIL
WHILE TRAVELING AND WITHOUT ANY INDICATION VEHICLE STALLED. CONSUMER WAS ABLE TO RESTART VEHICLE, BUT IT WOULD NOT DRIVE OUT OF FIRST GEAR. PLEASE PROVIDE FURTHER INFORMATION.*AK
TRANSMISSION MAIN SEAL DAMAGED CAUSING FLUID TO LEAK AND IMMINENT TRANSMISSION FAILURE. TRANSMISSION SPECIALIST SAID SUCH FAILURE IS VERY UNUSUAL FOR LOW MILEAGE VEHICLE AND SUGGESTED RECALL MAY BE ISSUED FOR VOYAGER/CARAVAN MODELS. DEALER DENIED THIS IS A MANUFACTURER PROBLEM. REVIEW OF NHTSA COMPLAINT SECTION REVEALS OTHERWI…
Read full complaint
TRANSMISSION MAIN SEAL DAMAGED CAUSING FLUID TO LEAK AND IMMINENT TRANSMISSION FAILURE. TRANSMISSION SPECIALIST SAID SUCH FAILURE IS VERY UNUSUAL FOR LOW MILEAGE VEHICLE AND SUGGESTED RECALL MAY BE ISSUED FOR VOYAGER/CARAVAN MODELS. DEALER DENIED THIS IS A MANUFACTURER PROBLEM. REVIEW OF NHTSA COMPLAINT SECTION REVEALS OTHERWISE. HOW MANY FAILURES DOES IT TAKE FOR A RECALL TO BE ISSUED?*AK
I AM A POLICE OFFICER AND HAVE TAKEN REPORTS TWICE ON GRAND VOYAGERS WHERE THEY HAVE POPPED OUT OF GEAR AND ROLLED UNNATTENDED. ON 5-10-2000 MY SISTERS VEHICLE WHICH WAS PARKED ON MY GRADED DRIVE DID THE SAME. IT NEARLY RAN ME OVER AND STRUCK MY VEHICLE. HER TRANSMISSION CAN BE PUT INTO GEAR WITHOUT DEPRESSING THE BRAKES. TH…
Read full complaint
I AM A POLICE OFFICER AND HAVE TAKEN REPORTS TWICE ON GRAND VOYAGERS WHERE THEY HAVE POPPED OUT OF GEAR AND ROLLED UNNATTENDED. ON 5-10-2000 MY SISTERS VEHICLE WHICH WAS PARKED ON MY GRADED DRIVE DID THE SAME. IT NEARLY RAN ME OVER AND STRUCK MY VEHICLE. HER TRANSMISSION CAN BE PUT INTO GEAR WITHOUT DEPRESSING THE BRAKES. THE SAME WAS TRUE FOR THE TWO REPORTS I TOOK IN MY OFFICIAL CAPACITY. THE DEALER TOLD ME THAT ALTHOUGH IT IS A MANDATED FEATURE IT ONLY LASTS SO LONG AND THAT IT IS NOT COVERED UNDER WARRANTY. THIS IS A MATTER THAT SHOULD BE LOOKED INTO BEFORE THE DEFECT RESULTS INTO A FATALITY. *AK
AUTOMATIC TRANSMISSION CAN BE SHIFTED TO REVERSE OR DRIVE WITHOUT HAVING FOOT ON THE BRAKE, DESIGN FLAW. YH
I TOOK THE VEHICLE TO A TRANSMISSION REPAIR SHOP AND WAS TOLD THE MAIN SEAL (PUMP SEAL) WAS DEFECTIVE AND NEEDED TO BE REPLACED BECAUSE OF LEAKING. I CHOOSE TO PULL THE TRANS MISSION AND FOUND A CRACK ON A MACHINED SURFACE INSIDE THE BELL HOUSING BEHIND THE TOURQUE CONVERTER. THE CRACK IS 1/16" WIDE AND 1" TO 1 1/2" LONG. THE MA…
Read full complaint
I TOOK THE VEHICLE TO A TRANSMISSION REPAIR SHOP AND WAS TOLD THE MAIN SEAL (PUMP SEAL) WAS DEFECTIVE AND NEEDED TO BE REPLACED BECAUSE OF LEAKING. I CHOOSE TO PULL THE TRANS MISSION AND FOUND A CRACK ON A MACHINED SURFACE INSIDE THE BELL HOUSING BEHIND THE TOURQUE CONVERTER. THE CRACK IS 1/16" WIDE AND 1" TO 1 1/2" LONG. THE MACHINED AREA LOOKS TO BE DESIGNED TO ALLOW CLEARENCE FOR THE TORQUE CONVERTER. THE CRACK ALSO APPEARS TO BE PUSH THRU FROM THE PASSENGERS SIDE DRIVE AXLE ASSEMBLY MEANING IT IS RAISED INSIDE THE BELL HOUSING. MY COMPLAINT IS THIS APPEARS TO BE A FLAW IN THE DESIGN THAT ALLOWS CLEARENCE FOR THE TOURQUE CONVERTER CAUSING A THIN WALL IN THE BELL HOUSING. IS THERE ANY TYPE OF RECALL OR INVESTIGATION THAT WOULD ALLOW OWNERS TO HAVE THEIR VEHICLES FIXED OR CHECKED FOR THIS PROBLEM? *AK
YOU CAN SHIFT FROM PARK TO REVERSE/DRIVE WITHOUT APPLYING BRAKE. *AK
Official recalls
402V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.