IllustrationAIR BAG LIGHT HAS COME ON AND STAYED ON. ALSO, HORN FAILED TO WORK, AND CRUISE CONTROL OPERATED RANDOMLY. *AK POSSIBLE CLOCKSPRING FAILURE. *SLC
1997 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1997 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 261 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports15 fire reports12 injury reports
Electrical System complaints
42 reportsAIR BAG LIGHT HAS BEEN ON AND WILL NOT GO OFF. ALSO, HORN HAS FAILED TO OPERATE. *AK
WHEN VAN WAS HIT BY ANOTHER VEHICLE, ON THE PASSENGER'S SIDE AT A HIGH RATE OF SPEED, THERE WAS NO DEPLOYMENT OF THE PASSENGER'S FRONT AIR BAG. ALSO, HORN DOES NOT WORK, REMOTE ENTRY ON DRIVER'S SIDE DOOR DOES NOT WORK, AIR BAG WARNING LIGHT STAYS ON, FUEL GAUGES DOES NOT WORK, A/C HEATER BLINK ON AND OFF,INSIDE DOME LIGHT BLINK…
Read full complaint
WHEN VAN WAS HIT BY ANOTHER VEHICLE, ON THE PASSENGER'S SIDE AT A HIGH RATE OF SPEED, THERE WAS NO DEPLOYMENT OF THE PASSENGER'S FRONT AIR BAG. ALSO, HORN DOES NOT WORK, REMOTE ENTRY ON DRIVER'S SIDE DOOR DOES NOT WORK, AIR BAG WARNING LIGHT STAYS ON, FUEL GAUGES DOES NOT WORK, A/C HEATER BLINK ON AND OFF,INSIDE DOME LIGHT BLINKS ON AND OFF, STEERING COLUMN FREEZES, CRUISE CONTROL WORKS ON AND OFF.
AIR BAG LIGHT COMES / CRUISE CONTROL FAILS TO WORK, AND HORN CANNOT BE USED. PROBLEM HAPPENS ONLY WHEN ENGINE STARTS, AND IS INTERMITTENT. *AK THE CRUISE CONTROL AND THE HORN FAILURES CAUSED BY CLOCK SPRING ASSEMBLY AND WAS REPLACED. *YH
HORN, AIRBAG, AND CRUISE CONTROL INOPERABLE
CHRSLER DEALER REFUSES TO PROVIDE COPY OF SERVICE BULLITEN NO. 070299, NHTSA ITEM NO: SB606159 CONCERNING SERPENTINE BELT SLIPPING OFF TENSIONER IDLER PULLEY. *AK
WHILE DRIVING THE VEHICLE CAUGHT FIRE, IT APPEARED TO BE ELECTRICAL, CLAIM # 40-2269-222. NLM
I HAVE HAD PROBLEMS WITH THIS VEHICLE EVER SINCE I BOUGHT IT. I TOOK THE VAN TO A GARAGE FOR THE PROBLEM I'M REPORTING AND THEY SAID IT WAS A PROBLEM WITH THE VEHICLE LOSING GROUNDING AND BURNING OUT THE PCM(?), BCM(?). THEY ALSO TOLD ME THAT THIS IS NOT A PART THAT IS MANUFACTURED FOR REPLACEMENT, YOU HAVE TO PULL THE DEFECTI…
Read full complaint
I HAVE HAD PROBLEMS WITH THIS VEHICLE EVER SINCE I BOUGHT IT. I TOOK THE VAN TO A GARAGE FOR THE PROBLEM I'M REPORTING AND THEY SAID IT WAS A PROBLEM WITH THE VEHICLE LOSING GROUNDING AND BURNING OUT THE PCM(?), BCM(?). THEY ALSO TOLD ME THAT THIS IS NOT A PART THAT IS MANUFACTURED FOR REPLACEMENT, YOU HAVE TO PULL THE DEFECTIVE ONE OUT AND SEND IT IN TO BE REPAIRED. THIS WILL TAKE ANYWHERE FROM 2 TO 5 DAYS AND THE COST IS $1,500. ADD TO THIS, 2 TO 5 DAYS OF A RENTAL CAR IN ORDER TO BE ABLE TO COMMUTE TO AND FROM WORK. NEVER WILL I BUY ANOTHER PLYMOUTH. EVER. *AK
WHILE DRIVING PRESSED ON ACCELERATOR PEDAL AND VEHICLE HESITATED. NOTICED WHITE SMOKE IN THE REAR OF VEHICLE. CHECKED SIDE MIRRORS & NOTICED FLAMES. STOPPED & TURNED VEHICLE OFF. FIRE DEPARTMENT CALLED & PUT FLAMES OUT. VEHICLE TOWED TO DEALERSHIP. MECHANIC INDICATED A SPARK CAUSED FUEL PUMP TO IGNITE & THE ELECTRICAL WIRES BUR…
Read full complaint
WHILE DRIVING PRESSED ON ACCELERATOR PEDAL AND VEHICLE HESITATED. NOTICED WHITE SMOKE IN THE REAR OF VEHICLE. CHECKED SIDE MIRRORS & NOTICED FLAMES. STOPPED & TURNED VEHICLE OFF. FIRE DEPARTMENT CALLED & PUT FLAMES OUT. VEHICLE TOWED TO DEALERSHIP. MECHANIC INDICATED A SPARK CAUSED FUEL PUMP TO IGNITE & THE ELECTRICAL WIRES BURNED. WIRING HARNESS, ANTI-LOCK BRAKE SENSORS, FUEL PUMP, FUEL FILTER, AND FUEL TANK WERE ALL DAMAGED. *AK *ML
A SPARK FROM AN UNKNOWN SOURCE IGNITED GASOLINE FROM A SMALL LEAK IN THE FUEL PUMP AND RESULTED IN THE MINIVAN CATCHING ON FIRE. THE WIRING OF THE VEHICLE WAS ALSO BURNED IN THE FIRE. THE REPAIR SHOP WHO INTIALLY LOOKED AT THE VEHICLE FELT IT WOULD BE BETTER FOR CHRYSLER TO PERFORM THE REPAIR WORK DUE TO THE WIRING BEING INVO…
Read full complaint
A SPARK FROM AN UNKNOWN SOURCE IGNITED GASOLINE FROM A SMALL LEAK IN THE FUEL PUMP AND RESULTED IN THE MINIVAN CATCHING ON FIRE. THE WIRING OF THE VEHICLE WAS ALSO BURNED IN THE FIRE. THE REPAIR SHOP WHO INTIALLY LOOKED AT THE VEHICLE FELT IT WOULD BE BETTER FOR CHRYSLER TO PERFORM THE REPAIR WORK DUE TO THE WIRING BEING INVOLVED. OUR LOCAL CHRYSLER DEALERSHIP REFUSED TO ALLOW THE CAR TO BE TOED TO THE DEALERSHIP UNTIL NATIONAL CHRYSLER SENT OUT AN INVESTIGATOR TO DETERMINE THE CAUSE OF THE FIRE. WE HAVE BEEN PROVIDED LITTLE INFORMATION FROM CHRYSLER OTHER THAN THEIR BELIEF THE FIRE WAS NOT DUE TO A MANUFACTURING PROBLEM. THEY HAVE NOT STATED WHAT THEY BELIEVE CAUSED THE FIRE AND THE DELAY IN GETTING OUR VEHICLE REPAIRED WAS OVER 1 WEEK. WE HAVE YET TO GET THE VEHICLE BACK! *AK
Official recalls
402V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.