IllustrationIF THE VAN GOES THROUGH A PUDDLE IN THE ROAD AIR CONDITIONER COMPRESSOR BELT SLIDES OFF ENGINE. WHEN THIS OCCURS VFEHICLE LOSES POWER STEERING AND STALLS BECAUSE THE BATTERY IS DRAINED. *AK
1997 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1997 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 261 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports15 fire reports12 injury reports
Electrical System complaints
42 reportsAIRBAG LIGHT STAYS ON WHILE DRIVING MOST OF THE TIME. HORN AND CRUISE CONTROL HAS STOPPED WORKING COMPLETELY.*AK
FUEL GAUGE INTERMITTENT NON-FUNCTIONAL. INCREASINGLY MORE FREQUENT ENGINE DYING EPISODES, THEN IS ABLE TO RESTART AFTER 5-10 MINUTES REST PERIOD. MIL LAMP CODE READS BATTERY POWER DISCONNECT TO PCM DURING PREVIOUS 40 ENGINE CRANKS. I SUSPECT A FAULTY RELAY( SWITCH) COMPONENT THAT FAILS AT CERTAIN VOLTAGES AND AFTER EQUILIBRATIO…
Read full complaint
FUEL GAUGE INTERMITTENT NON-FUNCTIONAL. INCREASINGLY MORE FREQUENT ENGINE DYING EPISODES, THEN IS ABLE TO RESTART AFTER 5-10 MINUTES REST PERIOD. MIL LAMP CODE READS BATTERY POWER DISCONNECT TO PCM DURING PREVIOUS 40 ENGINE CRANKS. I SUSPECT A FAULTY RELAY( SWITCH) COMPONENT THAT FAILS AT CERTAIN VOLTAGES AND AFTER EQUILIBRATION REST PERIOD ITS VALUE RETURNS TO NORMAL AND RESTARTS (ALLOWS CURRENT TO PASS THROUGH FROM BATTERY. SOURCE TO PCM AND INTO IGNITION CIRCUIT). *NLM
WHEN CAR IS SLOWING TO MAKE A TURN, THE WINDSHIELD WIPERS COME ON. THE SERVICE ENGINE LIGHT STAYS ON. WHEN A DIAGNOSTIC TEST WAS PERFORMED, THE CODE WHICH CAME UP INDICATED A PROBLEM DID NOT EXIST. IT WAS DETERMINED A SHORT CAUSED THE WINDSHIELD WIPERS AND ENGINE LIGHT TO STAY ON. WHEN THE COMPUTER WAS RESET, THE LIGHT CAME…
Read full complaint
WHEN CAR IS SLOWING TO MAKE A TURN, THE WINDSHIELD WIPERS COME ON. THE SERVICE ENGINE LIGHT STAYS ON. WHEN A DIAGNOSTIC TEST WAS PERFORMED, THE CODE WHICH CAME UP INDICATED A PROBLEM DID NOT EXIST. IT WAS DETERMINED A SHORT CAUSED THE WINDSHIELD WIPERS AND ENGINE LIGHT TO STAY ON. WHEN THE COMPUTER WAS RESET, THE LIGHT CAME BACK ON IN A MATTER OF MINUTES. I DO NOT THINK THIS PROBLEM IS DUE TO AGE OF THE CAR. MANY OF MY FRIENDS WHO HAVE THESE SAME AUTOS HAVE THE SAME PROBLEM. TO CORRECT THE PROBLEM WILL REQUIRE AN EXTENSIVE SEARCH OF THE ELECTRICAL WIRING AND IS PERFORMED ON AN HOURLY RATE. THIS COULD WELL COST HUNDREDS IF NOT THOUSANDS OF DOLLARS TO TRACK DOWN THE PROBLEM. I AM UNABLE TO SELL MY VEHICLE DUE TO THE PROBLEM WITHOUT SPENDING A LARGE SUM OF MONEY TO CORRECT THE PROBLEM. THIS PROBLEM BEGAN SEVERAL YEARS AGO, BUT WAS ONLY SPORADIC. IT DID NOT OCCUR ENOUGH TO WARRANT A SEARCH. IN THE PAST YEAR IT HAS BECOME ROUTINE. WHAT CAN PLYMOUTH CORPORATION DO TO CORRECT THIS PROBLEM WITHOUT THE EXPENSE BEING THAT OF THE OWNER. THE MECHANIC AT THE SHOP ALSO INDICATED THAT HE WAS COMPLETELY FAMILIAR WITH THIS PROBLEM OCCURRING IN MOST VANS OF THIS AGE. PLEASE ADVISE WHAT THE NEXT STEP SHOULD BE. *JB
AIRBAG LIGHT ILLUMINATED, HORN NOT FUNCTIONING, CONCERN OF SAFETY OF VEHICLE. *AK
AIRBAG LIGHT HAS COME ON AND HORN STOPPED WORKING. VEHICLE HAS NOT BEEN EXAMINED BY A DEALER.*AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
ENGINE AND AIR CONDITIONER WERE RUNNING. CONSUMER TURNED OFF ENGINE, BUT NOT AIR CONDITIONER. CONSUMER LATER TRIED TO START THE VEHICLE, BUT IT WOULD NOT START. THE CONSUMER HAD GOTTEN OUT, AND SAW FLAMES UNDER THE HOOD. THE WIRES UNDER FUSE BLOCK WERE BURNING. CONSUMER WAS ABLE TO PUT FIRE OUT. *AK DEALER REPAIRED BURNED W…
Read full complaint
ENGINE AND AIR CONDITIONER WERE RUNNING. CONSUMER TURNED OFF ENGINE, BUT NOT AIR CONDITIONER. CONSUMER LATER TRIED TO START THE VEHICLE, BUT IT WOULD NOT START. THE CONSUMER HAD GOTTEN OUT, AND SAW FLAMES UNDER THE HOOD. THE WIRES UNDER FUSE BLOCK WERE BURNING. CONSUMER WAS ABLE TO PUT FIRE OUT. *AK DEALER REPAIRED BURNED WIRING AT PDC AND REPLACED TWO 40 AMP FUSES IN PDC. *SCC
NO SUMMARY LISTED FOR ABVE VEHICLE. *AK
I USED TO BE A MACHANIC, I HAVE TAKEN THE DEFECTIVE CLOCKSPRING ASSY APART AND FOUND THAT THE WIRING HARNESS THAT IS SUPPOSE TO WIND & UNWIND--I FOUND AN AREA THAT WAS BENDING/KINKED INSTEAD SO IT WAS JUST A MATTER OF TIME TILL TURNING THE STEERING WHEEL ENOUGH THE WIRES WOULD BREAK. IN MY OPINION THIS IS A DEFECTIVE PART AND SI…
Read full complaint
I USED TO BE A MACHANIC, I HAVE TAKEN THE DEFECTIVE CLOCKSPRING ASSY APART AND FOUND THAT THE WIRING HARNESS THAT IS SUPPOSE TO WIND & UNWIND--I FOUND AN AREA THAT WAS BENDING/KINKED INSTEAD SO IT WAS JUST A MATTER OF TIME TILL TURNING THE STEERING WHEEL ENOUGH THE WIRES WOULD BREAK. IN MY OPINION THIS IS A DEFECTIVE PART AND SINCE IT PLYS A PART IN THE PROPER FUNCTION OF THE AIRBAG SYSTEM AND HORN THIS IS RELATED TO A SAFETY ITEM.. I DID SEE ON YOUR WEB SITE THAT THERE IS AN INVESTIGATION ON THIS RIGHT NOW.*AK
Official recalls
402V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.