NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
42 reportsClear category filterMileage unknown · Feb 1, 2000
Fuel System, GasolineStructureVisibility
THE FUEL PUMP FAILURE (TWICE) IS NOT ONLY INCOVENIENT AND EXPENSIVE THE 2ND TIME(NOT UNDER WARRANTY), BUT IT ALSO CAN BE DANGEROUS IF IT OCCURS AT THE WRONG TIME, LIKE DURING PASSING. THE WINDSHIELD WIPERS RANDOMLY TURN-ON IS MORE ANNOYING THAN DANGEROUS. I DO KNOW A FEW MORE OWNERS IN CENTRAL WISCONSIN THAT HAVE THE SAME PROB…
Read full complaint
THE FUEL PUMP FAILURE (TWICE) IS NOT ONLY INCOVENIENT AND EXPENSIVE THE 2ND TIME(NOT UNDER WARRANTY), BUT IT ALSO CAN BE DANGEROUS IF IT OCCURS AT THE WRONG TIME, LIKE DURING PASSING. THE WINDSHIELD WIPERS RANDOMLY TURN-ON IS MORE ANNOYING THAN DANGEROUS. I DO KNOW A FEW MORE OWNERS IN CENTRAL WISCONSIN THAT HAVE THE SAME PROBLEM. MY SLIDING DOOR ELECTRONIC LOCK PROBLEM IS A THEFT ISSUE--THE DOORS CAN'T BE LOCKED WHEN THE LOCKS MALFUNCTION-- AND BOTH SLIDING DOORS MALFUNCTIONED DURING THE LAST YEAR- AGAIN NOT UNDER WARRANTY.
NHTSA ODI #718145
Mileage unknown · Dec 3, 1999
Structure
POWER DOOR LOCK ACTUATOR FAILED. MJS
NHTSA ODI #549804
Mileage unknown · Aug 26, 1999
Structure
NO SUMMARY
NHTSA ODI #710549
Mileage unknown · Jun 23, 1999
Structure
BOTH REAR SLIDING DOOR LOCK AND ARE INOPERATIVE. *ET
NHTSA ODI #782927
Mileage unknown · Jun 10, 1999
Electrical SystemEngine And Engine CoolingExterior Lighting
ALTHOUGH WE GOT OUR VEHICLE IN JUNE '96, WE'VE HAD REPEATED ELECTRICAL PROBLEMS. THE MOST SERIOUS WERE THE DASHBOARD LIGHTS FAILED SEVERAL TIMES, THE ELECTRICAL LOCKS ON THE SLIDING DOORS FAILED SEVERAL TIMES, THE WINDSHIELD WIPERS FAILED SEVEN TIMES!!!, THE RADIO WAS REPLACED, THE WATER PUMP WAS REPLACED, THE BATTERY WAS REP…
Read full complaint
ALTHOUGH WE GOT OUR VEHICLE IN JUNE '96, WE'VE HAD REPEATED ELECTRICAL PROBLEMS. THE MOST SERIOUS WERE THE DASHBOARD LIGHTS FAILED SEVERAL TIMES, THE ELECTRICAL LOCKS ON THE SLIDING DOORS FAILED SEVERAL TIMES, THE WINDSHIELD WIPERS FAILED SEVEN TIMES!!!, THE RADIO WAS REPLACED, THE WATER PUMP WAS REPLACED, THE BATTERY WAS REPLACED, THE BODY MODULE WAS REPLACED 20AUG97, SLIDING DOORS HAD TO BE ADJUSTED TO OPEN PROPERLY 07OCT97 MILEAGE 9502, POWER DISTRIBUTION CENTER WAS REPLACED 11DEC97 MILEAGE 10360, HAD TO HOLD TURN SIGNAL STALK DOWN TO KEEP HIGH BEAMS ON AT NIGHT DUE TO FAULTY MUTI-FUNCTION SWITCH ON SEVERAL OCCASIONS, HEATER HOSE HAD TO BE REPLACED 24FEB99 MILEAGE 18494. *AK
NHTSA ODI #707431
Mileage unknown · Oct 16, 1998
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
ELECTRICAL SYSTEM MALFUNCTIONS CAUSING WINDSHIELD WASHERS TO GO ON FOR NO REASON AND ELECTRIC DOOR LOCKS THAT WILL NOT LOCK.
NHTSA ODI #542049
Mileage unknown · Jun 6, 1998
Structure
INTERIOR DOOR HANDLE FAILED.
NHTSA ODI #536676
Mileage unknown · Feb 14, 1998
Structure
DRIVER SIDE SLIDING DOOR FAILURE.
NHTSA ODI #530716
Mileage unknown · Nov 5, 1997
Engine And Engine CoolingEquipmentLatches/locks/linkages
DOOR LOCK FAILURE/ HANDLE RELEASE DOES NOT ENGAGE FROM INSIDE VEHICLE. MJS
NHTSA ODI #605529
Mileage unknown · Oct 21, 1997
Structure
AUTOMATIC DOOR LOCKS FAILED.
NHTSA ODI #604794
Official recalls
9Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 9, 1999
VEHICLE DESCRIPTION: MINIVANS. FUEL CAN LEAK FROM THE FUEL TANK AT THE INTERFACE OF THE FUEL PUMP MODULE ATTACHMENT.
Consequence & remedy
Consequence: IF A FUEL LEAK OCCURS IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE ATTACHING NUT WITH A NUT THAT INCLUDES TIGHTER DESIGN TOLERANCES. THE SEALING O-RING WILL ALSO BE REPLACED.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Jul 18, 1996
THE BOLTS WHICH SECURE THE INTEGRATED CHILD SEAT MODULES TO THE SEAT FRAME CAN BREAK.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE ACCIDENT, THE CHILD SEAT MAY NOT PROVIDE ADEQUATE PROTECTION TO THE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTEGRATED CHILD SEAT MODULE BOLTS.
Jan 16, 1996
A STATIC ELECTRIC CHARGE CAN BUILD UP ON THE UNGROUNDED METAL SECTION OF THE FUEL FILLER TUBE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A SPARK TO OCCUR WHEN FUELING THE VEHICLE AND POSSIBLY IGNITE THE FUEL VAPORS.
Remedy: DEALERS WILL INSTALL A GROUND STRAP FOR THE FUEL FILLER TUBE.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Dec 8, 1995
THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE INCREASES THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER TUBE WITH A FILLER TUBE THAT HAS AN ADDITIONAL ROLLOVER VALVE. THE ASSOCIATED ROLLOVER VALVE VAPOR HOSES WILL BE REROUTED.
Nov 28, 1995
THE BOLTS WHICH SECURE THE REAR BENCH SEATS TO THE SEAT RISERS MAY BE EMBRITTLED AND FRACTURE.
Consequence & remedy
Consequence: IN CASE OF AN ACCIDENT, THE BOLT MAY FAIL AND CAN CAUSE THE SEAT TO BREAK AWAY FROM THE SEAT RISERS, WHICH INCREASES THE POTENTIALOF INJURY TO ITS OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE REAR BENCH SEAT TO RISER BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration