IllustrationWHILE DRIVING OIL BEGAN TO LEAK FROM THE VEHICLE. *NLM
1994 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1994 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 198 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports3 fire reports13 injury reports
What owners actually said
198 reportsTHE TRANSMISSION WAS REPLACED 3 TIMES.*JB
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE TRANSMISSION. CONSUMER ALSO STATED THAT THE VEHICLES TRANSMISSION HAS BEEN REPLACE THREE TIMES. DEALER WAS CONTACTED AND STATED THAT THERE IS NOTHING THAT THEY CAN DO . *NLM
NO FAILURE ON THIS VEHICLE I OWN A VEHICLE WITH GEN 3 SEAT BELTS SUBJECT TO A CLASS ACTION LAWSUIT, AND I AM REPORTING THIS TO THE NHTSA. DT
AS I WAS DRIVING THE VEHICLE I NOTICED THAT THE AIRBAG LIGHT ON THE DASH CAME ON. THAN LATER ON I ALSO NOTICED THAT MY REAR WINDOW WIPER BLADE WAS NOT WORKING. I WAS TOLD BY A FRIEND THAT IT COULD BE A WIRING PROBLEM THAT THE MANUFACTURER SHOULD REPLACE. DT
THE METAL TUBE WHICH SUPPLIES COOLANT TO THE REAR HEATER BEGAN TO LEAK DUE TO CORROSION, THE DEALER REPLACED THE TUBE, HOWEVER ABOUT THREE AND A HLF YEARS LATER IT BEGAN CORRODING AGAIN, THE CONSUMER REQUESTED THAT THE DEALER/MANUFACTURER CONTRIBUTE TO THE COST OF THE REPAIR BUT IT WAS REJECTED. NLM
PULLED OUT OF THE DRIVEWAY THE MORNING OF JANUARY 8, 2002 AND INTO TRAFFIC. FELT A HARD JERK AND HEARD A STRANGE WINDING NOISE. THE TRANSMISSION WOULD NOT SHIFT OUT OF FIRST GEAR. TOOK THE VAN TO THE DEALER AND THEY SAID THE TRANSMISSION WAS SHOT FROM AN INTERNAL FAILURE AND WOULD NEED A NEW TRANSMISSION. THE DEALER INSTALLED A…
Read full complaint
PULLED OUT OF THE DRIVEWAY THE MORNING OF JANUARY 8, 2002 AND INTO TRAFFIC. FELT A HARD JERK AND HEARD A STRANGE WINDING NOISE. THE TRANSMISSION WOULD NOT SHIFT OUT OF FIRST GEAR. TOOK THE VAN TO THE DEALER AND THEY SAID THE TRANSMISSION WAS SHOT FROM AN INTERNAL FAILURE AND WOULD NEED A NEW TRANSMISSION. THE DEALER INSTALLED A NEW TRANSMISSION AT A COST OF $2147.28 WITH A 3 YEAR / 36,000 MILE WARRANTY.*AK
WHILE DRIVING 30 MPH BELT TENSIONER BROKE, CAUSING VEHICLE TO LOSE STEERING AND BRAKES.*AK *MJ
THE PART THAT HAD BEEN REPLACED IS COONDIERED A NON-WEAR ITEM. THIS PART SHOULD NOT HAVE BROKEN IN HALF. I CURRENTLY HAVE AN APPOINTMENT WITH THE DEALER BECAUSE I SUSPECT THIS PART IS BROKEN AGAIN. I WANTED TO SEE IF THE NHTSA HAD RECEIVED ANY OTHER COMPLAINTS, AND TO SEE IF THERE IS RECOURSE BACK TO THE MANUFACTURER FOR THE …
Read full complaint
THE PART THAT HAD BEEN REPLACED IS COONDIERED A NON-WEAR ITEM. THIS PART SHOULD NOT HAVE BROKEN IN HALF. I CURRENTLY HAVE AN APPOINTMENT WITH THE DEALER BECAUSE I SUSPECT THIS PART IS BROKEN AGAIN. I WANTED TO SEE IF THE NHTSA HAD RECEIVED ANY OTHER COMPLAINTS, AND TO SEE IF THERE IS RECOURSE BACK TO THE MANUFACTURER FOR THE FAILURE OF THE TORSION BAR. THANK YOU FOR TAKING MY CONCERN...PATRICK ADAMO 574-257-3153. *AK
CONSUMER STATED VEHICLE WAS TAKEN TO THE DEALER TO HAVE RECALL 99V113000 PERFORMED, HOWEVER THE PART THAT WAS NEEDED HAD TO BE ORDERED, AND CONSUMER WAS INFORMED THAT WHEN THE PART CAME IN HE WOULD RECEIVE A CALL, CONSUMER NEVER RECEIVED A CALL, CONSUMER TOOK THE VEHICLE BACK TO THE DEALER REGARDING ANOTHER RECALL AND THEN MENTI…
Read full complaint
CONSUMER STATED VEHICLE WAS TAKEN TO THE DEALER TO HAVE RECALL 99V113000 PERFORMED, HOWEVER THE PART THAT WAS NEEDED HAD TO BE ORDERED, AND CONSUMER WAS INFORMED THAT WHEN THE PART CAME IN HE WOULD RECEIVE A CALL, CONSUMER NEVER RECEIVED A CALL, CONSUMER TOOK THE VEHICLE BACK TO THE DEALER REGARDING ANOTHER RECALL AND THEN MENTIONED THE AIRBAG RECALL AND THAT THE LIGHT WAS COMING ON INTERMITTENTLY, THE DEALER STATED THE PART WOULD HAVE TO BE ORDERED, CONSUMER WAS THEN INFORMED THAT THE PROBLEM WITH THE AIRBAG WAS NOT RELATED TO THE RECALL, AND THE CONSUMER WOULD BE RESPONSIBLE FOR THE REPAIRS, CONSUMER WAS INFORMED THAT THE CLOCKSPRING NEEDED TO BE REPLACED.*JB
Official recalls
400V305000 · Steering: Steering Wheel/handle Bar
Oct 12, 2000
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
99V213000 · Structure:body:hatchback/liftgate:hinge And Attachments
Sep 2, 1999
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
99V113000 · Air Bags
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
93V215000 · Wheels:lugs/nuts/bolts/studs
Dec 14, 1993
WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Consequence & remedy
Consequence: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Remedy: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.