NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
510 reportsMileage unknown · Aug 4, 2009
Exterior Lighting
THE BLINKER SWITCH ISN'T WORKING PROPERLY. IT STARTED ABOUT A MONTH AGO AND I REPLACED THE BULB FOUR TIMES AND NOW WHEN I TRY TO REPLACE IT DOESN'T DO ANYTHING. I HAVE NOTICED ALL INTRIGUES HAVING THE SAME PROBLEM AS I HAVE ASKED THEM IF THAT WAS THE CASE. I TOOK IT TO AN AUTOMOTIVE MECHANIC AND THEY SAID THAT IT WAS A DEFECTIV…
Read full complaint
THE BLINKER SWITCH ISN'T WORKING PROPERLY. IT STARTED ABOUT A MONTH AGO AND I REPLACED THE BULB FOUR TIMES AND NOW WHEN I TRY TO REPLACE IT DOESN'T DO ANYTHING. I HAVE NOTICED ALL INTRIGUES HAVING THE SAME PROBLEM AS I HAVE ASKED THEM IF THAT WAS THE CASE. I TOOK IT TO AN AUTOMOTIVE MECHANIC AND THEY SAID THAT IT WAS A DEFECTIVE TURN SIGNAL SWITCH. THAT NEEDS TO BE REPLACED. *TR
NHTSA ODI #10279360
109,300 miles · Aug 2, 2009
Engine And Engine CoolingFire
THERE WERE NO EVENTS LEADING UP TO THE ENGINE COMPARTMENT FIRE ON MAY 29TH AT ABOUT 10:00PM. EXCEPT THAT PRIOR TO THE INCIDENT WHENEVER THE VEHICLE WAS DRIVEN THERE WAS A BURNING ODOR INSIDE THE VEHICLE. WE HAD A RECALL DONE ON THE VEHICLE THAT WE THOUGHT WOULD CORRECT THE BURNING ODOR BUT IT HOWEVER DIDN'T FIX THAT. THE RECA…
Read full complaint
THERE WERE NO EVENTS LEADING UP TO THE ENGINE COMPARTMENT FIRE ON MAY 29TH AT ABOUT 10:00PM. EXCEPT THAT PRIOR TO THE INCIDENT WHENEVER THE VEHICLE WAS DRIVEN THERE WAS A BURNING ODOR INSIDE THE VEHICLE. WE HAD A RECALL DONE ON THE VEHICLE THAT WE THOUGHT WOULD CORRECT THE BURNING ODOR BUT IT HOWEVER DIDN'T FIX THAT. THE RECALL NUMBER WAS 09047. WE HAD A SMALL ENGINE COMPARTMENT FIRE IN MAY OF 2007 BUT THERE WASN'T ANY DAMAGE. HOWEVER, WITH THE ENGINE COMPARTMENT FIRE OR THERMAL EVENT AS GM CALLS IT THERE WAS MAJOR DAMAGE TOTALING THE VEHICLE AS WHEN THE OIL DRIPS DOWN ON TO THE HOT EXHAUST MANIFOLD THERE WAS NO WHERE FOR THE OIL TO DRIP DOWN TO THE GROUND SO THEREFORE IT RESULTED IN A FIRE. THE RECALL #09047 DID NOTHING TO SOLVE THE BURNING ODOR SMELL OR AN ENGINE COMPARTMENT FIRE. THE VEHICLE DID HAVE SMALL AMOUNTS OF SMOKE THAT WOULD COME OUT OF THE ENGINE COMPARTMENT WHEN IT WAS DRIVEN STARTING 6 MONTHS PRIOR TO THE FINAL ENGINE COMPARTMENT FIRE ON JUNE 29, 2009. THEN AFTER THE RECALL WAS DONE WAS WHEN WE STARTED NOTICING THE BURNING ODOR OR SMELL WHEN THE VEHICLE WAS DRIVEN. *TR
NHTSA ODI #10279099
150,000 miles · Jul 21, 2009
Electrical SystemEngine And Engine CoolingFire
I RECEIVED A LETTER IN MAY STATING THAT GM WAS RECALLING MY CAR FOR POSSIBLE ENGINE FIRES (RECALL 09047). I CALLED THE NUMBER PROVIDED AND WAS ROUTED TO ONE OF THE LOCAL DEALERS, WHO TOLD ME THAT THEY COULDN'T DO ANYTHING WITH IT UNTIL LATE JULY OR AUGUST AND TO CALL BACK FOR AN APPOINTMENT THEN. YESTERDAY, 7/20/09, MY CAR BURNE…
Read full complaint
I RECEIVED A LETTER IN MAY STATING THAT GM WAS RECALLING MY CAR FOR POSSIBLE ENGINE FIRES (RECALL 09047). I CALLED THE NUMBER PROVIDED AND WAS ROUTED TO ONE OF THE LOCAL DEALERS, WHO TOLD ME THAT THEY COULDN'T DO ANYTHING WITH IT UNTIL LATE JULY OR AUGUST AND TO CALL BACK FOR AN APPOINTMENT THEN. YESTERDAY, 7/20/09, MY CAR BURNED TO A CRISP. ACCORDING TO THE FIREMEN, IT WAS AN ELECTRICAL FIRE THAT STARTED UNDER THE HOOD SOMEWHERE AND IT BURNED SO HOT AND SO FAST THAT THEY WERE UNABLE TO SALVAGE IT. THE FIRE ENGINES ARE KEPT LITERALLY A BLOCK AWAY FROM WHERE THE FIRE OCCURRED. THEY RESPONDED WITHIN MINUTES AND STILL THE ENTIRE ENGINE CONTENTS FRIED RIGHT UP. MY CAR IS A TOTAL LOSS. TODAY I HAVE SPENT JUST OVER TWO HOURS ON THE PHONE WITH GM CUSTOMER SERVICE, I HAVE HAD TO ESCALATE THE CALLS TWICE AND CALL BACK TO THEM TWICE AND ONCE TO THE LOCAL DEALER AND ALL ANYONE WILL SAY IS THEY WILL CONTACT ME WITHIN 5 BUSINESS DAYS AND TO SAVE THE VEHICLE SO THEY CAN INVESTIGATE IT. I HAVE NOWHERE TO STORE THIS CAR IN IT'S CURRENT STATE. IT IS A MAJOR FIRE HAZARD-ESPECIALLY WITH OUR CURRENT WARM WEATHER/DRY CONDITIONS AND IT'S FULL TANK OF GAS. GM INFORMED ME THAT IF I MAKE THE DECISION TO HAVE IT MOVED TO A JUNK YARD TO TAKE LOTS OF PICTURES BEFORE THAT HAPPENS. I INFORMED THEM THAT I CANNOT KEEP THE VEHICLE HERE, DUE TO IT'S FIRE HAZARD TO THE OTHER RESIDENTS ON MY BLOCK-THEIR HALF A MILLION DOLLAR HOMES AND THEIR VEHICLES THAT ARE PARKED IN THE SAME AREA. *TR
NHTSA ODI #10277577
80,000 miles · Jul 17, 2009
Electrical System
CAR REFUSES TO START, LEAVING DRIVER HELPLESS. OCCURS INTERMITTENTLY WITHOUT WARNING (MORE FREQUENTLY OVER TIME). RESEARCH ON INTERNET IDENTIFIES THIS AS A COMMON PROBLEM WITH GM PASSLOCK. ALTHOUGH A COMMON PROBLEM IT IS UNCLEAR WHAT THE PROBLEM REALLY IS - SEEMS THE SOLUTION IS TO HAVE THE SYSTEM REPLACED BY THE DEALER. TH…
Read full complaint
CAR REFUSES TO START, LEAVING DRIVER HELPLESS. OCCURS INTERMITTENTLY WITHOUT WARNING (MORE FREQUENTLY OVER TIME). RESEARCH ON INTERNET IDENTIFIES THIS AS A COMMON PROBLEM WITH GM PASSLOCK. ALTHOUGH A COMMON PROBLEM IT IS UNCLEAR WHAT THE PROBLEM REALLY IS - SEEMS THE SOLUTION IS TO HAVE THE SYSTEM REPLACED BY THE DEALER. THIS IS EXTREMELY DANGEROUS TO A VULNERABLE PERSON DEPENDENT UPON THE AUTOMOBILE. *TR
NHTSA ODI #10277070
145,000 miles · Jul 10, 2009
Engine And Engine CoolingFire
I HAD BOUGHT A 98 OLDSMOBILE INTRIGUE AROUND THE MIDDLE OF JANUARY FROM A PRIVATE OWNER OUT OF THE CLASSIFIEDS. ABOUT 2 WEEKS LATER, THE DAY I GOT INDUCED TO HAVE A CHILD, MY CAR HAD STARTED A FIRE IN THE HOSPITAL PARKING LOT. THEN IN MAY, I GOT A SAFETY RECALL NOTICE IN THE MAIL. I WANTED TO KNOW WHAT EXACTLY I CAN DO TO FIX TH…
Read full complaint
I HAD BOUGHT A 98 OLDSMOBILE INTRIGUE AROUND THE MIDDLE OF JANUARY FROM A PRIVATE OWNER OUT OF THE CLASSIFIEDS. ABOUT 2 WEEKS LATER, THE DAY I GOT INDUCED TO HAVE A CHILD, MY CAR HAD STARTED A FIRE IN THE HOSPITAL PARKING LOT. THEN IN MAY, I GOT A SAFETY RECALL NOTICE IN THE MAIL. I WANTED TO KNOW WHAT EXACTLY I CAN DO TO FIX THIS PROBLEM, WE HAD TO JUNK THE CAR BECAUSE IT WAS NOT FIXABLE. I DO STILL HAVE THE TITLE THOUGH. *TR
NHTSA ODI #10276344
52,363 miles · Jun 30, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE UPPER AND LOWER INTAKE MANIFOLDS NEEDED TO BE REPLACED. THE CONTACT HAS HAD THE PART REPLACED ON THREE DIFFERENT OCCASIONS,…
Read full complaint
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE UPPER AND LOWER INTAKE MANIFOLDS NEEDED TO BE REPLACED. THE CONTACT HAS HAD THE PART REPLACED ON THREE DIFFERENT OCCASIONS, WHICH ORIGINATED WITH THE CHECK ENGINE LIGHT ILLUMINATING. THE CURRENT MILEAGE WAS 117,000 AND FAILURE MILEAGE WAS 52,363.
NHTSA ODI #10275310
143,000 miles · Jun 28, 2009
Engine And Engine CoolingFire
I WAS THE SECOND OWNER AND BOUGHT THE CAR IN FEBRUARY 2003. HAD TO REPLACE THE RADIATOR TWICE. KEPT HAVING TROUBLE WITH THE TEMPERATURE SHOWING HIGH. 06 BOUGHT A RADIATOR. SUMMER OF 08 GOING UP ESCONDIDO MTN TRAVELING TO CALIFORNIA... CAUGHT FIRE. HAD TO REPLACE THE EXHAUST MANIFOLD. ENGINE TEMP KEPT READING HIGH AND SERVIC…
Read full complaint
I WAS THE SECOND OWNER AND BOUGHT THE CAR IN FEBRUARY 2003. HAD TO REPLACE THE RADIATOR TWICE. KEPT HAVING TROUBLE WITH THE TEMPERATURE SHOWING HIGH. 06 BOUGHT A RADIATOR. SUMMER OF 08 GOING UP ESCONDIDO MTN TRAVELING TO CALIFORNIA... CAUGHT FIRE. HAD TO REPLACE THE EXHAUST MANIFOLD. ENGINE TEMP KEPT READING HIGH AND SERVICE COULD NOT FIND THE REASON WHY. REPLACED RADIATOR AGAIN AND TRAVELING TO NM MAY 2009 THE TEMP KEPT READING HIGH AGAIN AND I HAD TO PULL OVER AND THEN STAY IN SECOND GEAR WITH THE HEATER ON FULL BLAST. FINALLY HAD TO REPLACE THE VEHICLE. THE INTRIGUE WAS A VERY NICE CAR WITH LEATHER SEATS AND DROVE REALLY GOOD WHEN IT WAS WORKING CORRECTLY, BUT SINCE THE ENGINE FIRE I'VE HAD NOTING BUT TROUBLE AND MAINTENANCE REPAIRS. CAN I BE REIMBURSED AT ALL FOR ANY OF THOSE EXPENSES? *TR
NHTSA ODI #10275130
127,873 miles · Jun 19, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING). THE CONTACT TOOK HIS VEHICLE TO THE DEALER FOR THE RECALL REPAIR, BUT THE PARTS WERE UNAVAILABLE. WHILE DRIVING 60 MPH, THE VEHICLE CAUGHT FIRE. THE CONTACT PULLED THE VEHIC…
Read full complaint
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING). THE CONTACT TOOK HIS VEHICLE TO THE DEALER FOR THE RECALL REPAIR, BUT THE PARTS WERE UNAVAILABLE. WHILE DRIVING 60 MPH, THE VEHICLE CAUGHT FIRE. THE CONTACT PULLED THE VEHICLE OVER AND EXTINGUISHED THE FIRE BEFORE THE FIRE DEPARTMENT ARRIVED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE FAILURE MILEAGE WAS 127,873.
NHTSA ODI #10274305
104,000 miles · Jun 5, 2009
Engine And Engine CoolingFireInjury
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. WHILE DRIVING 3 MPH, THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE CONTACT STOPPED THE VEHICLE AND EXTINGUISHED THE FIRE WITH A RAG. HE BURNED HIS FINGERS IN THE PROCESS. HE ALLOWED THE VEHICLE TO COOL DOWN AND NOTICED THAT IT STARTED BACK UP ROUGHLY. HE THEN TAPED THE TWO BURNE…
Read full complaint
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. WHILE DRIVING 3 MPH, THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE CONTACT STOPPED THE VEHICLE AND EXTINGUISHED THE FIRE WITH A RAG. HE BURNED HIS FINGERS IN THE PROCESS. HE ALLOWED THE VEHICLE TO COOL DOWN AND NOTICED THAT IT STARTED BACK UP ROUGHLY. HE THEN TAPED THE TWO BURNED SPARK PLUGS. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000. THE DEALER REPAIRED THE SPARK PLUGS. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 104,000.
NHTSA ODI #10272925
80,000 miles · May 29, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. A FEW MINUTES AFTER THE VEHICLE WAS PARKED IN THE GARAGE, IT CAUGHT FIRE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A REPORT WAS FILED AND THERE WERE NO INJURIES. THE FIRE OCCURRED IN AUGUST OF 2008. THE CONTACT CALLED THE MANUFACTURER AND THEY STATED THAT THEY CO…
Read full complaint
TL*THE CONTACT OWNS A 1998 OLDSMOBILE INTRIGUE. A FEW MINUTES AFTER THE VEHICLE WAS PARKED IN THE GARAGE, IT CAUGHT FIRE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A REPORT WAS FILED AND THERE WERE NO INJURIES. THE FIRE OCCURRED IN AUGUST OF 2008. THE CONTACT CALLED THE MANUFACTURER AND THEY STATED THAT THEY COULD NOT ASSIST BECAUSE THE VEHICLE WAS TOO OLD. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10272372
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
May 18, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
PE99016 · Rear Safety Belt Malfunction
Opened Feb 25, 1999 · Closed Jul 7, 1999
Status: closed (inferred from source dates) · Seat Belts:rear/other
There is no summary currently available
Illustration