NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
16 reportsClear category filter117,000 miles · Jul 10, 2014
Electrical System
GENERAL MOTORS RECENTLY RECALLED THE 1997-2005 CHEVROLET MALIBU FOR THE IGNITION SWITCH PROBLEM. I OWN THE SISTER VEHICLE WHICH IS A 1998 OLDSMOBILE CUTLASS. THIS VEHICLE IS THE IDENTICAL LAYOUT OF THE CHEVROLET MALIBU WHICH HAS BEEN RECALLED. I SENT A COUPLE OF E-MAIL MESSAGES TO THE GM CUSTOMER ASSISTANCE CENTER AND JUST RECEI…
Read full complaint
GENERAL MOTORS RECENTLY RECALLED THE 1997-2005 CHEVROLET MALIBU FOR THE IGNITION SWITCH PROBLEM. I OWN THE SISTER VEHICLE WHICH IS A 1998 OLDSMOBILE CUTLASS. THIS VEHICLE IS THE IDENTICAL LAYOUT OF THE CHEVROLET MALIBU WHICH HAS BEEN RECALLED. I SENT A COUPLE OF E-MAIL MESSAGES TO THE GM CUSTOMER ASSISTANCE CENTER AND JUST RECEIVED A PHONE CALL EXPLAINING TO ME THAT AT THIS TIME THEY HAD NO INTENTION OF DOING A RECALL ON THE OLDSMOBILE CUTLASS FOR THE IGNITION SWITCH. EVEN THOUGH I HAVE NOT ENCOUNTERED A PROBLEM WITH MY IGNITION SWITCH AS OF YET, I DEEM IT A SAFETY ISSUE WHICH GM SHOULD FIX. I DO NOT KNOW IF ANYONE ELSE HAS COMPLAINED OF SIMILAR ISSUES AS MINE, BUT I WANTED TO INFORM YOU OF MY CONCERNS. I DO NOT KNOW IF THIS IS THE PROPER FORUM FOR THIS, SO IF NOT, PLEASE FORWARD MY CONCERNS TO THE PROPER AUTHORITIES. THANK YOU *TR
NHTSA ODI #10609708
70,000 miles · Mar 31, 2014
Electrical System
HAVE HAD IGNITION SWITCH JUST SHUT OFF DRIVING DOWN THE ROAD. EXACTLY AS DESCRIBED IN GM'S RECENT RECALL ON IGNITION SWITCHES ON NEWER CARS. LOSES ALL ELECTRICAL POWER AND ENGINE SHUTS OFF. HAS HAPPENED NUMEROUS TIMES WHILE I HAVE OWNED IT FOR THE LAST 10 OR SO YEARS. WHEN IT HAPPENS I JUST QUICKLY PUT IT IN NEUTRAL AND RESTART …
Read full complaint
HAVE HAD IGNITION SWITCH JUST SHUT OFF DRIVING DOWN THE ROAD. EXACTLY AS DESCRIBED IN GM'S RECENT RECALL ON IGNITION SWITCHES ON NEWER CARS. LOSES ALL ELECTRICAL POWER AND ENGINE SHUTS OFF. HAS HAPPENED NUMEROUS TIMES WHILE I HAVE OWNED IT FOR THE LAST 10 OR SO YEARS. WHEN IT HAPPENS I JUST QUICKLY PUT IT IN NEUTRAL AND RESTART IMMEDIATELY. THIS IS A 1998 OLDS CUTLASS. IT IS APPARENT THAT GM'S PROBLEM WITH THEIR IGNITION SWITCH GOES BACK A LOT FARTHER THAN THEY CARE TO ADMIT. *TR
NHTSA ODI #10576006
Mileage unknown · Dec 4, 2008
Electrical System
I WORK FOR A IGNITION INTERLOCK COMPANY. I HAVE SEEN SEVERAL VEHICLES ENTER THE SERVICE CENTER WITH PROBLEMS WITH THE IGNITION SWITCH. THE KEY HAS TO BE SHAKEN SEVERAL TIMES IN ORDER TO GET THE KEY TO TURN TO START THE VEHICLE. THESE IGNITIONS ARE MOUNTED TO THE RIGHT OF THE STEERING COLUMN. I HAVE NOTICED IT ON ALMOST EVERY VEH…
Read full complaint
I WORK FOR A IGNITION INTERLOCK COMPANY. I HAVE SEEN SEVERAL VEHICLES ENTER THE SERVICE CENTER WITH PROBLEMS WITH THE IGNITION SWITCH. THE KEY HAS TO BE SHAKEN SEVERAL TIMES IN ORDER TO GET THE KEY TO TURN TO START THE VEHICLE. THESE IGNITIONS ARE MOUNTED TO THE RIGHT OF THE STEERING COLUMN. I HAVE NOTICED IT ON ALMOST EVERY VEHICLE THAT HAS THE IGNITION MOUNTED TO THE RIGHT OF THE STEERING COLUMN NOT ON THE COLUMN. THAT IS AN OLDSMOBILE. I OWN THE 1998 OLDMOBILE CUTLASS. WAS THERE EVER A RECALL AS DEFECT OF THIS IGNITION AND IS THE DEALERSHIP RESPONSIBLE FOR REPLACEMENT? IF I EVER HAD AN EMERGENCY I WOULD NOT BE ABLE TO START MY CAR RIGHT AWAY AS IT AT TIMES TAKES UP TO FIVE TO TEN MINUTES TO GET THE KEY TO TURN. *TR
NHTSA ODI #10250738
Mileage unknown · Mar 24, 2006
Electrical System
THEFT-LIGHT CAME ON FOR NO APPARENT REASON. HAD TO WAIT TEN MINUTES FOR SYSTEM TO RESET BEFORE STARTING CAR. HAD KEY-LOCK CYLINDER REPLACED TWICE, FOR A TOTAL OF OVER $1400 IN REPAIRS. NOW THE LIGHT IS ON SEEMINGLY PERMANENTLY. ALWAYS WONDER IF IT WILL START OR NOT. CAN'T GET ANYONE BESIDES A DEALER TO EVEN LOOK AT IT. THE…
Read full complaint
THEFT-LIGHT CAME ON FOR NO APPARENT REASON. HAD TO WAIT TEN MINUTES FOR SYSTEM TO RESET BEFORE STARTING CAR. HAD KEY-LOCK CYLINDER REPLACED TWICE, FOR A TOTAL OF OVER $1400 IN REPAIRS. NOW THE LIGHT IS ON SEEMINGLY PERMANENTLY. ALWAYS WONDER IF IT WILL START OR NOT. CAN'T GET ANYONE BESIDES A DEALER TO EVEN LOOK AT IT. THE DEALER HAS ENOUGH OF MY MONEY FOR NOW...I HAVE TO DEAL WITH BEING INCONVENIENCED REGULARLY BY THIS PROBLEM. *JB
NHTSA ODI #10153655
Mileage unknown · Mar 13, 2005
Electrical SystemEngine And Engine CoolingEquipment
I CURRENTLY HAVE THE FOLLOWING PROBLEMS WITH MY 1998 OLDS CUTLASS GL. MY POWER STEERING IS STIFF AND MAKES A "WAILING" NOISE. MY COOLENT SYSTEM HAS A LEAK. MY HEAT AND AIR HAVE COMPLETEY STOPPED WORKING. I HAVE HAD PROBLEMS (IN THE PAST THAT HAVE BEEN REPAIRED_ WITH MY POWER WINDOW LOCKING UP (DRIVERS SIDE). THE SOUND SYSTEM S…
Read full complaint
I CURRENTLY HAVE THE FOLLOWING PROBLEMS WITH MY 1998 OLDS CUTLASS GL. MY POWER STEERING IS STIFF AND MAKES A "WAILING" NOISE. MY COOLENT SYSTEM HAS A LEAK. MY HEAT AND AIR HAVE COMPLETEY STOPPED WORKING. I HAVE HAD PROBLEMS (IN THE PAST THAT HAVE BEEN REPAIRED_ WITH MY POWER WINDOW LOCKING UP (DRIVERS SIDE). THE SOUND SYSTEM SHORTED OUT. THE CD PLAYER QUIT WORKING. I HAVE REPLACED MY WIPER BLADES SEVERAL TIMES AND THEY STILL DO NOT CLEAR THE WINDSHIELD COMPLETELY. ONE TIME WHEN MY TEENS WERE USING MY CAR, THEY WERE ON THE INTERSTATE AND THE CAR WENT COMPLETELY DEAD...NOT ONLY WERE THEY TERRIFIED, IT WAS A VERY DANGEROUS SITUATION FOR THEM TO BE IN.*AK
NHTSA ODI #10114007
Mileage unknown · Oct 12, 2004
Electrical System
PERIODICALLY MY THEFT LIGHT COMES ON FOR NO APPARENT REASON, WHICH PREVENTS ME FROM STARTING MY VEHICLE UNTIL THE LIGHT STOPS FLASHING. THIS TAKES 15 MIN. AND IS VERY INCONVENIENT. IT HAPPENS UP TO FOUR TIMES OR MORE A MONTH!! *NM
NHTSA ODI #10095654
45,000 miles · Sep 9, 2003
Electrical System
ANTI-THEFT CONTROLLER DISABLES THE IGNITION PERIODICALLY FOR NO APPARENT REASON. REQUIRES THE DRIVER TO WAIT 15 MINUTES BEFORE THE SYSTEM RESETS AND ALLOWS THE CAR TO START. *AK
NHTSA ODI #10037540
Mileage unknown · Jun 7, 2003
Electrical System
MY ALARM DEFAULT ALONE-THEFT SYSTEM LIGHT BLINKS AND MY AUTO WILL NOT START UNTIL IT STOP BLINKING WHICH IS 10 MIN LONG. *JB
NHTSA ODI #10021188
Mileage unknown · Jun 11, 2002
Electrical System
POSTIVE BATTERY CABLE BROKE WHILE DRIVING. EVERYTHING SHUTDOWN AND DRIVER LOST CONTROL OF VEHICLE.*AK *YH
NHTSA ODI #8011486
Mileage unknown · Dec 7, 2001
Electrical SystemService Brakes, HydraulicSteering
ENGINE(IGNITION) QUITS WHILE CAR IS BEING DRIVEN. ALL POWER SYSTEMS ARE LOST, MAKING STEERING AND BRAKING DIFFICULT. ENGINE RESTARTS WHEN KEY IS TURNED OFF AND THEN TURNED ON TO RESTART. THIS IS AN ELECTRICAL OR COMPUTER PROBLEM THAT SEEMS TO BE RESET WHEN THE IGNITION SWITCH IS TURNED OFF AND THEN ON AGAIN. COULD BE A VERY DANG…
Read full complaint
ENGINE(IGNITION) QUITS WHILE CAR IS BEING DRIVEN. ALL POWER SYSTEMS ARE LOST, MAKING STEERING AND BRAKING DIFFICULT. ENGINE RESTARTS WHEN KEY IS TURNED OFF AND THEN TURNED ON TO RESTART. THIS IS AN ELECTRICAL OR COMPUTER PROBLEM THAT SEEMS TO BE RESET WHEN THE IGNITION SWITCH IS TURNED OFF AND THEN ON AGAIN. COULD BE A VERY DANGEROUS SITUATION.
NHTSA ODI #755405
Official recalls
2Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA99030 · Oversensitive Air Bag Deployment
Opened Oct 29, 1999 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE99037 · Inadvertent Air Bag Deployments
Opened May 19, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
Illustration