Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
325–50K
2050–75K
3575–100K
59100–150K
14150K+
132 reports with mileage · 189 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports31 fire reports10 injury reports
What owners actually said
321 reports
Mileage unknown · Jun 21, 2004
Fuel System, Gasoline
CONSUMER HAS THE SAME PROBLEM AS MENTIONED IN NHTSA RECALL #04V110000. VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK AT UNUSUALLY HIGH RATES. …
Read full complaint
CONSUMER HAS THE SAME PROBLEM AS MENTIONED IN NHTSA RECALL #04V110000. VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK AT UNUSUALLY HIGH RATES. DEALER INDICATED YOUR VEHICLE IS NOT INCLUDE IN THIS RECALL DUE TO THE VIN. *AK
NHTSA ODI #10079550
100,000 miles · Jun 15, 2004
Fuel System, GasolineFire
UPON STARTING THE VEHICLE,THE ENGINE CAUGHT FIRE BECAUSE OF THE FAILURE DESCRIBED IN THE FUEL RAIL TUBING RECALL (RECALL NUMBER 04V1110000); HOWEVER, THE VEHICLE'S VIN ISN'T INCLUDED IN THE RECALL. *LA
NHTSA ODI #10076237
109,500 miles · Jun 14, 2004
Fuel System, Gasoline
CONSUMER COMPLAINED ABOUT A FUEL RAIL LEAK. A RECALL WAS ISSUED ON THIS PROBLEM. CONSUMER CONTACTED THE MANUFACTURER. HOWEVER, MANUFACTURER NOTIFIED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
NHTSA ODI #10076220
Mileage unknown · Jun 14, 2004
Fuel System, Gasoline
WHEN STARTING THE VEHICLE CONSUMER SMELLEDA GAS ODOR INSIDE OF THE VEHICLE. CONSUMER TURNED THE VEHICLE OFF, AND HAD THE VEHICLE TOWED TO THE DEALER. MECHANIC DETERMINED THAT THE FUEL RAIL FAILED. *AK
NHTSA ODI #10076169
130,000 miles · Jun 11, 2004
Fuel System, Gasoline
WHILE DRIVING FUEL RAIL LEAKED. CONSUMER SMELLED GAS FUMES INSIDE THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10076117
Mileage unknown · Jun 10, 2004
Fuel System, Gasoline
WHEN DRIVING THE VEHICLE, THE DRIVER WOULD SMELL FUMES COMING FROM THE VENTS. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE OWNER THAT THE FUEL RAIL HAD FAILED. *AK
NHTSA ODI #10076054
Mileage unknown · Jun 10, 2004
Fuel System, Gasoline
WHEN WALKING TO THE VEHICLE, THE CONSUMER NOTICED GAS LEAKING FROM UNDER NEATH. THE CONSUMER OPENED THE HOOD AND SAW GAS LEAKING ONTO THE ENGINE. THE OWNER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE OWNER THAT THE FUEL RAIL HAD FAILED. *AK
NHTSA ODI #10076053
115,000 miles · Jun 9, 2004
Fuel System, Gasoline
CONSUMER SMELLED FUEL FUMES ON THE OUTSIDE AND INSIDE OF THE VEHICLE. IT WAS TAKEN TO THE DEALERSHIP. UPON INSPECTION OF THE FUEL FUMES ODOR DEALERSHIP INDICATED THAT THE PLASTIC FUEL INJECTION LINES WERE CREATING FUEL LEAKS. *AK
NHTSA ODI #10075979
Mileage unknown · Jun 9, 2004
Fuel System, Gasoline
WHEN STARTING THE VEHICLE CONSUMER SMELLED A GAS ODOR COMING FROM THE VEHICLE. CONSUMER OPENED THE HOOD, AND SAW GAS SPILLING ONTO THE ENGINE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL RAIL FAILED. *AK
NHTSA ODI #10075942
Mileage unknown · Jun 9, 2004
Fuel System, Gasoline
WHEN STARTING THE VEHICLE CONSUMER SMELLED A GAS ODOR COMING FROM THE VEHICLE. CONSUMER OPENED THE HOOD, AND SAW GAS SPILLING ONTO THE ENGINE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINE D THAT THE FUEL RAIL FAILED. *AK
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SHOULDER BELT(S) DO NOT RETRACT. A RETAINER COULD SEPARATE FROM A REAR SEAT SHOULDER BELT RETRACTOR WHICH RESULTS IN THE RETRACTOR RETURN SPRING BECOMING DISENGAGED.
Consequence & remedy
Consequence: IN A CRASH, AN OCCUPANT MAY RECEIVE MORE SEVERE INJURIES IF THERE IS EXCESSIVE SLACK IN THE SHOULDER BELT.
Remedy: DEALERS WILL INSPECT BOTH REAR SHOULDER BELT RETRACTORS FOR CORRECT FUNCTION AND INSTALL A SPRING COVER RETAINING STRAP TO EACH RETRACTOR. IF A RETRACTOR DOES NOT FUNCTION CORRECTLY, IT WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA00006 · Rear Seat Belt Retractor
Opened Feb 22, 2000 · Closed Mar 6, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
IN ITS LETTER DATED FEBRUARY 25, 2000 TO NHTSA, GENERAL MOTORS STATED THAT IT WILL CONDUCT A SAFETY RECALL OF 85,253 MODEL YEAR 1995 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES FOR THE DEFECT IN THE OUTBOARD REAR SEAT BELT RETRACTOR ASSEMBLIES.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
SQ96012 · Rear Compartment Lid Rod Separation
Opened Jun 25, 1996 · No close date supplied
Status: open (inferred from source dates) · Structure
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.
1995 Oldsmobile Aurora Problems, Complaints & Recalls | Skip That Year
Illustration