IllustrationWHEN STARTING THE VEHICLE CONSUMER SMELLED A GAS ODOR COMING FROM THE VEHICLE. CONSUMER OPENED THE HOOD, AND SAW GAS SPILLING ONTO THE ENGINE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL RAIL FAILED. *AK
1995 Oldsmobile Aurora
Owner reports · Recalls · Investigations
More warning signs than most Aurora years
Owner complaints for the 1995 Oldsmobile Aurora are substantially higher than the model-year median of 33.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aurora years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
325–50K
2050–75K
3575–100K
59100–150K
14150K+
132 reports with mileage · 189 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports31 fire reports10 injury reports
Fuel System, Gasoline complaints
166 reportsWHEN STARTING THE VEHICLE CONSUMER SMELLED A GAS ODOR COMING FROM THE VEHICLE. CONSUMER OPENED THE HOOD, AND SAW GAS SPILLING ONTO THE ENGINE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINE D THAT THE FUEL RAIL FAILED. *AK
1995 OLDS ARUORA - FUEL RETURN LINE SPRAYING FUEL OVER ENGINE. OPENED HOOD TO CHANGE OIL AND NOTICED FUEL SPRAY. HAD TO TOW TO A DEALER. DEALER REPLACED CENTER FUEL LINE AND CLEANED INJECTORS. THINK PART #25604921 - GM SAYS THIS CAR VIN IS NOT UNDER THE CURRENT RECALL (04614 OR 04V11000) FOR THE SAME ISSUE. PAID $550 FOR REP…
Read full complaint
1995 OLDS ARUORA - FUEL RETURN LINE SPRAYING FUEL OVER ENGINE. OPENED HOOD TO CHANGE OIL AND NOTICED FUEL SPRAY. HAD TO TOW TO A DEALER. DEALER REPLACED CENTER FUEL LINE AND CLEANED INJECTORS. THINK PART #25604921 - GM SAYS THIS CAR VIN IS NOT UNDER THE CURRENT RECALL (04614 OR 04V11000) FOR THE SAME ISSUE. PAID $550 FOR REPAIR AND ALMOST MY SONS LIFE. *AK
FUEL LINE FUEL RAIL CRACKS LEAKING FUEL ON TOP OF MANIFOLD ,NOTICED FUEL SMELL N PASSANGER COMPARTMENT . AVE HAD TO REPAIR WITH PIECES OF FUEL LINE 7 TIMES WAITING ON RECALL ,ALLED GM THEY SAY NOT ACTIVE RECALL YET VERY DANGEROUS PROBLEM. *AK
CONSUMER'S VEHICLE EXPERIENCED THE SAME DEFECT AS MENTIONED IN NHTSA RECALLS 04V110000: VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. THIS VEHICLE NOT INCLUDED IN THE RECALL DUE TO VIN. *AK A STRONG SMELL OF GAS COULD BE SMELL INSI…
Read full complaint
CONSUMER'S VEHICLE EXPERIENCED THE SAME DEFECT AS MENTIONED IN NHTSA RECALLS 04V110000: VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. THIS VEHICLE NOT INCLUDED IN THE RECALL DUE TO VIN. *AK A STRONG SMELL OF GAS COULD BE SMELL INSIDE THE CABIN OF THE VEHICLE. IT WAS LATER DETERMINED THAT THERE WAS A CRACK IN THE FUEL RAIL WHICH CAUSED FUEL TO SATURATE THE ENGINE COMPARTMENT. THE RECALL INDICATED THAT THE NYLON TUBING MAY DEGRADE AND CRACK, BUT AS OF FEB 2004 THE ONLY PART AVAILABLE WAS MADE OF NYLON. *NM
CONSUMER'S VEHICLE EXPERIENCED THE SAME DEFECT AS MENTIONED IN NHTSA RECALLS 04V110000: VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *NM
WHILE DRIVING, THE CONSUMER NOTICED FUMES COMING FROM VEHICLE. THE CONSUMER PULLED OVER AND NOTICED THE FRONT END OF THE VEHICLE WAS POURING OUT GAS. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THE TECHNICIAN REPLACED THE FUEL RAIL. PLEASE PROVIDE FURTHER DETAILS. *MR
WHILE DRIVING, THE CONSUMER SMELLED GAS COMING FROM THE VEHICLE, THE CONSUMER STOPPED THE VEHICLE AND NOTICED GAS LEAKING ON THE ENGINE. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP. PLEASE ADD ANY FURTHER DETAILS. *JB
VEHICLE WAS HARD TO START, AND A GAS ODOR WAS COMING FROM THE VENTS. CONSUMER CONTACTED THE DEALER, AND WILL TAKE THE VEHICLE TO DEALER THE NEXT DAY FOR INSPECTION. *AK
THE VEHICLE EXPERIENCED THE SAME PROBLEM AND CONSEQUENCES AS DESCRIBED IN THE FUEL RAIL TUBING RECALL 04V110000, BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *JB
Official recalls
204V110000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 4, 2004
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
00V057000 · Seat Belts:front:webbing
Feb 28, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SHOULDER BELT(S) DO NOT RETRACT. A RETAINER COULD SEPARATE FROM A REAR SEAT SHOULDER BELT RETRACTOR WHICH RESULTS IN THE RETRACTOR RETURN SPRING BECOMING DISENGAGED.
Consequence & remedy
Consequence: IN A CRASH, AN OCCUPANT MAY RECEIVE MORE SEVERE INJURIES IF THERE IS EXCESSIVE SLACK IN THE SHOULDER BELT.
Remedy: DEALERS WILL INSPECT BOTH REAR SHOULDER BELT RETRACTORS FOR CORRECT FUNCTION AND INSTALL A SPRING COVER RETAINING STRAP TO EACH RETRACTOR. IF A RETRACTOR DOES NOT FUNCTION CORRECTLY, IT WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA00006 · Rear Seat Belt Retractor
Opened Feb 22, 2000 · Closed Mar 6, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
IN ITS LETTER DATED FEBRUARY 25, 2000 TO NHTSA, GENERAL MOTORS STATED THAT IT WILL CONDUCT A SAFETY RECALL OF 85,253 MODEL YEAR 1995 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES FOR THE DEFECT IN THE OUTBOARD REAR SEAT BELT RETRACTOR ASSEMBLIES.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
SQ96012 · Rear Compartment Lid Rod Separation
Opened Jun 25, 1996 · No close date supplied
Status: open (inferred from source dates) · Structure
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.