NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
13 reportsClear category filter135,000 miles · Apr 20, 2010
Engine And Engine CoolingEquipment
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THE VEHICLE WAS NOT RESPONDING BECAUSE THE SECURITY SYSTEM WAS UNDER THE IMPRESSION THE VEHICLE WAS STOLEN. THE CONTACT ADVISED THE FAILURE WOULD OCCUR…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THE VEHICLE WAS NOT RESPONDING BECAUSE THE SECURITY SYSTEM WAS UNDER THE IMPRESSION THE VEHICLE WAS STOLEN. THE CONTACT ADVISED THE FAILURE WOULD OCCUR INTERMITTENTLY AND WHEN DOING SO, THE SECURITY WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. IN ADDITION, WHEN SITTING IDLE WITH THE ENGINE RUNNING, THE VEHICLE WOULD OCCASIONALLY STALL. THE VEHICLE HAD NOT YET BEEN TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE FAILURE MILEAGE WAS 135,000 AND THE CURRENT MILEAGE WAS 136,000.
NHTSA ODI #10326678
42,000 miles · May 26, 2005
EquipmentService Brakes, Air
I HAVE OWNED THIS 01 ALERO FOR 7 MONTHS NOW AND HAVE HAD PROBLEMS SINCE DAY ONE. I FIRST HAD TO REPLACED THE FRONT BRAKES, CALIPERS & PADS & ROTORS. THEN MY ABS SPEED SENSOR WENT SO I HAD TO REPLACE THAT TOO. NOW WHENEVER I HIT THE BRAKES THEY GRIND AND SOMETIMES FAIL TO WORK. FOR A 01 THIS CAR HAS GIVEN ME WAY TOO MANY PRO…
Read full complaint
I HAVE OWNED THIS 01 ALERO FOR 7 MONTHS NOW AND HAVE HAD PROBLEMS SINCE DAY ONE. I FIRST HAD TO REPLACED THE FRONT BRAKES, CALIPERS & PADS & ROTORS. THEN MY ABS SPEED SENSOR WENT SO I HAD TO REPLACE THAT TOO. NOW WHENEVER I HIT THE BRAKES THEY GRIND AND SOMETIMES FAIL TO WORK. FOR A 01 THIS CAR HAS GIVEN ME WAY TOO MANY PROBLEMS. SOMETIMES I AM SCARED TO DRIVE IT IN BUMPER TO BUMPER TRAFFIC WITH THE FEAR OF THE BRAKES NOT WORKING!
NHTSA ODI #10122204
76,000 miles · May 31, 2004
Engine And Engine CoolingEquipment
I HAVE HAD TO REPLACE 4 ENGINES 2.4L ON MY 2001 OLDSMOBILE ALERO. MY LAST ENGINE LASTED 32 DAYS AFTER I SPENT 1200$ AND NOW I NEED TO HAVE WORK DONE TO IT AGAIN. *AK
NHTSA ODI #10074521
Mileage unknown · May 17, 2004
Electrical SystemEngine And Engine CoolingEquipment
THE TECHNICIAN INFORMED THE CONSUMER ABOUT A RECALL ON THE VEHICLE, BUT THE CONSUMER NEVER RECEIVED A NOTICE FROM THE MANUFACTURER. *LA THE VEHICLE WOULD NOT START RIGHT AWAY. THERE WOULD BE SEVERAL TRIES BUT THE VEHICLE WOULD NEVER "CRANK OVER." THE ENGINE VIBRATED WHEN THE A/C WAS USED,THE FUEL GAUGE WAS INOPERATIVE, THE …
Read full complaint
THE TECHNICIAN INFORMED THE CONSUMER ABOUT A RECALL ON THE VEHICLE, BUT THE CONSUMER NEVER RECEIVED A NOTICE FROM THE MANUFACTURER. *LA THE VEHICLE WOULD NOT START RIGHT AWAY. THERE WOULD BE SEVERAL TRIES BUT THE VEHICLE WOULD NEVER "CRANK OVER." THE ENGINE VIBRATED WHEN THE A/C WAS USED,THE FUEL GAUGE WAS INOPERATIVE, THE FRONT WINDOWS WOULD NOT ROLL DOWN, THE REAR HANDLES FELT LIKE THEY WERE STICKING, THERE WAS A BURNT OIL SMELL, AND AFTER SEVERAL TIMES OF STARTING THE VEHICLE IT WOULD RUN ROUGH. THE MASTER SWITCH, A/C COMPRESSOR, CRANK SENSOR, FUEL PUMP, FUEL TANK, HAZARD SWITCH, AND THE WINDOW REGULATOR WERE REPLACED. THE MECHANICS REPOSITIONED A WIRE HARNESS FROM THE CRANK SENSOR AND REPLACED THE PRESSURE CONTROL SOLENOID. THE TURN SIGNALS STOPPED WORKING IN TRAFFIC IN WHICH THERE WAS ALMOST AN ACCIDENT. THE ANTENNA WAS REPLACED BECAUSE THE RADIO SIGNAL WOULD GO OUT EVERY TIME THE REAR DEFROSTER WAS USED (THIS DID NOT SOLVE THE PROBLEM). THE BACK WINDOW HAD TO BE COMPLETELY REPLACED TO SOLVE THE ANTENNA PROBLEM. THE WATER PUMP WAS REPLACED BECAUSE THE SEAL FOR THE COOLANT LEAKED. *SC *JB
NHTSA ODI #10074104
25,000 miles · Jan 12, 2004
Equipment
THE HEATING/AIR CONDITIONING FAN CONTROL KNOB ONLY WORKS ON THE 3RD OR 4TH SELECTION. IT STARTED ABOUT 6 MONTHS AGO AND KEEPS MOVING UP A NOTCH. THIS IS TO BE TRUE ON SEVERAL ALERO'S OF THIS YEAR. WILL THERE BE A RECALL ON THIS? *LA
NHTSA ODI #10052983
Mileage unknown · Sep 30, 2003
Electrical SystemEquipmentExterior Lighting
CONSUMER HAD ELECTRICAL PROBLEMS SINCE SHE PURCHASED THE VEHICLE. SOME OF THE PROBLEMS INCLUDED THE FOLLOWING; ROAD HAZARD LIGHT SHORTED OUT WHICH CAUSED ALL DASHBOARD LIGHTS AND EXTERNAL LIGHTS TO NOT WORK/ AIR CONDITIONER (A/C) UNIT SHORTED OUT/ RADIO AUTOMATICALLY RESET ITSELF AT WILL, AND BLINKER LIGHTS WORKED SOME TIM…
Read full complaint
CONSUMER HAD ELECTRICAL PROBLEMS SINCE SHE PURCHASED THE VEHICLE. SOME OF THE PROBLEMS INCLUDED THE FOLLOWING; ROAD HAZARD LIGHT SHORTED OUT WHICH CAUSED ALL DASHBOARD LIGHTS AND EXTERNAL LIGHTS TO NOT WORK/ AIR CONDITIONER (A/C) UNIT SHORTED OUT/ RADIO AUTOMATICALLY RESET ITSELF AT WILL, AND BLINKER LIGHTS WORKED SOME TIMES AND SOME TIMES NOT. SHE HAD THIS VEHICLE IN REPAIR SHOP 5-6 TIMES FOR THE SAME PROBLEM, AND NO ONE COULD SOLVE THE PROBLEM.*AK
NHTSA ODI #10042019
Mileage unknown · Aug 28, 2003
Equipment
TRIM IS PEELING ON DOORS AND ON DASH.
NHTSA ODI #10036772
7,000 miles · Jul 17, 2003
Electrical SystemEquipmentTires
ELECTRICAL,TIRES,AIR CONDITIONER. *AK
NHTSA ODI #10028520
Mileage unknown · Jun 4, 2003
EquipmentService Brakes, Hydraulic
THE BRAKES ON THE OLDS ALERO HAVE A DESIGN FLAW IN THE BRAKES. THE ROTORS TEND TO OVERHEAT UNDER NORMAL DRIVING USE. IT WEARS THE PADS DOWN FASTER THAN THEY SHOULD, WARPS THE ROTORS SO THAT THEY HAVE TO BE TURNED EVERY SINGLE TIME YOU REPLACE THE PADS... AND I DO MEAN HAVE TO BE. THE ROTORS WILL QUICKLY LOSE THICKNESS, AND …
Read full complaint
THE BRAKES ON THE OLDS ALERO HAVE A DESIGN FLAW IN THE BRAKES. THE ROTORS TEND TO OVERHEAT UNDER NORMAL DRIVING USE. IT WEARS THE PADS DOWN FASTER THAN THEY SHOULD, WARPS THE ROTORS SO THAT THEY HAVE TO BE TURNED EVERY SINGLE TIME YOU REPLACE THE PADS... AND I DO MEAN HAVE TO BE. THE ROTORS WILL QUICKLY LOSE THICKNESS, AND THE THINNER THEY ARE AFTER EACH TURN THE QUICKER THEY WILL WARP UNDER NORMAL USE. CONTACTING GENERAL MOTORS HAS ACCOMPLISHED NOTHING... DESPITE THE FACT THAT UNDER THE 2000 MODEL THEY HAD A TECHNICAL SERVICE BULLETIN (FRONT DISC BRAKE PULSATION (NEW ROTOR RUN-OUT SPECIFICATION AND CORRECTION METHOD) #00-05-23-002A) ISSUED FOR THE CAR. TO MY KNOWLEDGE GENERAL MOTORS HASN'T ALTERED THE DESIGN OF THE CAR SINCE IT'S INCEPTION WITH EXCEPTION OF COSMETIC CHANGES. THEY REFUSE TO ADMIT THERE'S A DESIGN FLAW IN THE BRAKES THAT FORCES THE CONSUMER TO EITHER PAY OUTRAGEOUS PRICES EACH AND EVERY TIME THEY NEED BRAKE PADS... OR DISCARD THE MANUFACTURERS WARRANTY AND PURCHASE AFTERMARKET BRAKE SOLUTIONS TO ELIMINATE THE ISSUE ENTIRELY. *NLM
NHTSA ODI #10021002
Mileage unknown · Apr 15, 2003
Electrical SystemEquipment
IN FEB. 2003 I HAD SURGERY AND DID NOT DRIVE MY CAR FOR ABOUT A WEEK. WHEN I FINALLY DROVE MY CAR, MY DRIVERS SIDE WINDOW WOULD NOT ROLL DOWN. A COUPLE OF DAYS LATER IT STARTED WORKING AND NOW HAS A GRINDING NOISE TO IT. RECENTLY MY HORN STOPPED WORKING COMPLETELY. I REPLACED THE RELAY SWITCH AND IT STILL WILL NOT WORK. NOW, MY…
Read full complaint
IN FEB. 2003 I HAD SURGERY AND DID NOT DRIVE MY CAR FOR ABOUT A WEEK. WHEN I FINALLY DROVE MY CAR, MY DRIVERS SIDE WINDOW WOULD NOT ROLL DOWN. A COUPLE OF DAYS LATER IT STARTED WORKING AND NOW HAS A GRINDING NOISE TO IT. RECENTLY MY HORN STOPPED WORKING COMPLETELY. I REPLACED THE RELAY SWITCH AND IT STILL WILL NOT WORK. NOW, MY TURN SIGNALS WORK WHENEVER THEY WANT TO. THE ONLY WAY I CAN GET THEM TO WORK IS TO PRESS MY HAZARD SWITCH AND NOW IT IS GETTING TO WHERE IT WILL NOT WORK. AND LAST BUT NOT LEAST MY AIR CONDITIONER IS NOT BLOWING PROPERLY. ON THE 2 FIRST SETTINGS IT BARELY BLOWS, IF I PRESS ON MY BRAKES IT FEELS AS IF IT COMPLETELY QUITS. I HAVE ALSO NOTICED THAT WHEN I ROLL DOWN MY WINDOWS THE INTERIOR LIGHTS WILL DIM AND THE CAR ENGINE POWER WILL DECLINE. I HAVE HAD MY CAR FOR 1 YR. I PURCHASED IT USED WITH LESS THAN 25,000 MILES. I FEEL THESE ISSUES SHOULD BE ADDRESSED BECAUSE THEY CAN LEAD TO SAFETY ISSUES. I WAS CHANGING LANES AND MY BLINKERS FAILED AND WAS ALMOST HIT BY ANOTHER CAR, AT THAT TIME AND STILL DO NOT HAVE A HORN TO BLOW TO WARN THEM THAT I WAS CHANGING LANES ALSO. THE DEALER I PURCHASED THE CAR FROM THINKS THAT I AM CRAZY. THAT I AM A HYPOCONDRIAC. THEY ARE UNCOOPERATIVE AND BASICALLY REFUSE TO HELP ME. I FEEL I SHOULD NOT HAVE TO PAY FOR SOMETHING THAT APPARENTLY A LOT OF ALERO OWNERS ARE GOING THROUGH. *JB
NHTSA ODI #10014392
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration