Illustration2001 OLDSMOBILE ALERO IGNITION SWITCH. *MW THE CONSUMER STATED THE IGNITION SWITCH WAS REPLACED IN NOVEMBER 2010, DUE TO THE VEHICLE STALLING WHEN PLACED IN REVERSE. ALSO, NONE OF THE GAUGES AND DASH LIGHTS WORKED, THE FUEL PRESSURE REGULATOR AND HEAD GASKET WERE REPLACED. *JB
2001 Oldsmobile Alero
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Oldsmobile Alero do not stand out strongly from the model-year median of 279.
About this comparison →How this year compares
Owner complaints by model year
Compare all Alero years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
4625–50K
5650–75K
2475–100K
45100–150K
21150K+
214 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports5 fire reports13 injury reports
Engine And Engine Cooling complaints
46 reportsI HAVE A 2001 OLD ALERO 6 MONTHS AGO MY VEHICLE WOULD NOT START I HAD IT TOWED TO A GM DEALER WHICH TOLD ME I NEEDED A FUEL PUMP SO I HAD IT FIXED WELL A FEW WEEKS LATER CAR WOULD START ONE DAY THEN NOTHING THE NEXT NOW IT WONT START AT ALL IT DIED WHILE I WAS DRIVING WITH MY 4 CHILDREN WE WERE STUCK FOR AN HOUR IN THE COLD I HA…
Read full complaint
I HAVE A 2001 OLD ALERO 6 MONTHS AGO MY VEHICLE WOULD NOT START I HAD IT TOWED TO A GM DEALER WHICH TOLD ME I NEEDED A FUEL PUMP SO I HAD IT FIXED WELL A FEW WEEKS LATER CAR WOULD START ONE DAY THEN NOTHING THE NEXT NOW IT WONT START AT ALL IT DIED WHILE I WAS DRIVING WITH MY 4 CHILDREN WE WERE STUCK FOR AN HOUR IN THE COLD I HAD IT TOWED TO MY MECHANIC HE SAYS IT THE SECURITY SYSTEM WELL IT WILL COST ALMOST 1000 DOLLARS TO FIX SO IT WILL SIT THERE UNTIL GM DECIDES TO DO A RECALL I AM NOT THE FIRST TO COMPLAIN AND I KNOW I WONT BE THE LAST THERE SHOULD BE SOMETHING DONE AS THIS IS A SAFETY ISSUE. *TR
I HAVE A 2001 OLDS ALERO I BOUGHT FOR MY DAUGHTER. IT HAS A PROBLEM WITH STARTING AND STALLING. BASED ON MY RESEARCH IT APPEARS TO BE A PROBLEM WITH THE PASSKEY SECURITY SYSTEM. I HAVE HAD THE CAR TOWED MULTIPLE TIMES, HAD IT IN THE SHOP MULTIPLE TIMES WITHOUT RESOLUTION. IT APPEARS TO BE A COMMON PROBLEM WITH GM CARS OF THIS ER…
Read full complaint
I HAVE A 2001 OLDS ALERO I BOUGHT FOR MY DAUGHTER. IT HAS A PROBLEM WITH STARTING AND STALLING. BASED ON MY RESEARCH IT APPEARS TO BE A PROBLEM WITH THE PASSKEY SECURITY SYSTEM. I HAVE HAD THE CAR TOWED MULTIPLE TIMES, HAD IT IN THE SHOP MULTIPLE TIMES WITHOUT RESOLUTION. IT APPEARS TO BE A COMMON PROBLEM WITH GM CARS OF THIS ERA. THERE IS NO SERVICE NOTICE AVAILABLE FROM GM ON HOW TO FIX THIS PROBLEM. THE CAR WILL JUST STOP SOMETIMES WHEN MY DAUGHTER IS DRIVING AND I FEAR IT COULD LEAD TO A CRASH OR INJURY. *KB
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE FUEL FILTER, BATTERY, IGNITION SWITCH AND STARTER WERE REPLACED. THE COMPUT…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE FUEL FILTER, BATTERY, IGNITION SWITCH AND STARTER WERE REPLACED. THE COMPUTER WAS RESET BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSIS BUT WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE CONTINUED TO STALL. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 143,000.
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THE VEHICLE WAS NOT RESPONDING BECAUSE THE SECURITY SYSTEM WAS UNDER THE IMPRESSION THE VEHICLE WAS STOLEN. THE CONTACT ADVISED THE FAILURE WOULD OCCUR…
Read full complaint
TL*THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THE VEHICLE WAS NOT RESPONDING BECAUSE THE SECURITY SYSTEM WAS UNDER THE IMPRESSION THE VEHICLE WAS STOLEN. THE CONTACT ADVISED THE FAILURE WOULD OCCUR INTERMITTENTLY AND WHEN DOING SO, THE SECURITY WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. IN ADDITION, WHEN SITTING IDLE WITH THE ENGINE RUNNING, THE VEHICLE WOULD OCCASIONALLY STALL. THE VEHICLE HAD NOT YET BEEN TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE FAILURE MILEAGE WAS 135,000 AND THE CURRENT MILEAGE WAS 136,000.
2001 OLDSMOBILE ALERO 3.4L V6 - ENGINE RACING - HIGH IDLE 2004-2010 THIS HAS BEEN AN OFF AND ON PROBLEM THE ENTIRE TIME I HAVE OWNED THE VEHICLE THE PAST 6 YEARS AND MIGHT HAPPEN FOR 2-3 WEEKS AND THEN NOT AGAIN FOR A FEW MONTHS. WHEN I START MY CAR IT WILL BE IDLING AT 3,500 RPMS OR MORE, IF I PUT IT IN DRIVE IT WILL GO BAC…
Read full complaint
2001 OLDSMOBILE ALERO 3.4L V6 - ENGINE RACING - HIGH IDLE 2004-2010 THIS HAS BEEN AN OFF AND ON PROBLEM THE ENTIRE TIME I HAVE OWNED THE VEHICLE THE PAST 6 YEARS AND MIGHT HAPPEN FOR 2-3 WEEKS AND THEN NOT AGAIN FOR A FEW MONTHS. WHEN I START MY CAR IT WILL BE IDLING AT 3,500 RPMS OR MORE, IF I PUT IT IN DRIVE IT WILL GO BACK TO 1,500 RPMS, BUT THE CAR WILL START TO ACCELERATE BY ITSELF (THE ACCELERATOR IS NOT BEING PUSHED AND IS NOT STUCK). IT TAKES ABOUT 20-30 SECONDS IF ON FLAT GROUND, BUT THE CAR WILL GET UP TO 55MPH BY ITSELF. IF I AM GOING DOWN HILL IT GOES EVEN FASTER. IF STOPPED AT A STOP LIGHT THE ENGINE SOUNDS LIKE IT IS TRYING TO GO 60MPHS. SOMETIMES THE PROBLEM CEASES IF I SHUT THE CAR OFF AND RESTART, BUT THIS DOES NOT ALWAYS WORK. I THINK IT IS HIGHLY UNSAFE AND WITH ALL OF THE RECENT TOYOTA PROBLEMS I THINK THIS SHOULD BE INVESTIGATED AS ONE OF MY COLLEGE FRIENDS HAS A SISTER WITH AN ALERO THAT HAS HAD THE SAME PROBLEM. PLEASE LET ME KNOW IF THERE HAS BEEN SOMETHING DONE ALREADY OR IF YOU HAVE HEARD SIMILAR COMPLAINTS. THANK YOU. *TR
01 ALERO WILL TURN OVER BUT NOT START. FIRST INCIDENT WAS IN 2006 REPLACED FUEL PUMP AND FUEL FILTER. SOME DAYS IT WILL START OTHERS IT WILL NOT. IT ALSO HAS DIED WHILE DRIVING TWICE. ONCE ON THE HIGHWAY AND ONCE IN TOWN. I WAS DRIVING ACROSS THE STREET WITH MY SON AND THE CAR DIED LUCKILY I COASTED OUT OF THE LINE OF TRAFFIC. F…
Read full complaint
01 ALERO WILL TURN OVER BUT NOT START. FIRST INCIDENT WAS IN 2006 REPLACED FUEL PUMP AND FUEL FILTER. SOME DAYS IT WILL START OTHERS IT WILL NOT. IT ALSO HAS DIED WHILE DRIVING TWICE. ONCE ON THE HIGHWAY AND ONCE IN TOWN. I WAS DRIVING ACROSS THE STREET WITH MY SON AND THE CAR DIED LUCKILY I COASTED OUT OF THE LINE OF TRAFFIC. FOR THE PAST WEEK IT HAS ONLY STARTED ONCE OUT OF MULTIPLE ATTEMPTS TO START IT. IT SHOWS CAM SENSOR, CRANK SENSOR, PASSLOCK, CODES WHEN DIAGNOSTICS RAN. OTHER SITES HAVE HAD SAME ISSUE WITH NOTHING BEING A PERMANENT SOLUTION TO PROBLEM. CAR NEEDS TO BE RECALLED. *TR
MY GIRLFRIEND BOUGHT A 2001 OLDSMOBILE ALERO FROM A DEALER WITH A 30 DAY WARRANTY. THE CARS ANTIFREEZE MIXES WITH THE OIL (HEAD GASKET) . HE NEVER FIXED THIS AND DISSAPEARED ON US. THIS WAS IN MARCH 09. I WAS TOLD THAT I MIGHT BE ABLE TO CONTACT GM AND THEY MIGHT BE ABLE TO FIX THIS PROBLEM. I'VE READ ONLINE THAT THIS CAR WAS R…
Read full complaint
MY GIRLFRIEND BOUGHT A 2001 OLDSMOBILE ALERO FROM A DEALER WITH A 30 DAY WARRANTY. THE CARS ANTIFREEZE MIXES WITH THE OIL (HEAD GASKET) . HE NEVER FIXED THIS AND DISSAPEARED ON US. THIS WAS IN MARCH 09. I WAS TOLD THAT I MIGHT BE ABLE TO CONTACT GM AND THEY MIGHT BE ABLE TO FIX THIS PROBLEM. I'VE READ ONLINE THAT THIS CAR WAS RECALLED BECAUSE OF NUMEROUS PROBLEMS. PLEASE CONTACT ME KEMA, CORNELL THANKS. *TR
ENGINE:ENGINE COOLING COOLANT LEAKS WHEN CAR IS IDLE. *TR
ENGINE TURNS OVER BUT WONT START UNTIL CRANKED ON FOR A MINUTE OR MORE. HAZARD RELAY CLICKS REPEATEDLY. *TR
Official recalls
414V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V327000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
00V372000 · Power Train:manual Transmission
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available