NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
32 reportsClear category filter129,000 miles · Feb 19, 2021
Fuel/propulsion System
YES IN THE 2005 NISSAN XTERRAS THERE IS NO FLOATING ARM DEVICE WITHIN THE FUEL SENDING UNIT. WHICH IS WHAT IS CAUSING THE VEHICLE TO HAVE THE FUEL GAUGE ON THE FRONT DASH PANEL TO READ INCORRECTLY TO THE ELECTRONIC SCREEN. IT ALSO DOESN'T REPORT YOUR DTE ON THE DASH PANEL BECAUSE THE FUEL SENDING UNIT HAS BEEN CORRODED, OR WAS M…
Read full complaint
YES IN THE 2005 NISSAN XTERRAS THERE IS NO FLOATING ARM DEVICE WITHIN THE FUEL SENDING UNIT. WHICH IS WHAT IS CAUSING THE VEHICLE TO HAVE THE FUEL GAUGE ON THE FRONT DASH PANEL TO READ INCORRECTLY TO THE ELECTRONIC SCREEN. IT ALSO DOESN'T REPORT YOUR DTE ON THE DASH PANEL BECAUSE THE FUEL SENDING UNIT HAS BEEN CORRODED, OR WAS MADE OF PLASTIC, AND HAS BEEN COMPLETELY DAMAGED. SO NOW WHEN THE VEHICLE SITS WHILE STARTED FOR A LONG PERIOD OF TIME THE FUEL GAUGE WILL GO TO EMPTY BUT REMAIN RUNNING, OR YOU COULD FILL YOUR VEHICLE UP ALL THE WAY WITH GAS, AND THEN WHEN YOU START THE XTERRA, THE VEHICLE WILL THEN SHOW EMPTY STILL UNTIL IT WAS AT 3 QUARTERS OF THE TANK, THEN IT WILL READ IT AT 3 QUARTERS OF A TANK UNTIL HALF A TANK. UNLESS THE VEHICLE SITS TO LONG WITHOUT MOVING, THEN VEHICLE WILL SHOW THE FUEL GAUGE ON THE FRONT DASH PANEL TO BE EMPTY. THIS IS UNSAFE BECAUSE IT WILL CAUSE NISSAN XTERRAS TO RUN OUT OF GAS ON THE ROAD WHICH COULD LEAD TO FRONT, SIDE, REAR, AND ROLLOVER CRASHES.
NHTSA ODI #11396894
121,000 miles · Oct 21, 2020
Electronic Stability Control (esc)Fuel/propulsion SystemPower Train
CAR CUTS OFF WHEN DRIVING AND WHILE CAR IS IDLED. FUELS STOPS REPEATEDLY WHEN REFUELING.
NHTSA ODI #11365644
Mileage unknown · Sep 14, 2020
Fuel/propulsion System
I HAVE THE SAME ISSUE AS DESCRIBED IN RECALL #10V075000. THIS AFFECTED 2006 NISSAN XTERRAS, MINE IS A 2005. THE FUEL GAUGE DROPS TO EMPTY WHEN THE TANK IS FILLED, AFTER DRIVING AWHILE IT STARTS TO CLIMB BACK UP TO READ NEAR FULL, THEN IT WILL APPEARS TO DECREASE AS NORMAL, BUT YOU NEVER KNOW HOW MUCH FUEL IS ACTUALLY IN THE TA…
Read full complaint
I HAVE THE SAME ISSUE AS DESCRIBED IN RECALL #10V075000. THIS AFFECTED 2006 NISSAN XTERRAS, MINE IS A 2005. THE FUEL GAUGE DROPS TO EMPTY WHEN THE TANK IS FILLED, AFTER DRIVING AWHILE IT STARTS TO CLIMB BACK UP TO READ NEAR FULL, THEN IT WILL APPEARS TO DECREASE AS NORMAL, BUT YOU NEVER KNOW HOW MUCH FUEL IS ACTUALLY IN THE TANK, SO YOU HAVE TO BASE IT ON MILES TRAVELED. THE PROBLEM IS YOU NEVER KNOW IF THE STATION ATTENDANT (I LIVE IN OR SO YOU CAN'T FILL YOUR OWN VEHICLE WITH GAS) HAS ACTUALLY FILLED THE TANK OR DID IT CLICK OFF EARLY AGAIN, WHICH IT FREQUENTLY DOES. SO YOU CAN RUN OUT OF GAS EASILY, BECAUSE YOU HAVE A FUEL GAUGE THAT DOESN'T FUNCTION CORRECTLY. THIS HAS BEEN GOING ON SINCE ABOUT 2011, BUT I'M TIRED OF DEALING WITH IT. DON'T KNOW THE ACTUAL DATE WHEN THIS PROBLEM STARTED, BUT IT HAS BEEN ONGOING.
NHTSA ODI #11355012
81,000 miles · Mar 27, 2018
Electrical SystemFuel/propulsion System
CHECK ENGINE LIGHT CAME. GAS GAUGE READS EMPTY EVEN AFTER YOU FILL IT UP COMPLETELY. DIAGNOSTIC CODE P0463, FUEL LEVEL SENSOR. THE FUEL GAUGE DOES NOT ACCURATELY STATE THE AMOUNT OF FUEL IN THE TANK. THIS ISSUE IS KNOWN TO NISSAN AND NHTSA. IT IS A SAFETY ISSUE AS YOU NEVER KNOW HOW MUCH GAS IS LEFT IN THE TANK OR HOW MANY MILES…
Read full complaint
CHECK ENGINE LIGHT CAME. GAS GAUGE READS EMPTY EVEN AFTER YOU FILL IT UP COMPLETELY. DIAGNOSTIC CODE P0463, FUEL LEVEL SENSOR. THE FUEL GAUGE DOES NOT ACCURATELY STATE THE AMOUNT OF FUEL IN THE TANK. THIS ISSUE IS KNOWN TO NISSAN AND NHTSA. IT IS A SAFETY ISSUE AS YOU NEVER KNOW HOW MUCH GAS IS LEFT IN THE TANK OR HOW MANY MILES YOU CAN GO. THIS WAS PREVIOUSLY RECALLED FOR CERTAIN 2006, 2007 AND 2008 XTERRAS. NOT SURE WHY IT HASN'T BEEN FOR THE 2005 MODEL YEAR AS IT IS THE SAME ISSUE.
NHTSA ODI #11081532
140,000 miles · Feb 26, 2018
Fuel/propulsion System
THE VEHICLE IN QUESTION STARTED TO LOSE POWER WHEN DRIVING THIS PAST SATURDAY. SO, BASICALLY MY CAR DOES START THEN AFTER DRIVING IT A FEW MINUTES OR MORE WILL STIFFEN AND CUT OFF. THANK YOU
NHTSA ODI #11075033
65,000 miles · Jun 30, 2017
Fuel/propulsion System
WHILE DRIVING MY XTERRA WHICH HAS 65000 MILES APPROXIMATELY, MY GAS GAUGE DROPPED FROM 3/4 TANK TO BELOW EMPTY. MY CHECK ENGINE LIGHT CAME ON AND MY CAR IMMEDIATELY STOPPED IN THE ROAD. I HAD TO BE TOWED WHERE I WAS TOLD I HAVE P0463 AND MY CAR WAS OUT OF GAS. I WAS TOLD THIS IS A MAJOR PROBLEM WITH. ISSA XTERRA. I WENT TO DEAL…
Read full complaint
WHILE DRIVING MY XTERRA WHICH HAS 65000 MILES APPROXIMATELY, MY GAS GAUGE DROPPED FROM 3/4 TANK TO BELOW EMPTY. MY CHECK ENGINE LIGHT CAME ON AND MY CAR IMMEDIATELY STOPPED IN THE ROAD. I HAD TO BE TOWED WHERE I WAS TOLD I HAVE P0463 AND MY CAR WAS OUT OF GAS. I WAS TOLD THIS IS A MAJOR PROBLEM WITH. ISSA XTERRA. I WENT TO DEALER TO GET IT REPLACED AND THEY SAID $700. I SEE THAT THIS IS TOO COMMON AN ISSUE. I THINK THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THIS DEFECT. I'M JUST HAPP HAPPY I WASN'T DRIVING ON THE HIGHWAY WHEN IT STOPPED. LUCKILY I WAS ON SIDE ROAD.
NHTSA ODI #11002577
41,500 miles · Mar 21, 2017
Fuel/propulsion System
MY VEHICLE HAS 43,419 MILES AND AFTER FUELING THE VEHICLE THE FUEL GAUGE DROPPED TO EMPTY AND THE SERVICE ENGINE SOON DASHBOARD LIGHT ILLUMINATED. A CHECK OF THE DIAGNOSTIC TROUBLE CODE (P0463) DISCLOSED A FAULTY FUEL LEVEL SENSOR "A" CIRCUIT HIGH. I HAD THE REPAIR DONE AT NISSAN. THE FEE FOR LABOR AND PARTS WAS $367.88. I SEE S…
Read full complaint
MY VEHICLE HAS 43,419 MILES AND AFTER FUELING THE VEHICLE THE FUEL GAUGE DROPPED TO EMPTY AND THE SERVICE ENGINE SOON DASHBOARD LIGHT ILLUMINATED. A CHECK OF THE DIAGNOSTIC TROUBLE CODE (P0463) DISCLOSED A FAULTY FUEL LEVEL SENSOR "A" CIRCUIT HIGH. I HAD THE REPAIR DONE AT NISSAN. THE FEE FOR LABOR AND PARTS WAS $367.88. I SEE SEVERAL HUNDRED REGISTERED NHTSA COMPLAINTS REGARDING THIS ISSUE AS WELL AS HUNDREDS AND HUNDREDS OF COMPLAINTS ON THE INTERNET. I BELIEVE THERE SHOULD BE A RECALL AS THIS IS CLEARLY A DEFECTIVE PART. THERE IS A RECALL ON THE 2006 XTERRA FOR THE SAME ISSUE.
NHTSA ODI #10967599
125 miles · Jan 22, 2016
Fuel/propulsion SystemUnknown Or Other
TRANSMISSION HAS BEEN SLIPPING . I HEARD OF A RECALL ON THIS PROBLEM AND I CALLED NISSAN AND WAS TOLD I MISSED EXTENDED WARRANTY BUY 8 DAYS ,THEY ADMITTED THAT THEY DID HAVE PROBLEMS WITH THIS VEHICLES TRANSMISSION.BUT REFUSE TO DO ANYTHING ABOUT IT, ALSO VERY HARD TO PUT GAS IN,
NHTSA ODI #10821605
135,000 miles · Dec 17, 2015
Fuel/propulsion SystemPower Train
TRANSMISSION HAS FAILED AT 135,000. FUEL GAUGE DOES NOT WORK.CHECK ENGINE LIGHT STAYS ILLUMINATED, THEREFORE I AM UNAWARE OF ANY ADDITIONAL ISSUES, AND CANNOT PASS EMISSIONS IN ATLANTA, GA, THEREFORE I CANNOT RENEW MY TAG.
NHTSA ODI #10810892
65,000 miles · Sep 22, 2015
Fuel/propulsion System
ENGINE LIGHT CAME ON . TOOK IT TO AUTO ZONE WHICH YIELD A CODE REFERRING TO THE FUEL SENSING UNIT.
NHTSA ODI #10767567
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Oct 5, 2005
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A NISSAN ACCESSORY TOW HITCH, INADEQUATE QUALITY OF SOME WELDED JOINTS IN THE HITCH ASSEMBLY MAY RESULT IN SEPARATION OF THE HITCH FROM THE VEHICLE WHEN BEING USED TO TOW.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE TRAILER SEPARATING FROM THE VEHICLE AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE TOW HITCHES. ON OCTOBER 17, 2005, OWNERS WERE SENT AN INTERIM LETTER ADVISING THEM NOT TO USE THE TOW HITCH UNTIL IT CAN BE REPAIRED. ANOTHER LETTER WAS SENT OUT ON NOVEMBER 21, 2005, NOTIFYING THEM TO BRING THEIR VEHICLES IN FOR REPAIR. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Illustration