Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

21 crash reports7 fire reports13 injury reports

Suspension complaints

13 reports

Clear category filter

117,950 miles · Apr 22, 2008

Suspension

THE MAIN LEAF SPRING IN THE REAR SUSPENSION SHEARED OFF NEXT TO THE AXLE WHILE DRIVING. I WAS THE ONLY PERSON IN THE CAR AND THE TOTAL LOAD IN THE REAR OF THE CAR WAS APPROXIMATELY 100LBS. THE SPRING CAUGHT ON THE BRAKE LINE AS IT BROKE. MY ABS LIGHT CAME ON. THE REPAIRS HAVE NOT BEEN MADE YET. *TR

NHTSA ODI #10225365

37,500 miles · Jan 16, 2006

Suspension

THE VEHICLE LEFT A COUPLE LARGE PUDDLES WHILE PARKED. DEALER IDENTIFIED THE PROBLEM AS A COMPLETELY FAILED REAR SHOCK, DUE TO CORROSION, AND RECOMMENDED IMMEDIATE REPLACEMENT OR RISK DIMINISHED HANDLING. AT 37,500 MI, THE 2002 MODEL YEAR VEHICLE WAS NO LONGER UNDER FACTORY WARRANTY SO BOTH REAR SHOCKS WERE REPLACED AT OWNER'S EX…

Read full complaint

NHTSA ODI #10147839

80,800 miles · Jul 8, 2004

Suspension

RIGHT REAR SHOCK BROKE WHILE DRIVING 35 MPH. MANUFACTURER WAS NOTIFIED, AND THEY INFORMED THE CONSUMER THAT IT WAS CONSIDERED NORMAL WEAR AT 80,000 MILES.*AK

NHTSA ODI #10081565

Mileage unknown · Jun 5, 2003

Suspension

THE VEHICLE WAS TAKEN TO THE DEALER FOR A RECALL #02V299000. THE CONSUMER NOTICED THE MECHANIC DID NOT PUT SEALANT ON THE ABS SENSOR. THE MECHANIC STATED HE DID EVERYTHING AS HE WAS TOLD. *JB

NHTSA ODI #10022484

Mileage unknown · May 21, 2003

Suspension

CAR PULLS TO THE RIGHT SINCE I BOUGHT IT. I TOOK IT TO THE DEALER SEVERAL TIMES ABOUT 4 TO DO AN ALIGNMENT AND STILL THE SAME ITS VERY DANGEROUS. *JB

NHTSA ODI #10019082

Mileage unknown · May 20, 2003

SteeringSuspensionUnknown Or Other

Read full complaint

THIS IS A VERY SOLID, AND STABLE VEHICLE IN THE SNOW AND ICE, (WITH STUDDED SNOW TIRES, ALL SEASON RADIALS ONLY WORK IN FLORIDA) IT HANDLES WELL, AND PERFORMS NICELY FOR A SMALL SUV. THE ONLY COMPLAINTS THAT I HAVE WITH THIS VEHICLE, IS THAT THE RIDE IS A BIT ROUGH. AND IT IS A BIT UNCOMFORTABLE FOR TALLER PEOPLE ON LONG RIDES. TO THOSE THAT ARE COMPLAINING ABOUT THE VEHICLE PULLING TO THE LEFT AND RIGHT. CURE #1, GET THE CAR ALIGNED. #2, CHECK THE ROAD YOU ARE DRIVING ON, THE TRACK WIDTH ON THE XTERRA IS NARROW, IT MAY BE CATCHING A GROOVE IN THE ROAD. #3 CHECK THE TIRE PRESSURES, TO COMPLAINTS ABOUT THE BRAKING....... HAVE THE BRAKES CHECKED, ROTORS, PADS, OR CALIPERS COULD BE STICKING. *NLM

NHTSA ODI #10019029

2,500 miles · Apr 1, 2003

SteeringSuspensionTires

WHILE DRIVING VEHICLE PULLS TO THE RIGHT OR LEFT. ALSO, WHEN BRAKING IT TENDS TO PULL ON EITHER SIDE MAKING IT HARD TO CONTROL. *JB

NHTSA ODI #10013792

250 miles · Apr 1, 2003

Suspension

VEHICLE VIBRATES SO HARD THAT PASSENGER'S SEAT BACK VIBRATES AS IT THE SEAT IS BROKEN AND MAKES AN ANNOYING NOISE. CONTACTED DEALER THEY SAID THEY CAN NOT DO ANYTHING ABOUT IT. PLEASE PROVIDE ANY INFO YOU HAVE. *JB

NHTSA ODI #10013788

32,600 miles · Mar 9, 2003

Suspension

Read full complaint

I OWN A 13 MONTH OLD 2002 NISSAN XTERRA THAT HAS 32,600 MILES ON IT AND HAS NEVER BEEN DRIVEN OFF-ROAD. THE LEAF SPRING ON THE DRIVER'S SIDE BROKE AT THE REAR MOUNTING BOLT. LUCKILY WE CAUGHT IT IMMEDIATELY AND THE DEALER IS REPLACING IT UNDER WARRANTY. HAS THIS BEEN A PROBLEM WITH THE XTERRA AND SHOULD THE OTHER ONE BE REPLACED AT THE SAME TIME? THE DEALER CLAIMS TO HAVE LOOKED AT THE OTHER ONE AND SEES NO PROBLEM AT THIS TIME. I'M CONCERNED ABOUT THE SAFETY BECAUSE I DO A LOT OF HIGH SPEED DRIVING WITH MY DAUGHTER IN THE CAR. *NLM

NHTSA ODI #10010184

Mileage unknown · Oct 23, 2002

Suspension

WHILE DRIVING THE VEHICLE PULLS TO THE RIGHT, IF THE BRAKES ARE APPLIED AGGRESIVELY THE VEHICLE RUNS OF THE ROAD, AS A RESULT THE DEALER NOTICED THAT THE TIRES WERE BEGINNING TO FEATHER ON THE RIGHT SIDE. NLM

NHTSA ODI #567987

Official recalls

10V554000 · Steering:column

Nov 11, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.

Consequence & remedy

Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.

Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

04V230000 · Fuel System, Gasoline:delivery:fuel Pump

May 24, 2004

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Consequence & remedy

Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

03V061000 · Air Bags:frontal:driver Side:inflator Module

Feb 27, 2003

ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.

Consequence & remedy

Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

02V298000 · Vehicle Speed Control

Nov 12, 2002

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.

Consequence & remedy

Consequence: THIS WILL CAUSE THE ENGINE CONTROL SYSTEM TO GO INTO THE FAILSAFE MODE. UNDER THIS CONDITION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE AND ENGINE SPEED WILL NOT EXCEED 2400 RPM REGARDLESS OF THE THROTTLE POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE. OWNER NOTIFICATION BEGAN JANUARY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

02V299000 · Suspension:rear

Nov 12, 2002

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Consequence & remedy

Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP03005 · Brake Rotor Warpage

Opened Jul 11, 2003 · Closed Jul 29, 2003

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor

MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.

EA02020 · Driver's Air Bag System Failure

Opened Aug 29, 2002 · Closed Mar 3, 2003

Status: closed (inferred from source dates) · Air Bags:frontal

IN ITS LETTER DATED FEBRUARY 21, 2003 TO NHTSA, NISSAN STATED THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 27,385 MY 2002 NISSAN XTERRA VEHICLES PRODUCED FROM 6/12/01 (START OF PRODUCTION) TO 11/1/01 AS WELL AS APPROXIMATELY 37,177 MY 2002 NISSAN ALTIMA VEHICLES PRODUCED FROM 6/13/01 (START OF PRODUCTION) TO 10/25/01.VEHICLES MANUFACTURED AFTER THESE DATES ARE NOT AFFECTED.NISSAN STATED THAT THE CLOCKSPRING ELECTRICAL CONNECTOR MAY NOT BE FULLY SECURED TO THE DRIVER-SIDE AIR BAG MODULE SQUIB PIN CONNECTOR DUE TO THE RETAINING GROOVE IN THE MODULE NOT HAVING SUFFICIENT DEPTH TO HOLD THE CONNECTOR IN THE ASSEMBLED POSITION.A RETAINING CLIP WILL BE INSTALLED ON THE CLOCKSPRING ELECTRICAL CONNECTOR.SEE RECALL 03V-061 FOR ADDITIONAL INFORMATION.

PE02038 · Driver's Air Bag System Malfunction

Opened Mar 26, 2002 · Closed Aug 29, 2002

Status: closed (inferred from source dates) · Air Bags:frontal

No summary supplied.