Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

21 crash reports7 fire reports13 injury reports

Seat Belts complaints

3 reports

Clear category filter

164,000 miles · Dec 5, 2024

Seat Belts

The contact owns a 2002 Nissan Xterra. The contact stated that while the vehicle was parked with the rear passenger’s seat occupied, the rear passenger’s seat belt thread unraveled, and the buckle detached and remained latched. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure m…

Read full complaint

NHTSA ODI #11628967

18,500 miles · Jul 10, 2003

Seat Belts

I OWN A 2002 XTERRA SE-SC THE SEATBELT ON PASSENGER SIDE LOCKS UP BUT DOESN'T RELEASE WHEN DRIVING COMPLAINED TO DEALER THEY CAN'T FIND ANYTHING WRONG WITH IT. CAN YOU PASS SOME INFO TO ME WHEN AVALIBLE. DP

NHTSA ODI #10025778

Mileage unknown · Feb 28, 2002

Seat Belts

INTERMITTENTLY SRS LIGHT STAYES ILLUMINATED WHILE DRIVING. DEALER HAS REPARIED VEHICLE FOUR TIMES; HOWEVER, LIGHT IS STILL ILLUMINATED. ALSO, ACCORDING TO OWNER'S MANUAL WHEN LIGHT ILLUMINATES THERE IS A POSSIBILITY THAT RESTRAINTS WILL BE INOPERABLE. PLEASE PROVIDE ADDITIONAL INFORMATION. *AK

NHTSA ODI #8004776

Official recalls

10V554000 · Steering:column

Nov 11, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.

Consequence & remedy

Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.

Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

04V230000 · Fuel System, Gasoline:delivery:fuel Pump

May 24, 2004

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Consequence & remedy

Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

03V061000 · Air Bags:frontal:driver Side:inflator Module

Feb 27, 2003

ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.

Consequence & remedy

Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

02V298000 · Vehicle Speed Control

Nov 12, 2002

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.

Consequence & remedy

Consequence: THIS WILL CAUSE THE ENGINE CONTROL SYSTEM TO GO INTO THE FAILSAFE MODE. UNDER THIS CONDITION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE AND ENGINE SPEED WILL NOT EXCEED 2400 RPM REGARDLESS OF THE THROTTLE POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE. OWNER NOTIFICATION BEGAN JANUARY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

02V299000 · Suspension:rear

Nov 12, 2002

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Consequence & remedy

Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP03005 · Brake Rotor Warpage

Opened Jul 11, 2003 · Closed Jul 29, 2003

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor

MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.

EA02020 · Driver's Air Bag System Failure

Opened Aug 29, 2002 · Closed Mar 3, 2003

Status: closed (inferred from source dates) · Air Bags:frontal

IN ITS LETTER DATED FEBRUARY 21, 2003 TO NHTSA, NISSAN STATED THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 27,385 MY 2002 NISSAN XTERRA VEHICLES PRODUCED FROM 6/12/01 (START OF PRODUCTION) TO 11/1/01 AS WELL AS APPROXIMATELY 37,177 MY 2002 NISSAN ALTIMA VEHICLES PRODUCED FROM 6/13/01 (START OF PRODUCTION) TO 10/25/01.VEHICLES MANUFACTURED AFTER THESE DATES ARE NOT AFFECTED.NISSAN STATED THAT THE CLOCKSPRING ELECTRICAL CONNECTOR MAY NOT BE FULLY SECURED TO THE DRIVER-SIDE AIR BAG MODULE SQUIB PIN CONNECTOR DUE TO THE RETAINING GROOVE IN THE MODULE NOT HAVING SUFFICIENT DEPTH TO HOLD THE CONNECTOR IN THE ASSEMBLED POSITION.A RETAINING CLIP WILL BE INSTALLED ON THE CLOCKSPRING ELECTRICAL CONNECTOR.SEE RECALL 03V-061 FOR ADDITIONAL INFORMATION.

PE02038 · Driver's Air Bag System Malfunction

Opened Mar 26, 2002 · Closed Aug 29, 2002

Status: closed (inferred from source dates) · Air Bags:frontal

No summary supplied.