NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
24 reportsClear category filter90,000 miles · Jul 21, 2011
Electrical SystemEngine And Engine Cooling
MY 2002 XTERRA ENGINE STALLS WHEN AT IDLE SPEED, IT STARTS BACK BUT WILL STALL ALMOST EVERYTIME I STOP AT A LIGHT,STOP SIGN OR IN TRAFFIC. ENGINE LIGHT DOES NOT COME ON AND THERE IS NO CODES. I SPOKE TO A NISSAN DEALERSHIP AND WHEN I ASKED THEM ABOUT A RECALL ON THE 2004 MODEL FOR THIS PROBLEM THAT HAS TO DO WITH THE IPDM RELAY,…
Read full complaint
MY 2002 XTERRA ENGINE STALLS WHEN AT IDLE SPEED, IT STARTS BACK BUT WILL STALL ALMOST EVERYTIME I STOP AT A LIGHT,STOP SIGN OR IN TRAFFIC. ENGINE LIGHT DOES NOT COME ON AND THERE IS NO CODES. I SPOKE TO A NISSAN DEALERSHIP AND WHEN I ASKED THEM ABOUT A RECALL ON THE 2004 MODEL FOR THIS PROBLEM THAT HAS TO DO WITH THE IPDM RELAY, THEY SAID THAT IS PROBABLY WHAT IS WRONG WITH MINE. THE DEALERSHIP ALSO SAID THERE IS AN ONGOING CAMPAIGN FOR THIS ISSUE WITH THE 2002 MODEL. I HAVE ALREADY HAD IT IN THE SHOP FOR THIS PROBLEM HAD SPARK PLUGS,DISTRIBUTOR,PLUG WIRES,FUEL FILTER ,MAF SENSOR AND THE THROTTLE BODY REPLACED $1300.00 LATER I STILL HAVE THE SAME PROBLEM. *KB
NHTSA ODI #10413939
Mileage unknown · Mar 21, 2011
Engine And Engine CoolingFire
2002 NISSAN XTERRA, UNIT 1 WAS TRAVELING EASTBOUND ON THE OHIO TURNPIKE WHEN THE ENGINE CAUGHT FIRE. *BF (OHIO TRAFFIC CRASH REPORT # 10-0086-91) UPDATED 03/29/11 *BF
NHTSA ODI #10393172
85,000 miles · Oct 15, 2008
Engine And Engine Cooling
HEAD GASKET FAILURE AND ANTIFREEZE LEAK. *TR
NHTSA ODI #10245626
89,000 miles · Jul 9, 2008
Engine And Engine Cooling
BOTH OF THE VEHICLES EXHAUST MANIFOLDS HAVE DEVELOPED CRACKS AND HAD TO BE REPLACES BECAUSE OF POTENTIAL EXHAUST FUMES ENTERING THE DRIVERS CABIN. THIS IS A WELL KNOWN AND COMMON OCCURRENCE WITH 00-02 NISSAN XTERRAS . NISSAN CHANGED THE MANIFOLD DESIGN IN 03 WHICH ACKNOWLEDGED THAT THEY RECOGNIZED THE ISSUE BUT HAVE DONE NOTHING…
Read full complaint
BOTH OF THE VEHICLES EXHAUST MANIFOLDS HAVE DEVELOPED CRACKS AND HAD TO BE REPLACES BECAUSE OF POTENTIAL EXHAUST FUMES ENTERING THE DRIVERS CABIN. THIS IS A WELL KNOWN AND COMMON OCCURRENCE WITH 00-02 NISSAN XTERRAS . NISSAN CHANGED THE MANIFOLD DESIGN IN 03 WHICH ACKNOWLEDGED THAT THEY RECOGNIZED THE ISSUE BUT HAVE DONE NOTHING TO RECALL OR COMPENSATE CONSUMERS FOR THE ISSUE IN PRIOR MODELS. *TR
NHTSA ODI #10233619
Mileage unknown · Jul 7, 2008
Engine And Engine Cooling
THE EXHAUST MANIFOLD ON THE PASSENGER SIDE OF VEHICLE IS CRACKED ALLOWING EXHAUST FUMES INTO THE PASSENGER AREA. THIS IS A WELL KNOWN PROBLEM AMONG NISSAN XTERRA OWNERS. *TR
NHTSA ODI #10233349
50,000 miles · Mar 23, 2007
Engine And Engine CoolingEquipmentFuel System, Gasoline
TL* - THE CONTACT OWNS A 2002 NISSAN XTERRA. WHILE DRIVING AT 35 MPH THE VEHICLE BEGAN TO VIBRATE. THE CONTACT PULLED INTO A GAS STATION, PURCHASED OIL AND PUT IT INTO THE VEHICLE, AND THEN THE VEHICLE WOULD NOT START. THE CONTACT HAD TRIPLE AAA TOW THE VEHICLE TO A NISSAN DEALERSHIP. THE PROBLEM WAS DIAGNOSED AS DIESEL …
Read full complaint
TL* - THE CONTACT OWNS A 2002 NISSAN XTERRA. WHILE DRIVING AT 35 MPH THE VEHICLE BEGAN TO VIBRATE. THE CONTACT PULLED INTO A GAS STATION, PURCHASED OIL AND PUT IT INTO THE VEHICLE, AND THEN THE VEHICLE WOULD NOT START. THE CONTACT HAD TRIPLE AAA TOW THE VEHICLE TO A NISSAN DEALERSHIP. THE PROBLEM WAS DIAGNOSED AS DIESEL FUEL MIXED WITH GAS. THE CONTACT WAS TOLD THAT THE VEHICLE NEEDED THE FUEL TANK AND THE FUEL SYSTEM TO BE FLUSHED, AND THE OIL CHANGED, SPARK PLUGS REPLACED, AND THE FUEL FILTER REPLACED. THE DEALER HAD THE CONTACTS VEHICLE FOR APPROXIMATELY THREE WEEKS AND PERFORMED AN OIL CHANGE, FLUSHED THE FUEL TANK, AND FUEL SYSTEM. THE CONTACT PICKED UP THE VEHICLE ,WENT DIRECTLY ACROSS THE STREET AND PURCHASED HIGH OCTANE GAS. THE VEHICLE RAN LONG ENOUGH FOR HIM TO GO ACROSS THE STREET, GOT THE GAS AND THEN THE VEHICLE STALLED. THE CONTACT DID NOT BELIEVE THAT THE VEHICLE WAS WORKING AS IT DID BEFORE THE REPAIRS WERE PERFORMED. THE VEHICLE WAS TAKEN BACK TO THE DEALER , WHERE ANOTHER DIAGNOSTIC HAD TO BE DONE, AND THE DEALER TOLD THE CONTACT THAT THE ENGINE NEEDED TO BE REBUILT. THE CONTACT BELIEVED THAT THE FIRST DIAGNOSTIC SHOULD HAVE REVEALED THAT THE ENGINE HAD A PROBLEM, AND THAT NOTHING ON THE DASHBOARD EVER INDICATED THAT THE OIL WAS LOW. THE VEHICLE WAS PURCHASED IN AUGUST, AND THE PROBLEMS BEGAN AT THE END OF JANUARY. THE CONTACT FELT THAT IF THE VEHICLE DID NOT HAVE OIL IT WAS PURCHASED THAT WAY. THE CURRENT AND FAILURE MILEAGE WERE 50,000.*AK THE DEALER STATES TAG LIGHT NOT WORKING AND CD PLAYER NOT WORKING. THE CONSUMER PROVIDED INFORMATION FROM CARFAX AND A REPAIR INVOICE. UPDATED 06/08/07 *TR
NHTSA ODI #10186030
29,000 miles · Oct 31, 2006
Engine And Engine Cooling
HAD THE CHECK ENGINE LIGHT COME ON HAD XTERRA FOR ONLY 26 DAYS FIND OUT IT IS EMISSIONS PROBLEM NO HELP FROM DEALER. *NM
NHTSA ODI #10172316
40,000 miles · Nov 1, 2005
Engine And Engine Cooling
PREMATURE FAILURE OF HEAD GASKET ON 2002 NISSAN XTERRA 4WD. CAR IS LEAKING ANTIFREEZE COOLANT AND ONLY 3 YRS OLD. NISSAN DEALER WANTS SOMEWHERE AROUND $3000 TO REPAIR. NISSAN USA MANUFACTURER OF VEHICLE HAS TOLD ME THAT THEY CANNOT ASSIST ME. CAR NOW HAS ONLY 70,000 MILES BUT THE PROBLEM EXISTED WAY BEFORE. DEALER TOLD ME T…
Read full complaint
PREMATURE FAILURE OF HEAD GASKET ON 2002 NISSAN XTERRA 4WD. CAR IS LEAKING ANTIFREEZE COOLANT AND ONLY 3 YRS OLD. NISSAN DEALER WANTS SOMEWHERE AROUND $3000 TO REPAIR. NISSAN USA MANUFACTURER OF VEHICLE HAS TOLD ME THAT THEY CANNOT ASSIST ME. CAR NOW HAS ONLY 70,000 MILES BUT THE PROBLEM EXISTED WAY BEFORE. DEALER TOLD ME THAT THEY SMELLED ANTI-FREEZE LEAK WHEN I BROUGHT THE CAR IN FOR A 30,000 MILE MAINTENANCE BUT THEY NEVER PUT IT IN WRITING AND NEVER MENTIONED IT AGAIN. *JB
NHTSA ODI #10141366
70,267 miles · Sep 9, 2005
Engine And Engine Cooling
DT: THE CONTACT STATED HAD A COOLANT LEAK COMING FROM RADIATOR TO HER ENGINE. SHE WENT ON THE WEBSITE AND FOUND A COUPLE OF SERVICE BULLETINS, NHTSA ITEM 631329, AND 633628 THAT RELATED TO THE COOLANT LEAK PROBLEM. THE PROBLEM WAS FIXED. CURRENTLY, WAS HAVING ANOTHER COOLANT PROBLEM, AND SHE WAS TAKING VEHICLE TO THE D…
Read full complaint
DT: THE CONTACT STATED HAD A COOLANT LEAK COMING FROM RADIATOR TO HER ENGINE. SHE WENT ON THE WEBSITE AND FOUND A COUPLE OF SERVICE BULLETINS, NHTSA ITEM 631329, AND 633628 THAT RELATED TO THE COOLANT LEAK PROBLEM. THE PROBLEM WAS FIXED. CURRENTLY, WAS HAVING ANOTHER COOLANT PROBLEM, AND SHE WAS TAKING VEHICLE TO THE DEALER ON WEDNESDAY. SHE WAS LOSING COOLANT, BUT SHE SAW NO SIGN OF A LEAK. SHE ASSUMED THAT IT WAS A LEAK WITHIN THE ENGINE. THE PROBLEM STARTED AROUND 1-05, AND SHE TOOK IT TO DEALER ON 1-11-05 TO HAVE THE ORIGINAL COOLANT PROBLEM FIXED ,AND HAD TO PAY $946.36 FOR THE REPAIRS. *AK *NM
NHTSA ODI #10133538
54,428 miles · Apr 7, 2005
Engine And Engine Cooling
DRIVING DOWN THE HIGHWAY 65 MPH, ENGINE BEGAN KNOCKING SUDDENLY, OIL LIGHT CAME ON, ENGINE STOPPED. HAD VEHICLE TOWED TO DEALER, THEY TOLD ME I NEEDED AN ENGINE I ASKED WHAT CAUSED THE PROBLEM, THEY SAID SLUDGE GOT IN THE ENGINE CAUSED IT TO SEIZE UP, THEY DID NOT DETERMINE HOW THE SLUDGE GOT IN THE ENGINE. *AK
NHTSA ODI #10116581
Official recalls
5Nov 11, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
Consequence & remedy
Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
May 24, 2004
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.
Consequence & remedy
Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.
Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Feb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
Consequence & remedy
Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Nov 12, 2002
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.
Consequence & remedy
Consequence: THIS WILL CAUSE THE ENGINE CONTROL SYSTEM TO GO INTO THE FAILSAFE MODE. UNDER THIS CONDITION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE AND ENGINE SPEED WILL NOT EXCEED 2400 RPM REGARDLESS OF THE THROTTLE POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE. OWNER NOTIFICATION BEGAN JANUARY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Nov 12, 2002
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.
Consequence & remedy
Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP03005 · Brake Rotor Warpage
Opened Jul 11, 2003 · Closed Jul 29, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor
MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.
EA02020 · Driver's Air Bag System Failure
Opened Aug 29, 2002 · Closed Mar 3, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
IN ITS LETTER DATED FEBRUARY 21, 2003 TO NHTSA, NISSAN STATED THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 27,385 MY 2002 NISSAN XTERRA VEHICLES PRODUCED FROM 6/12/01 (START OF PRODUCTION) TO 11/1/01 AS WELL AS APPROXIMATELY 37,177 MY 2002 NISSAN ALTIMA VEHICLES PRODUCED FROM 6/13/01 (START OF PRODUCTION) TO 10/25/01.VEHICLES MANUFACTURED AFTER THESE DATES ARE NOT AFFECTED.NISSAN STATED THAT THE CLOCKSPRING ELECTRICAL CONNECTOR MAY NOT BE FULLY SECURED TO THE DRIVER-SIDE AIR BAG MODULE SQUIB PIN CONNECTOR DUE TO THE RETAINING GROOVE IN THE MODULE NOT HAVING SUFFICIENT DEPTH TO HOLD THE CONNECTOR IN THE ASSEMBLED POSITION.A RETAINING CLIP WILL BE INSTALLED ON THE CLOCKSPRING ELECTRICAL CONNECTOR.SEE RECALL 03V-061 FOR ADDITIONAL INFORMATION.
PE02038 · Driver's Air Bag System Malfunction
Opened Mar 26, 2002 · Closed Aug 29, 2002
Status: closed (inferred from source dates) · Air Bags:frontal
No summary supplied.
Illustration