DROVE CAR TO STORE, CAME BACK OUTSIDE AND CAR WOULD NOT START, ONLY A FEW INDICATOR LIGHTS CAME ON THE INSTRUMENT PANEL. JUMP STARTED THE CAR IT STARTED RIGHT AWAY, TURNED ON THE HEADLIGHTS AND CAR INSTANTLY STOPPED AND WOULD NOT RESTART. TOWED TO REPAIR SHOP. *TR
2011 Nissan Versa
Owner reports · Recalls · Investigations
More warning signs than most Versa years
Owner complaints for the 2011 Nissan Versa are substantially higher than the model-year median of 95.
About this comparison →How this year compares
Owner complaints by model year
Compare all Versa years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
146 reports with mileage · 123 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
17 reports2011 NISSAN VERSA WAS TAKEN INTO THE DEALERSHIP FOR NOT SHIFTING OUT OF PARK. AT THE TIME, POWERTRAIN WARRANTY WAS NO LONGER IN EFFECT. DEALER ADVISED, THAT THE SHIFTER SOLENOID IS NOT FUNCTIONING AND NEEDS TO BE REPLACED. THE COST FOR THE SHIFTER SOLENOID IS APPROXIMATELY $600.00 DOLLARS. I CONDUCTED A RESEARCH AND DISCOVERED …
Read full complaint
2011 NISSAN VERSA WAS TAKEN INTO THE DEALERSHIP FOR NOT SHIFTING OUT OF PARK. AT THE TIME, POWERTRAIN WARRANTY WAS NO LONGER IN EFFECT. DEALER ADVISED, THAT THE SHIFTER SOLENOID IS NOT FUNCTIONING AND NEEDS TO BE REPLACED. THE COST FOR THE SHIFTER SOLENOID IS APPROXIMATELY $600.00 DOLLARS. I CONDUCTED A RESEARCH AND DISCOVERED NISSAN HAS THIS PROBLEM WITH MOST OF THEIR VEHICLES AT LOW MILEAGE. NISSAN HAS NOT ISSUED A RECALL ON THE VEHICLE. IN ADDITION, THE SUSPENSION IS ALSO MAKING NOISES AND HAS BEEN DIAGNOSED BY AN AUTOMOTIVE TECHNICIAN, WHO HAS ADVISED THE STRUT NEEDS TO BE REPLACED. THE VEHICLE MAKES CLICKING NOISED WHEN TURNING TO THE RIGHT OR LEFT. THE COST FOR OEM STRUT IS APPROXIMATELY $ 200.00. I AM HAVING TO MANY ISSUES WITH THIS VEHICLE AND CONSIDERED TO TRADE IT IN IF NISSAN DOES NOT RECALL VEHICLES. *TR
THE SERVICE ENGINE LIGHT BEGAN TO GO ON AND OFF AS WELL AS A KNOCKING SOUND HAD DEVELOPED. WE HAD OUR SON, WHO HAD ATTENDED SCHOOL TO BECOME A MECHANIC, CHECKED IT LOOKING AT THE OIL LEVEL. THE OIL WAS ABOUT A QUART LOW AND HE ADVISED US TO TAKE IT TO CARMAX WHERE WE HAD PURCHASED THE CAR. AFTER TWO DIAGNOSTIC TESTS AND AN O…
Read full complaint
THE SERVICE ENGINE LIGHT BEGAN TO GO ON AND OFF AS WELL AS A KNOCKING SOUND HAD DEVELOPED. WE HAD OUR SON, WHO HAD ATTENDED SCHOOL TO BECOME A MECHANIC, CHECKED IT LOOKING AT THE OIL LEVEL. THE OIL WAS ABOUT A QUART LOW AND HE ADVISED US TO TAKE IT TO CARMAX WHERE WE HAD PURCHASED THE CAR. AFTER TWO DIAGNOSTIC TESTS AND AN OIL CHANGE AT $140.00, MY HUSBAND WAS TOLD THAT IT NEEDED A NEW ENGINE. IT IS BURNING OIL AND IS BEING EMITTED OUT THE EXHAUST AND HAS EXCESSIVE ENGINE BLOW BY. WE HAVE BEEN ADVISED BY MAXCARE, CARMAX'S WARRANTY COMPANY, THAT IN ORDER TO PROPERLY DIAGNOSE THE PROBLEM AND DETERMINE IF IT IS COVERED BY WARRANTY WE HAVE TO PAY ANOTHER $400.00 TO HAVE THE ENGINE TORN DOWN WITH NO GUARANTEE REPAIRS WILL BE COVERED BY THE WARRANTY THE ANOTHER $400.00 TO PUT IT BACK TOGETHER IF IT IS NOT FIXED. ALSO, AT LEAST 3 TIMES WHEN THE SERVICE ENGINE LIGHT BEGAN TO TURN ON AND OFF THE VERSA STALLED WHILE IN HEAVY TRAFFIC. WE ALSO COMPLAINED TO CARMAX THAT THE CHECK TIRES INDICATOR LIGHT WOULD GO ON AND OFF CAUSING US TO CONSTANTLY STOP TO CHECK THE PRESSURE AND OFTEN IT WAS OK. CARMAX OFFERED TO RUN ANOTHER DIAGNOSTIC TEST FOR MORE MONEY TO TRY TO FIND OUT WHAT THE PROBLEM WAS. BOTH PROBLEMS COULD CAUSE SERIOUS DAMAGE IN THE FUTURE AND IT SEEMS THE ONLY WAY TO GET IT REPAIRED IS TO PAY OUT OF OUR POCKET. *TR
TL* THE CONTACT OWNS A 2011 NISSAN VERSA. THE CONTACT STATED THAT WHILE ATTEMPTING TO ENTER THE VEHICLE, THE POWER LOCKS AND ELECTRICAL SYSTEM FAILED. THE CONTACT ALSO STATED THAT WHILE DRIVING 25 MPH, THE POWER STEERING ASSIST AND THE BRAKES FAILED WITHOUT WARNING, CAUSING HER TO CRASH INTO A TELEPHONE POLE. THE VEHICLE WAS DE…
Read full complaint
TL* THE CONTACT OWNS A 2011 NISSAN VERSA. THE CONTACT STATED THAT WHILE ATTEMPTING TO ENTER THE VEHICLE, THE POWER LOCKS AND ELECTRICAL SYSTEM FAILED. THE CONTACT ALSO STATED THAT WHILE DRIVING 25 MPH, THE POWER STEERING ASSIST AND THE BRAKES FAILED WITHOUT WARNING, CAUSING HER TO CRASH INTO A TELEPHONE POLE. THE VEHICLE WAS DESTROYED. THE CONTACT SUSTAINED HEAD TRAUMA AND BURNS TO THE HANDS. THE PASSENGER SUSTAINED BACK INJURIES, A HEMATOMA AND BRUISING TO THE LEFT LEG. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 1,150. *TR
MY CAR THAT I BOUGHT IN 2011 BRAND NEW HAS CUT OFF WHILE DRIVING EVERY OTHER MONTH . IT IS VERY RANDOM AND NO LIGHTS COME ON IN THE CAR. THE LAST TIME MY WIFE WAS DRIVING 35 MPH ON A HIGHWAY AND SHE HAD TO STOP IN THE MIDDLE OF TRAFFIC, PUT THE CAR IN PARK, AND START IT BACK AGAIN. I HAVE BROUGHT MY CAR TO THE NEAREST NISSAN DEA…
Read full complaint
MY CAR THAT I BOUGHT IN 2011 BRAND NEW HAS CUT OFF WHILE DRIVING EVERY OTHER MONTH . IT IS VERY RANDOM AND NO LIGHTS COME ON IN THE CAR. THE LAST TIME MY WIFE WAS DRIVING 35 MPH ON A HIGHWAY AND SHE HAD TO STOP IN THE MIDDLE OF TRAFFIC, PUT THE CAR IN PARK, AND START IT BACK AGAIN. I HAVE BROUGHT MY CAR TO THE NEAREST NISSAN DEALERSHIP, BUT THEY CAN NOT FIND ANYTHING WRONG. THEY HAVE DRIVEN IT OVER 140 MILES, SCANNED 4 TIMES FOR FAILURES IN WHICH NONE CAME UP. I COMPLAINED TO THE NISSAN CORPORATION AND THEY SAY ONLY WAIT UNTIL IT HAPPENS AGAIN AND BRING IT INTO THE DEALERSHIP. THIS HAS HAPPENED A TOTAL OF 6 TIMES WHILE DRIVING IN THE PAST YEAR. MY CAR HAS ALSO NOT CRANKED UP FOR A TOTAL 10 MINUTES AT A TIME. THIS HAS OCCURRED AT LEAST 15 TIMES IN THE PAST YEAR. I DO NOT FEEL SAFE DRIVING MY CAR. THEY LEAVE ME WITH NO OTHER OPTION THAN TO DRIVE IT AND WAIT. *TR
WHILE DRIVING AT NIGHT (WITH A HERTZ RENTAL CAR IN KAUAI HAWAII) AND SWITCHING BETWEEN HIGH BEAM AND LOW BEAM AND TRAVELING AT 40 MPH ALL THE HEADLIGHTS TURNED OFF. THE STALK MOUNTED SWITCH CONTROLS BOTH HEADLIGHT ON/OFF (ROTARY MOTION) AND HIGH BEAM-LOW BEAM WITH BACK AND FORTH STALK MOTION. AFTER DRIVING FOR ABOUT AN HOUR A…
Read full complaint
WHILE DRIVING AT NIGHT (WITH A HERTZ RENTAL CAR IN KAUAI HAWAII) AND SWITCHING BETWEEN HIGH BEAM AND LOW BEAM AND TRAVELING AT 40 MPH ALL THE HEADLIGHTS TURNED OFF. THE STALK MOUNTED SWITCH CONTROLS BOTH HEADLIGHT ON/OFF (ROTARY MOTION) AND HIGH BEAM-LOW BEAM WITH BACK AND FORTH STALK MOTION. AFTER DRIVING FOR ABOUT AN HOUR AND SUCCESSFULLY USING THE HIGH-BEAM LOW BEAM SELECTOR OFTEN, ON THE NEXT CHANGE BETWEEN HIGH AND LOW BEAM THE ROTARY MOTION OF THE KNOB ALSO ENGAGED AND TURNED THE HEADLIGHTS OFF. I HAVE SIMILAR CONTROLS ON MY CAR AT HOME AND THIS HAS NEVER HAPPENED. THE ROTARY MOTION OF THE ON / OFF KNOB REQUIRES JUST A VERY LIGHT TWIST AND THE IN-OUT MOTION NEEDED TO CHANGE BETWEEN HIGH AND LOW BEAM ALSO TWISTED THE OFF SWITCH. FORTUNATELY I WAS ABLE TO BRING THE CAR TO A HALT WITH THE BRAKES AND STAY ON THE ROAD. IT WAS VERY SCARY AND VERY FRIGHTENING TO BRAKE FROM 40 MPH IN THE PITCH DARK NOT KNOWING IF THE NEXT INSTANT WAS TO BRING A CRASH. MY WIFE WAS ALSO VERY SHOOK UP. AFTER I STOPPED I FIGURED OUT WHAT HAPPENED. IT WAS PITCH BLACK OUTSIDE WITH NO STREET LIGHTS. THIS CAN KILL SOMEONE!! THE FLUTED SURFACE OF THE ON/OFF KNOB EXACERBATES THE PROBLEM AND MAKES IT EASIER FOR A LIGHT BRUSH WITH A FINGER TIP TO TURN THE KNOB AND HEADLIGHTS OFF. THE VIN I COPIED FROM THE LIHUE AIRPORT HERTZ RECEIPT FOR THE RENTAL. LICENSE NUMBER WAS [XXX], HAWAII .IT WAS A RED COLOR CAR WITH AUTOMATIC SHIFT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NISSAN VERSA 1.6 BASE SEDAN, SPEEDOMETER PROBLEM. SHOWING A SPEED HIGHER THEN THE ACTUAL SO I AM GETTING MORE MILES THEN ACTUAL AND MIGHT RESULT IN THE EARLIER EXPIRATION OF WARRANTY. *KB
Official recalls
620V008000 · Air Bags:frontal:passenger Side:inflator Module
Jan 9, 2020
Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.
18V401000 · Air Bags:frontal:passenger Side:inflator Module
Jun 15, 2018
Nissan North America, Inc. (Nissan) is recalling certain 2011 Nissan Versa sedan vehicles and 2011-2012 Nissan Versa hatchback vehicles ever registered in the states of Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia. Nissan is also recalling 2010-2011 Nissan Versa sedan vehicles and 2010-2012 Nissan Versa hatchback vehicles ever registered in the states of ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 5, 2018. Owners may contact Nissan customer service at 1-800-867-7669.
18V044000 · Air Bags:frontal:passenger Side:inflator Module
Jan 10, 2018
Nissan North America, Inc. (Nissan) is recalling certain 2009-2012 Versa Hatchback, and 2009-2011 Versa Sedan vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Nissan is recalling certain 2009-2010 Versa Hatchback, and Versa Sedan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Nissan is also recalling certain 2009 Versa Hatchback and Versa Sedan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
17V449000 · Air Bags:frontal:driver Side:inflator Module
Jul 17, 2017
Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.
16V349000 · Air Bags:frontal:passenger Side:inflator Module
May 24, 2016
Nissan North America, Inc. (Nissan) is recalling certain model year 2003-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2010 Infiniti M35 and M45, and 2007-2011 Nissan Versa vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Nissan is recalling certain model year 2005-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2008 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Nissan is recalling certain model year 2003-2004 Infiniti I35 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began December 21, 2017. All owners should receive a second notice by May 15, 2017. Owners may contact Nissan customer service at 1-800-647-7261.
15V573000 · Suspension:front:springs:coil Springs
Sep 14, 2015
Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence & remedy
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE15019 · Front Coil Spring Fracture
Opened May 13, 2015 · Closed Oct 2, 2015
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
In a letter dated September 10,2015, Nissan North America,Inc. (Nissan) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in coil spring fracture in approximately 218,019 model year (MY) 2007 through 2012 Nissan Versa vehiclesproduced from May 8, 2006 through November12, 2012 and originally sold or ever registered in the following 22 states and the District of Columbia: Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia and Wisconsin (NHTSA Recall 15V-573).Nissan indicated that the recalled vehicles may contain front coil springs that received inadequate phosphorous coating, have low residual stress, or a combination of both.Surface imperfections resulting from coil-to-coil contact when the spring is compressed may lead to crack initiation.Exposure of the surface imperfections to road salts, in regions with heavy use of road salts for snow and ice control, may promote crack propagation in the spring that could result in spring fracture.If the coil spring fractures it may puncture the front tire and possibly the brake line while driving, which may increase the risk of a vehicle crash.ODI's analysis of complaints it has received from the public (VOQ's) and Nissan complaint data submitted in response to the information request letter for PE15-019 identified a total of 468 non-duplicative reports alleging coil spring fractures in the subject vehicles, including 142 VOQ's and 367 Nissan complaints (41 of the incidents reported to ODI were also reported to Nissan).While the recall region accounts for approximately 43 percent of vehicle sales, the analysis found that 94 percent of the complaints involved vehicles sold or operated in those states.Approximately 27 percent of the VOQ's reporting coil spring failures in the recalled states indicated that the failure resulted in a punctured tire.ODI also identified one complaint that alleged brake line damage from a failed spring.Nissan's recall will replace both coil springs free of charge.Based on Nissan's safety recall, this investigation is closed.The 142 VOQ's referenced in this resume are: 10236143, 10405369, 10443746, 10452956, 10491553, 10497737, 10503060, 10504557, 10512390, 10512975, 10514582, 10516024, 10516085, 10521216, 10522261, 10526334, 10533856, 10537404, 10537407, 10548678, 10552124, 10559853, 10562485, 10565283, 10572591, 10578519, 10583059, 10583154, 10583496, 10583673, 10584979, 10585327, 10585377, 10585751, 10586397, 10586444, 10587798, 10588347, 10588427, 10592366, 10592498, 10592780, 10593373, 10593621, 10595215, 10596802, 10598404, 10598877, 10606859, 10606998, 10610082, 10618059, 10640845, 10644269, 10645075, 10649515, 10653189, 10659632, 10662158, 10663102, 10667071, 10667845, 10669949, 10670829, 10671894, 10676522, 10680544, 10680740, 10682397, 10691419, 10692629, 10693347, 10694156, 10694420, 10701250, 10702765, 10703126, 10704658, 10705882, 10706351, 10711805, 10712045, 10712922, 10714243, 10715041, 10715175, 10716106, 10717254, 10717320, 10717403, 10717412, 10717489, 10717563, 10720958, 10721782, 10721824, 10722113, 10722459, 10722915, 10723873, 10723972, 10723973, 10724158, 10724899, 10725002, 10725328, 10725377, 10725542, 10726251, 10726736, 10726741, 10730138, 10730154, 10730342, 10731050, 10731692, 10731799, 10731901, 10732054, 10732062, 10733059, 10733144, 10733309, 10733349, 10733607, 10733781, 10733854, 10735347, 10735353, 10735606, 10736199, 10736227, 10743474, 10743634, 10743790, 10744
Illustration