NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
430 reports31,740 miles · May 31, 2013
Electrical SystemExterior Lighting
GOING HOME FROM WORK, WHILE DRIVING EVERY TIME I PUT THE RIGHT TURN SIGNAL ON I NOTICED THE LIGHT AT THE DASHBOARD FLASHES SO WEIRD AND THEN DISAPPEAR. I MADE FIVE RIGHT TURNS THAT NIGHT ALL ACTING THE SAME THING. THE NEXT DAY I TOOK THE TRUCK TO THE GARAGE AND HAD IT CHECKED THEY FOUND OUT THAT THE WIRING INSIDE THE LAMP ASSEMB…
Read full complaint
GOING HOME FROM WORK, WHILE DRIVING EVERY TIME I PUT THE RIGHT TURN SIGNAL ON I NOTICED THE LIGHT AT THE DASHBOARD FLASHES SO WEIRD AND THEN DISAPPEAR. I MADE FIVE RIGHT TURNS THAT NIGHT ALL ACTING THE SAME THING. THE NEXT DAY I TOOK THE TRUCK TO THE GARAGE AND HAD IT CHECKED THEY FOUND OUT THAT THE WIRING INSIDE THE LAMP ASSEMBLY WAS MELTED, THE WIRE WAS TIED WITH PLASTIC STRING WRAP SO TIGHT THAT MADE THE INSULATION OF THE WIRE MELTS AND CREATED A SHORT CIRCUIT. THE WHOLE INSIDE OF THE COMBINATION LAMP ASSEMBLY REAR, RH OF MY TRUCK WAS MELTED. THEY CUT THE PLASTIC STRING WRAP AND THEN PUT SOME ELECTRICAL TAPE ON THE WIRES, THEY HAVE A HARD TIME OF PUTTING THE LAMP ASSEMBLY BACK INTO THE TRUCK AND UNTIL NOW I DID NOT REPLACE THE RH REAR COMBINATION LAMP ASSEMBLY. *TR
NHTSA ODI #10514460
84,000 miles · May 17, 2013
Engine
TICKING NOISE FROM ENGINE AREA ESPECIALLY UNDER MODERATE ACCELERATION, DEALER INSPECTED AND SAID MY EXHAUST MANIFOLDS ARE CRACKED AND WOULD COST 3K TO FIX . NISSAN CUSTOMER RELATIONS REFUSES TO HELP IN ANY WAY EVEN THOUGH MY TRUCK IS ONLY 4000 MILES PAST MILEAGE LIMIT. THIS IS A KNOWN ISSUE THAT IS A SAFETY HAZARD (EXHAUST FUMES…
Read full complaint
TICKING NOISE FROM ENGINE AREA ESPECIALLY UNDER MODERATE ACCELERATION, DEALER INSPECTED AND SAID MY EXHAUST MANIFOLDS ARE CRACKED AND WOULD COST 3K TO FIX . NISSAN CUSTOMER RELATIONS REFUSES TO HELP IN ANY WAY EVEN THOUGH MY TRUCK IS ONLY 4000 MILES PAST MILEAGE LIMIT. THIS IS A KNOWN ISSUE THAT IS A SAFETY HAZARD (EXHAUST FUMES CAN ENTER CAB) AND NISSAN REFUSES TO TAKE ANY RESPONSIBILITY. *TR
NHTSA ODI #10512607
Mileage unknown · Apr 25, 2013
Engine And Engine Cooling
HAVE TAKEN IT TO TWO DIFFERENT REPAIR SHOPS AND HAVE BOTH (DRIVERS/PASSENGER SIDE) EXHAUST MANIFOLD ARE CRACKED. HAVE GONE TO NISSAN FOR THE REPAIRS .NISSAN HAS STATED THAT ITS A KNOWN ISSUE ON NISSAN TITANS FOR THE YEARS OF 2004-2007 BUT WON'T REPLACE IT. WAS QUOTED FOR THE REPAIR OF $3,000. ITS JUST OUT OF THE MILES ON THE 80K…
Read full complaint
HAVE TAKEN IT TO TWO DIFFERENT REPAIR SHOPS AND HAVE BOTH (DRIVERS/PASSENGER SIDE) EXHAUST MANIFOLD ARE CRACKED. HAVE GONE TO NISSAN FOR THE REPAIRS .NISSAN HAS STATED THAT ITS A KNOWN ISSUE ON NISSAN TITANS FOR THE YEARS OF 2004-2007 BUT WON'T REPLACE IT. WAS QUOTED FOR THE REPAIR OF $3,000. ITS JUST OUT OF THE MILES ON THE 80K/8YEAR EMISSIONS WARRANTY, BUT STILL TIME FRAME.
NHTSA ODI #10509602
135,260 miles · Apr 23, 2013
Power Train
LEFT REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENITAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTOR WHICH COULD CAUSE BRAKE FAILURE. THIS IS A MAJOR SAFETY CONCERN TO ME. THE LEAKING DIFFERENTIAL FLUID WILL CAUSED THE REAR DIFFERENTIAL TO FAIL. THIS SEEMS TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD A…
Read full complaint
LEFT REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENITAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTOR WHICH COULD CAUSE BRAKE FAILURE. THIS IS A MAJOR SAFETY CONCERN TO ME. THE LEAKING DIFFERENTIAL FLUID WILL CAUSED THE REAR DIFFERENTIAL TO FAIL. THIS SEEMS TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD ADDRESS THIS ISSUE AND OFFER A PERMANENT FIX SO TITAN OWNERS WOULD NOT HAVE TO DEAL WITH THIS SAFETY ISSUE IN THE FUTURE. *TR
NHTSA ODI #10509292
95,000 miles · Apr 11, 2013
Air Bags
MY 2006 NISSAN TITAN KING CAB HAS THE AIR BAG LIGHT FLASHING , I WAS ADVISE BY A MECHANIC THAT THERE'S A RECALL ON SAME VEHICLES JUST LIKE MINE, THE RECENT DEALER'S DIAGNOSIS CONFIRMS THAT THE WIRING FOR THE HARNESS ARE BROKEN AND IT'S REQUIRE TO BE REPLACED, THIS ISSUE APPLIES TO THE SAME DESCRIPTION ON THE RECALL CAMPAIGN # 0…
Read full complaint
MY 2006 NISSAN TITAN KING CAB HAS THE AIR BAG LIGHT FLASHING , I WAS ADVISE BY A MECHANIC THAT THERE'S A RECALL ON SAME VEHICLES JUST LIKE MINE, THE RECENT DEALER'S DIAGNOSIS CONFIRMS THAT THE WIRING FOR THE HARNESS ARE BROKEN AND IT'S REQUIRE TO BE REPLACED, THIS ISSUE APPLIES TO THE SAME DESCRIPTION ON THE RECALL CAMPAIGN # 06V459000 NISSAN CLAIMS MY VIN IT'S NOT ON THE RECALL , BUT THE PROBLEM IS THE SAME ,IT'S A SAFETY ISSUE AND SHOULD BE NISSAN,S RESPONSIBILITY TO REPAIR . THIS IS UNSAFE FOR ME ,MY FAMILY AND OTHER DRIVERS OUT THERE. I HOPE THE NATIONAL HIGHWAY SAFETY ADMINISTRATION OPEN A RECALL UNDER MY VIN RANGE. THIS CAN BE A SERIOUS SAFETY HAZARD . *TR
NHTSA ODI #10506014
150,000 miles · Apr 9, 2013
Engine
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE ENGINE EXHIBITED SEVERE HESITATION WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS, WHO STATED THAT THE EXHAUST MANIFOLD WAS FRACTURED ON BOTH SIDES. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE ENGINE EXHIBITED SEVERE HESITATION WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS, WHO STATED THAT THE EXHAUST MANIFOLD WAS FRACTURED ON BOTH SIDES. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10505674
60,000 miles · Apr 4, 2013
Power Train
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND ATTEMPTING TO SLOW THE VEHICLE DOWN, THE IT BEGAN TO MAKE A RUMBLING NOISE. WHEN THE VEHICLE STOPPED MOVING, THE DRIVE SHAFT FELL OUT. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSTIC TESTING. THE REAR AXLE AND DIFFERENTIAL WERE REPLACED. TWO Y…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND ATTEMPTING TO SLOW THE VEHICLE DOWN, THE IT BEGAN TO MAKE A RUMBLING NOISE. WHEN THE VEHICLE STOPPED MOVING, THE DRIVE SHAFT FELL OUT. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSTIC TESTING. THE REAR AXLE AND DIFFERENTIAL WERE REPLACED. TWO YEARS LATER THE VEHICLE BEGAN TO LEAK DIFFERENTIAL FLUID. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10507159
95,603 miles · Apr 3, 2013
Air BagsSeat Belts
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SIDE SEAT BELT RETENTIONER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS ALSO ADVISED BY THE DEALER THAT…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SIDE SEAT BELT RETENTIONER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS ALSO ADVISED BY THE DEALER THAT THE AIR BAG SENSOR UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 95,603. *TR
NHTSA ODI #10505501
170,000 miles · Apr 1, 2013
Power Train
FIRST OF ALL ,I WOULD LIKE TO SAY THAT MY TRUCK HAS HIGH MILES.I PURCHASED IT NEW, DEALER SERVICED ONLY.IN FACT MY TRUCK WAS SERVICED BY A DEALER IN MIAMI ON 3-28-13 FOR OIL CHANGE ,THE DAY BEFORE I LOST MY TRANSMISSION BECAUSE OF ,WHAT I NOW KNOW TO BE COMMON PLACE, A $5 COOLING TUBING THAT GOES TO THE TRANSMISSION. MY FIRST TH…
Read full complaint
FIRST OF ALL ,I WOULD LIKE TO SAY THAT MY TRUCK HAS HIGH MILES.I PURCHASED IT NEW, DEALER SERVICED ONLY.IN FACT MY TRUCK WAS SERVICED BY A DEALER IN MIAMI ON 3-28-13 FOR OIL CHANGE ,THE DAY BEFORE I LOST MY TRANSMISSION BECAUSE OF ,WHAT I NOW KNOW TO BE COMMON PLACE, A $5 COOLING TUBING THAT GOES TO THE TRANSMISSION. MY FIRST THOUGHT WAS MAYBE THE TECH AT THE DEALER BROKE THE TUBING SINCE ITS INCHES AWAY FROM THE OIL FILTER AND MY VEHICLE WAS SERVICED THERE HOURS BEFORE I LOST ALL MY FLUID,THEREFORE BURNING UP MY TRANSMISSION, YOU WOULD THINK THAT THE DEALERS WOULD CHECK THE TUBING SINCE ITS RIGHT IN THE TECH'S FACE WHILE CONDUCTING OIL CHANGES. OH WELL ,MY TRUCK WAS WELL MAINTAINED,STILL LOOKS GREAT,TOTALLY LOADED LE, MY TRANNY WENT DOWN WITHOUT WARNING,THIS WILL COST ME AROUND $6000.I`M A NISSAN MAN,I JUST PURCHASED THE NEW 2013 PATHFINDER FOR MY WIFE BACK IN DECEMBER BEFORE IT EVEN APPEARED ON THE STREETS, SHOULD I HAVE FEARS ABOUT DEFECTS WITH THIS ONE ? WHAT'S GOING ON NISSAN ? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10505269
86,000 miles · Feb 8, 2013
Engine
MY 2006 NISSAN TITAN WAS TAKEN IN FOR RECALLS. UPON COMPLETION OF THE WORK, WHICH WAS POORLY PERFORMED, I WAS NOTIFIED THAT BOTH OF MY MANIFOLDS WERE CRACKED AND WOULD NEED TO BE REPLACED WHICH WOULD COST ME OVER $2,000 BUT THE DEALER WOULD CUT ME A DEAL FOR $1,700 IF I WANTED TO DO IT RIGHT AWAY AND THEY ALSO THREATENED ME WITH…
Read full complaint
MY 2006 NISSAN TITAN WAS TAKEN IN FOR RECALLS. UPON COMPLETION OF THE WORK, WHICH WAS POORLY PERFORMED, I WAS NOTIFIED THAT BOTH OF MY MANIFOLDS WERE CRACKED AND WOULD NEED TO BE REPLACED WHICH WOULD COST ME OVER $2,000 BUT THE DEALER WOULD CUT ME A DEAL FOR $1,700 IF I WANTED TO DO IT RIGHT AWAY AND THEY ALSO THREATENED ME WITH THE FACT THAT I WOULD NOT PASS MY SMOG SO I HAD TO DO IT NOW. I DECLINED AS I COULD NOT AFFORD REPAIRS LIKE THAT. AFTER A SHORT SEARCH ONLINE I FOUND THAT THIS WAS A REGULAR ISSUE WITH TITANS BUT WAS NOT SUBMITTED FOR A RECALL. I HAVE ALSO SENT A COMPLAINT TO NISSAN. I AM QUITE DISAPPOINTED WITH THIS ISSUE AS WELL AS THE LACK OF SERVICE I HAVE RECEIVED FROM THE DEALER. MY FAMILY AND I HAVE ALWAYS BEEN STRONG SUPPORTERS OF NISSAN AND OWN MANY OF THEIR VEHICLES AND HAVE NEVER HAD ISSUES LIKE THIS THAT HAVE NOT BEEN ABLE TO BE RESOLVED. I WILL CONTINUE TO BUY NISSANS BUT HOPE THAT THIS WILL BE REVIEWED AND CLAIMED AS A RECALL. I CANNOT AFFORD THE REPAIRS AS MY HUSBAND AND I ARE BOTH CURRENTLY UNEMPLOYED WITH 4 CHILDREN AND THIS IS OUR ONLY VEHICLE WHICH WE CAN NO LONGER DRIVE BECAUSE WE CANNOT HAVE IT SMOGGED TO RENEW REGISTRATION. THERE IS NO DOUBT IN MY MIND THAT THE MANIFOLDS HAD BEEN CRACKED FOR SOME TIME PRIOR TO THE VISIT TO THE DEALER. WE HAD ALWAYS TAKEN OUR TRUCK TO THE DEALER BECAUSE WE HAD PURCHASED A GOLD PACKAGE FOR MAINTENANCE AND I HAD COMPLAINED ABOUT NOISE BEFORE AND THEY COULD NEVER FIND A PROBLEM. IT FIGURES THAT AS SOON AS IT IS OUT OF WARRANTY THEY WOULD MAGICALLY FIND THE ISSUE. *TR
NHTSA ODI #10496939
Official recalls
5Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration