IllustrationRIGHT REAR WHEEL SEAL IS LEAKING BADLY NOTICED AT 65000 MILES BUT IT LOOKS LIKE ITS BEEN LEAKING FOR A WHILE. THIS PROBLEM SEEMS TO BE FREQUENT AND IT ALSO SEEMS TO BE A SAFETY ISSUE IT OIL LEAKING ONTO THE BRAKES. *TR
2006 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2006 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
580–25K
7925–50K
10050–75K
6475–100K
51100–150K
24150K+
376 reports with mileage · 54 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 194 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports10 fire reports7 injury reports
Power Train complaints
194 reports2006 NISSAN TITAN REAR AXLE SEALS BEGAN LEAKING. VEHICLE HAS NEVER BEEN OFF THE PAVEMENT AND HAS HAD ALL MAINTENANCE PERFORMED BY THE OWNER MANUAL LIST. *TR
I NOTICED AN EXHAUST LEAK ON MY TRUCK. TOOK IT TO A REPUTABLE EXHAUST SHOP, THEY TOLD ME THEIR WAS A CRACK IN THE CONVERTER AND I NEEDED TO TAKE IT TO THE DEALERSHIP. AFTER CHECKING THE WEB I REALIZED IT WAS UNDER WARRANTY (80000 ON EXHAUST EMISSIONS) MY TRUCK ONLY HAD 65K. THEY REPLACED BOTH MANIFOLDS AS THEY WERE BOTH CRACKED.…
Read full complaint
I NOTICED AN EXHAUST LEAK ON MY TRUCK. TOOK IT TO A REPUTABLE EXHAUST SHOP, THEY TOLD ME THEIR WAS A CRACK IN THE CONVERTER AND I NEEDED TO TAKE IT TO THE DEALERSHIP. AFTER CHECKING THE WEB I REALIZED IT WAS UNDER WARRANTY (80000 ON EXHAUST EMISSIONS) MY TRUCK ONLY HAD 65K. THEY REPLACED BOTH MANIFOLDS AS THEY WERE BOTH CRACKED. THIS REPAIR WOULD HAVE COST ME 2500.00! AFTER SEEING THIS WAS A COMMON PROBLEM WITH THE TITAN TRUCKS, I THINK THIS SHOULD BE ADDRESSED. ALSO THE DEALERSHIP TOLD ME I HAD A FRONT DIFFERENTIAL LEAK WHICH WAS THE PINION SEAL, THIS REPAIR WILL COST ME 300-500.00. OF COURSE ITS NOT COVERED UNDER WARRANTY SO I WILL HAVE TO PAY THIS. AFTER SEEING THIS IS ALSO A COMMON PROBLEM, I FEEL NISSAN NEEDS TO CORRECT THIS ISSUE AS IT IS A SAFETY PROBLEM FOR BOTH ME AND FELLOW MOTORIST. MY TRUCK HAS 65,000 MILES AND IS BABIED! TOTAL REPAIRS WOULD BE AROUND 3000.00 FOR THE MANIFOLDS AND THE DIFFERENTIAL, I FEEL SOMETHING NEEDS TO BE DONE AS THIS IS AN ONGOING ISSUE. *TR
REAR AXLE SEALS LEAKING GEAR OIL. REPLACED BY CERTIFIED MECHANIC TWICE AND THE LEAK PERSISTS. *TR
I WAS HAVING MY VEHICLES FRONT DIFFERENTIAL FLUID CHANGED AND THE SERVICE TECHNICIAN NOTICED 2 CRACKS AROUND THE AXLE HOUSING. UPON FURTHER INSPECTION THE HOUSING WAS DAMAGED ENOUGH TO WEAR IT COULD LEAK AND CAUSE FAILURE. *TR
BOTH REAR AXLE SEALS STARTED LEAKING ALL OVER MY BRAKES AND INSIDE THE WHEEL WELL CAUSING POOR BREAKING ABILITY. I CALLED THE NISSAN DEALER AND THEY TOLD ME THIS IS A COMMON PROBLEM WITH TITANS AND THAT THEY NO LONGER RECOMMEND REPLACING JUST THE SEALS BUT INSTEAD THE WHOLE AXLE. THE TECH (WHO TOLD ME HE HAD 20 YRS WITH NISSAN…
Read full complaint
BOTH REAR AXLE SEALS STARTED LEAKING ALL OVER MY BRAKES AND INSIDE THE WHEEL WELL CAUSING POOR BREAKING ABILITY. I CALLED THE NISSAN DEALER AND THEY TOLD ME THIS IS A COMMON PROBLEM WITH TITANS AND THAT THEY NO LONGER RECOMMEND REPLACING JUST THE SEALS BUT INSTEAD THE WHOLE AXLE. THE TECH (WHO TOLD ME HE HAD 20 YRS WITH NISSAN) SAID THAT WHEN THEY USED TO JUST REPLACE THE SEALS PEOPLE WOULD HAVE TO COME BACK 6 MONTHS LATER BECAUSE THE SEALS WOULD BLOW AGAIN. ALL OF THE POSTS ONLINE SAY THAT IT IS A RESULT OF AN IMPROPER VENTING SYSTEM THAT DOES NOT ALLOW FOR THE RELEASE OF NEGATIVE PRESSURE. IF THIS IS SUCH A COMMON PROBLEM, AND NISSAN KNOWS THAT IT IS, WHY DON'T THEY DO A FULL RECALL? THIS IS A VERY DANGEROUS PROBLEM THAT CAN CAUSE BRAKE FAILURE. *TR
REAR AXLE SEAL, DRIVER SIDE, AND SOON AFTER, THE PASSENGER SIDE AS WELL, FAILED. DIFFERENTIAL FLUID LEAKED OUT ONTO INNER WHEEL SURFACE, BRAKE PARTS, AND IMMEDIATE AREA CREATING HAZARDOUS CONDITIONS. THIS IS A WIDELY KNOWN PROBLEM FOR NISSAN TITAN OWNERS AND NISSAN IS, AND HAS BEEN, WELL AWARE OF THIS PROBLEM AND HAS NOT OFFE…
Read full complaint
REAR AXLE SEAL, DRIVER SIDE, AND SOON AFTER, THE PASSENGER SIDE AS WELL, FAILED. DIFFERENTIAL FLUID LEAKED OUT ONTO INNER WHEEL SURFACE, BRAKE PARTS, AND IMMEDIATE AREA CREATING HAZARDOUS CONDITIONS. THIS IS A WIDELY KNOWN PROBLEM FOR NISSAN TITAN OWNERS AND NISSAN IS, AND HAS BEEN, WELL AWARE OF THIS PROBLEM AND HAS NOT OFFERED A DESIGN SOLUTION TO MY KNOWLEDGE. NEARLY EVERY TITAN EXPERIENCES THIS SEAL FAILURE AT SOME POINT. SOME WHILE STILL UNDER WARRANTY, (WHICH TYPICALLY GET REPAIRED BY NISSAN) BUT AS FOR THE REST OF US WHO ARE BEYOND OUR WARRANTIES, WE ARE LEFT WITH THIS HAZARDOUS CONDITION AND A BIG REPAIR BILL. **THIS SHOULD BE A RECALL, OR AT LEAST REPAIRED BY NISSAN AT THEIR EXPENSE. ITS MY UNDERSTANDING THAT THERE WAS A TECHNICAL SERVICE BULLETIN OUTLINING THE ISSUEFOR NISSAN MECHANICS. PLEASE HELP** *TR
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE REAR DIFFERENTIAL CRACKED WHILE DRIVING 55 MPH AND CAUSED DIFFERENTIAL FLUID TO LEAK FROM THE REAR DRIVER SIDE TIRE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIO…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE REAR DIFFERENTIAL CRACKED WHILE DRIVING 55 MPH AND CAUSED DIFFERENTIAL FLUID TO LEAK FROM THE REAR DRIVER SIDE TIRE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THE SAME FAILURE BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 64,000.
MY 2006 NISSAN TITAN HAS AN AXEL SEAL FAILURE ON THE DRIVERS SIDE REAR, DIFFERENTIAL FLUID IS LEAKING ONTO THE REAR BRAKES CAUSING REDUCED BRAKING AND ALSO THE POTENTIAL FOR AXLE/DIFFERENTIAL FAILURE. NISSAN REFUSES TO ADDRESS THIS DESIGN FLAW. THEY HAVE A RE-ENGINEERED REPLACEMENT AXLE SHAFT AND SEAL AT A COST OF ABOUT $800 PER…
Read full complaint
MY 2006 NISSAN TITAN HAS AN AXEL SEAL FAILURE ON THE DRIVERS SIDE REAR, DIFFERENTIAL FLUID IS LEAKING ONTO THE REAR BRAKES CAUSING REDUCED BRAKING AND ALSO THE POTENTIAL FOR AXLE/DIFFERENTIAL FAILURE. NISSAN REFUSES TO ADDRESS THIS DESIGN FLAW. THEY HAVE A RE-ENGINEERED REPLACEMENT AXLE SHAFT AND SEAL AT A COST OF ABOUT $800 PER SIDE. THIS SHOULD BE A RECALL NOT $1600 OUT OF MY POCKET TO FIX. WILL NISSAN AND NTSB WAIT UNTIL THERE ARE FATALITIES BEFORE THEY ADDRESS THIS COMMON ISSUE WITH THE NISSAN TITANS? *TR
JUST REPLACED THE REAR SEALS FOR A NISSAN TITAN 2006. PROBLEM BEGAN AT 65,000 MILES. I WAS TOLD THAT LACK OF FLUID DUE TO LEAKING COULD CAUSE THE VEHICLE TO LOCK-UP WHILE DRIVING. THE INTERNET IS FILLED WITH COMPLAINTS REGARDING THIS ISSUE. THIS SEEMS TO BE A MAJOR SAFETY PROBLEM. ALSO HAD TAILPIPE ISSUES (DROPPING FROM THE TRUC…
Read full complaint
JUST REPLACED THE REAR SEALS FOR A NISSAN TITAN 2006. PROBLEM BEGAN AT 65,000 MILES. I WAS TOLD THAT LACK OF FLUID DUE TO LEAKING COULD CAUSE THE VEHICLE TO LOCK-UP WHILE DRIVING. THE INTERNET IS FILLED WITH COMPLAINTS REGARDING THIS ISSUE. THIS SEEMS TO BE A MAJOR SAFETY PROBLEM. ALSO HAD TAILPIPE ISSUES (DROPPING FROM THE TRUCK) WHICH IS ALSO WELL DOCUMENTED ON THE INTERNET AND, AGAIN, A SAFETY PROBLEM. NEEDS TO BE RECALLED. *TR
Official recalls
510V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V064000 · Latches/locks/linkages:doors:latch
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.