NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
194 reportsClear category filter66,590 miles · Dec 19, 2013
Power TrainStructureCrash
TRAVELING 20 TO 25 MPH, UP A HILL, IN 4 WHEEL DRIVE ROAD CONDITIONS WHEN THERE WAS A LOUD "BANG". THE REAR OF THE VEHICLE IMMEDIATELY SHIFTED TO THE RIGHT, STRIKING A TREE. NEVER WOULD YOU EXPECT A VEHICLE TO BRAKE IN SUCH A WAY AS TO THROW YOU INTO ONCOMING TRAFFIC. I BELIEVE THAT THIS DEFECT SHOULD BE IMMEDIATELY INVESTIGATE…
Read full complaint
TRAVELING 20 TO 25 MPH, UP A HILL, IN 4 WHEEL DRIVE ROAD CONDITIONS WHEN THERE WAS A LOUD "BANG". THE REAR OF THE VEHICLE IMMEDIATELY SHIFTED TO THE RIGHT, STRIKING A TREE. NEVER WOULD YOU EXPECT A VEHICLE TO BRAKE IN SUCH A WAY AS TO THROW YOU INTO ONCOMING TRAFFIC. I BELIEVE THAT THIS DEFECT SHOULD BE IMMEDIATELY INVESTIGATED AND A RECALL ISSUED. DEALER SERVICE DEPARTMENT DETERMINED THAT THE FRONT DIFFERENTIAL AND TRANSFER CASE HAD TO BE REPLACED DUE TO CATASTROPHIC FAILURE. THE FRONT AXLE HAD BACKED OUT RESULTING IN FLUID LEAKING OUT. I WAS TOLD THAT THIS WAS A KNOWN DEFECT THAT HAD BEEN REDESIGNED. *TR
NHTSA ODI #10556752
65,000 miles · Nov 9, 2013
Electrical SystemPower TrainUnknown Or Other
SITTING OVERNIGHT WITH TEMPERATURE IN THE 40'S, WHEN PUTTING THE AUTOMATIC TRANSMISSION INTO DRIVE,IT WOULD KEEP DROPPING OUT OF GEAR. THE TRUCK DROVE FINE WHEN MANUALLY SHIFTING THROUGH THE GEARS. PROBLEM CONTINUED FOR MOST OF A YEAR BUT DID NOT GENERATE AN ERROR CODE. FINALLY DEVELOPED AN ERROR CODE INDICATING PROBLEM IN FIRST…
Read full complaint
SITTING OVERNIGHT WITH TEMPERATURE IN THE 40'S, WHEN PUTTING THE AUTOMATIC TRANSMISSION INTO DRIVE,IT WOULD KEEP DROPPING OUT OF GEAR. THE TRUCK DROVE FINE WHEN MANUALLY SHIFTING THROUGH THE GEARS. PROBLEM CONTINUED FOR MOST OF A YEAR BUT DID NOT GENERATE AN ERROR CODE. FINALLY DEVELOPED AN ERROR CODE INDICATING PROBLEM IN FIRST GEAR OF THE TRANSMISSION VALVE BODY WITH TCM. THIS REQUIRED REPLACEMENT OF VALVE BODY INTERNAL TO THE TRANSMISSION, WHICH HAD BEEN CONTAMINATED BY AN UNDETECTABLE RADIATOR TO TRANS COOLER LEAK ALSO REQUIRING THE RADIATOR TO BE REPLACED. I HAVE BEEN TOLD THIS IS NOT AN UNCOMMON PROBLEM, FOR WHICH NISSAN HAS DONE NOTHING, OTHER THAN PUTTING A SPECIAL COATING ON BOLTS INTERNAL TO THE TRANSMISSION TO DETECT THE PRESENCE OF COOLANT. THIS PROBLEM CAN CAUSE COMPLETE FAILURE OF THE TRANSMISSION. IT COULD BE EASILY PREVENT BY THE INSTALLATION OF A SEPARATE TRANSMISSION COOLER. *TR
NHTSA ODI #10551621
122,000 miles · Nov 1, 2013
Power TrainService Brakes
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED AFTER HAVING NHTSA CAMPAIGN I.D. NUMBERS REMEDIED ON THE VEHICLE 10V074000 (FUEL SYSTEM) AND 10V517000 (ENGINE). AFTER THE VEHICLE WERE REPAIRED THE POWER TRAIN WAS DEFECTIVE. THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE OFF OF THE DEALERS PARKING LOT. THE VEHICLE WOUL…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED AFTER HAVING NHTSA CAMPAIGN I.D. NUMBERS REMEDIED ON THE VEHICLE 10V074000 (FUEL SYSTEM) AND 10V517000 (ENGINE). AFTER THE VEHICLE WERE REPAIRED THE POWER TRAIN WAS DEFECTIVE. THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE OFF OF THE DEALERS PARKING LOT. THE VEHICLE WOULD NOT MOVE FORWARD OR IN REVERSE. THE DEALER PERFORMED A DIAGNOSTIC TEST THAT DISPLAYED A DEFECT TO THE FRONT BRAKE SOLENOID. THE CONTACT CALLED THE MANUFACTURER REGARDING THE POWER TRAIN DEFECT. THE MANUFACTURER STATED THE RECALL REPAIR AND THE BRAKE SOLENOID WAS UNRELATED. THE CONTACT DID NOT HAVE THE SOLENOID REPAIRED. THE FAILURE MILEAGE WAS 122,000.
NHTSA ODI #10550554
91,646 miles · Sep 22, 2013
Power Train
HEARD NOISE IN TRANSFER CASE, TOOK IN TO MECHANIC TO HAVE PROBLEM CHECKED. FOUND OUT ANTI-FREEZE AND TRASMISSION FLUID WERE MIXED TOGETHER. TRANSMISSION HAD TO BE REBUILT. AFTER REPAIR NEEDED ADDITIONAL REPAIR TO REPAIR TRANSMISSION LINE THAT HAD CAME OFF.
NHTSA ODI #10544879
47,000 miles · Aug 29, 2013
Power TrainService Brakes
I OWN A 2006 NISSAN TITAN WITH 47000 MILES. PARTIAL VIN "1N6BA07A0" WHILE TAKING IT TO THE LOCAL MIDAS SHOP FOR AN OIL CHANGE. THE MECHANIC POINTED OUT A LEAK ON LEFT REAR AXLE SEAL. THEY QUOTED ME WITH $350.00 TO REPLACE THE SEAL. HOWEVER THEY ALSO SUGGESTED TO HAVE THE DEALERSHIP ATTEMPT TO REPLACE UNDER A RECALL/ WARRANTY.…
Read full complaint
I OWN A 2006 NISSAN TITAN WITH 47000 MILES. PARTIAL VIN "1N6BA07A0" WHILE TAKING IT TO THE LOCAL MIDAS SHOP FOR AN OIL CHANGE. THE MECHANIC POINTED OUT A LEAK ON LEFT REAR AXLE SEAL. THEY QUOTED ME WITH $350.00 TO REPLACE THE SEAL. HOWEVER THEY ALSO SUGGESTED TO HAVE THE DEALERSHIP ATTEMPT TO REPLACE UNDER A RECALL/ WARRANTY... THE DEALERSHIP QUOTED $1900.00 TO REPLACE THE WHOLE REAR AXLE UNDER THE GUIDANCE FROM THEIR TECHNICIANS AND IT BEING OVER THE MANUFACTURES WARRANTY AND/OR NO RECALL. THIS SOUNDS LIKE A RIPOFF. HERE IS A QUOTE I FOUND ON THE CLUB TITAN FORUM SITE. HTTP://WWW.CLUBTITAN.ORG/FORUMS/ARCHIVE/INDEX.PHP/T-32631.HTML "LEFT REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENTIAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTORS WHICH COULD CAUSE BRAKE FAILURE, WHICH WAS A MAJOR SAFETY CONCERN TO ME. AT TIME OF FAILURE AT 8000 MILES NO SUSPENSION MODIFICATIONS HAD BEEN DONE TO VEHICLE. ALSO, THE REAR DIFFERENTIAL OIL WILL SLOWLY LEAK AND CAUSE THE REAR DIFFERENTIAL TO LOSE FLUID AND FAIL. NISSAN REPLACED SPACER AXLE (43070-7S200), BEARING (40210-7S210), AND SEAL (43252-7S200). AS THIS SEEMED TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD ADDRESS THIS ISSUE AND OFFER A PERMANENT FIX SO WEOULD NOT BE FACED WITH THE SAFETY ISSUE IN THE FUTURE. *AK"
NHTSA ODI #10537834
90,000 miles · Jul 9, 2013
Power Train
TODAY I FOUND THAT MY REAR AXLE OIL SEALS ARE LEAKING. IT IS SO BAD THAT THE OIL IS GETTING ON THE REAR BRAKES. WHICH MAKES SENSE CONSIDERING I HAVE NOTICED THAT MY REAR BRAKES ARE NOT FUNCTIONING PROPERLY. THIS PROBLEM NEEDS TO BE ADDRESSED WITH BETTER OIL SEALS SO THAT THIS DOES NOT HAPPEN TO ANYONE ELSE. *TR
NHTSA ODI #10523973
135,260 miles · Apr 23, 2013
Power Train
LEFT REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENITAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTOR WHICH COULD CAUSE BRAKE FAILURE. THIS IS A MAJOR SAFETY CONCERN TO ME. THE LEAKING DIFFERENTIAL FLUID WILL CAUSED THE REAR DIFFERENTIAL TO FAIL. THIS SEEMS TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD A…
Read full complaint
LEFT REAR AXLE SEAL BLEW OUT AND LEAKED DIFFERENITAL FLUID. DIFFERENTIAL FLUID LEAKING ON REAR BRAKE ROTOR WHICH COULD CAUSE BRAKE FAILURE. THIS IS A MAJOR SAFETY CONCERN TO ME. THE LEAKING DIFFERENTIAL FLUID WILL CAUSED THE REAR DIFFERENTIAL TO FAIL. THIS SEEMS TO BE A VERY COMMON PROBLEM WITH THE NISSAN TITAN, NISSAN SHOULD ADDRESS THIS ISSUE AND OFFER A PERMANENT FIX SO TITAN OWNERS WOULD NOT HAVE TO DEAL WITH THIS SAFETY ISSUE IN THE FUTURE. *TR
NHTSA ODI #10509292
60,000 miles · Apr 4, 2013
Power Train
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND ATTEMPTING TO SLOW THE VEHICLE DOWN, THE IT BEGAN TO MAKE A RUMBLING NOISE. WHEN THE VEHICLE STOPPED MOVING, THE DRIVE SHAFT FELL OUT. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSTIC TESTING. THE REAR AXLE AND DIFFERENTIAL WERE REPLACED. TWO Y…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND ATTEMPTING TO SLOW THE VEHICLE DOWN, THE IT BEGAN TO MAKE A RUMBLING NOISE. WHEN THE VEHICLE STOPPED MOVING, THE DRIVE SHAFT FELL OUT. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSTIC TESTING. THE REAR AXLE AND DIFFERENTIAL WERE REPLACED. TWO YEARS LATER THE VEHICLE BEGAN TO LEAK DIFFERENTIAL FLUID. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10507159
170,000 miles · Apr 1, 2013
Power Train
FIRST OF ALL ,I WOULD LIKE TO SAY THAT MY TRUCK HAS HIGH MILES.I PURCHASED IT NEW, DEALER SERVICED ONLY.IN FACT MY TRUCK WAS SERVICED BY A DEALER IN MIAMI ON 3-28-13 FOR OIL CHANGE ,THE DAY BEFORE I LOST MY TRANSMISSION BECAUSE OF ,WHAT I NOW KNOW TO BE COMMON PLACE, A $5 COOLING TUBING THAT GOES TO THE TRANSMISSION. MY FIRST TH…
Read full complaint
FIRST OF ALL ,I WOULD LIKE TO SAY THAT MY TRUCK HAS HIGH MILES.I PURCHASED IT NEW, DEALER SERVICED ONLY.IN FACT MY TRUCK WAS SERVICED BY A DEALER IN MIAMI ON 3-28-13 FOR OIL CHANGE ,THE DAY BEFORE I LOST MY TRANSMISSION BECAUSE OF ,WHAT I NOW KNOW TO BE COMMON PLACE, A $5 COOLING TUBING THAT GOES TO THE TRANSMISSION. MY FIRST THOUGHT WAS MAYBE THE TECH AT THE DEALER BROKE THE TUBING SINCE ITS INCHES AWAY FROM THE OIL FILTER AND MY VEHICLE WAS SERVICED THERE HOURS BEFORE I LOST ALL MY FLUID,THEREFORE BURNING UP MY TRANSMISSION, YOU WOULD THINK THAT THE DEALERS WOULD CHECK THE TUBING SINCE ITS RIGHT IN THE TECH'S FACE WHILE CONDUCTING OIL CHANGES. OH WELL ,MY TRUCK WAS WELL MAINTAINED,STILL LOOKS GREAT,TOTALLY LOADED LE, MY TRANNY WENT DOWN WITHOUT WARNING,THIS WILL COST ME AROUND $6000.I`M A NISSAN MAN,I JUST PURCHASED THE NEW 2013 PATHFINDER FOR MY WIFE BACK IN DECEMBER BEFORE IT EVEN APPEARED ON THE STREETS, SHOULD I HAVE FEARS ABOUT DEFECTS WITH THIS ONE ? WHAT'S GOING ON NISSAN ? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10505269
89,000 miles · Dec 7, 2012
Power Train
FRONT PINION SEAL LEAKING POSSIBLY GET ON EXHAUST AND CAUSE A FIRE AND DESTROY ELECTRICAL WIRING. *TR
NHTSA ODI #10487627
Official recalls
5Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration